2019 Honda Insight

2019 Honda Insight 4 DR FWD

Overall

★★★★★

Front Crash

★★★★★

Side Crash

★★★★★

Rollover

★★★★★

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Honda (American Honda Motor Co.) is recalling certain 2018-2019 Acura NSX, 2019 Acura RDX, RLX and RLX Sport Hybrid, 2018-2019 Honda Accord, Civic Hatchback, Civic Type R and HR-V, 2019-2020 Insight and 2019 Fit vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Campaign: 20V314000

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

Honda (American Honda Motor Co.) is recalling certain 2018-2020 Accord Sedan, Accord Hybrid, and 2019-2020 Insight vehicles. A software error may cause intermittent or continuous disruptions in communication between the Body Control Module (BCM) and other components. This may result in malfunctions of various systems such as the windshield wipers and defroster, rearview camera, exterior lights, audible warning of a stopped vehicle, and power window operation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 103, "Windshield Defrosting and Defogging Systems" and number 111, "Rear Visibility" as well as FMVSS numbers 104, 108, 114, 118, and 305.

Campaign: 20V771000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Campaign: 21V215000

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Honda (American Honda Motor Co.) is recalling certain 2018 Honda Accord and 2019 Honda Insight vehicles. In certain scenarios, the back-up camera center display may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Campaign: 18V629000

SEAT BELTS:PRETENSIONER

Honda (American Honda Motor Co.) is recalling certain 2019 Honda Insight, Odyssey, and Ridgeline vehicles. The Supplemental Restraint System (SRS) control unit may have a manufacturing error, possibly resulting in the air bags or seatbelt pretensioners not deploying in the event of a crash.

Campaign: 18V664000

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Honda (American Honda Motor Co.) is recalling certain 2017-2020 CR-V, 2018-2019 Accord and Accord Hybrid, 2018-2020 Odyssey, 2019 Insight, and 2019-2020 Acura RDX vehicles. A manufacturing issue with the front seat belts may cause the seat belt buckle channel to interfere with the release button, preventing the seat belt buckle from latching.

Campaign: 23V158000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.

Campaign: 23V858000

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER

Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.

Campaign: 26V332000

AIR BAGS

The car was last driven and parked at about 8:30pm local time. At around noon the next day, we noticed that the dashboard in the vicinity of the passenger airbag was melted with an approximately 12-inch hole. There was soot staining the interior of the vehicle, and the windshield was burned and cracked above the hole in the dashboard.

UNKNOWN OR OTHER

The A/C evaporator failed due to a refrigerant leak caused by corrosion. The component is available for inspection upon request at the dealership where it was diagnosed. The failure resulted in complete loss of air conditioning. In hot weather conditions, particularly during highway driving and stop-and-go traffic, loss of A/C poses a risk of heat-related illness to the driver, especially in high-temperature climates. The defect was confirmed by a Honda dealership technician during an inspection in May 2026. The service advisor explicitly stated that the evaporator is manufactured from the same defective material as the A/C condenser, which Honda already acknowledged as a manufacturing defect under Service Bulletin 21-016. A Honda corporate customer relations representative independently confirmed the same information — that the evaporator shares the same material and is subject to the same corrosion issue. No warning lamps or messages appeared prior to failure. The first symptom was warm air blowing from vents, which progressively worsened until A/C stopped functioning entirely. Honda repaired the condenser under Service Bulletin 21-016 at no charge but refused to cover the evaporator repair, quoting approximately $2,600 out of pocket despite acknowledging the same root cause. I am requesting NHTSA investigate whether a recall or additional service bulletin covering the A/C evaporator on 2019-2021 Honda Insight vehicles is warranted, as other owners are likely experiencing the same defect.

EXTERIOR LIGHTING

The daytime running lights started to fade it till there was nothing. I was told it would be over $2000 to fix

ELECTRICAL SYSTEM

The contact owns a 2019 Honda Insight. The contact stated that while driving 75 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, several unknown warning lights were illuminated. The contact stated that the failure had occurred while driving on a busy highway. The vehicle was driven onto the off-ramp and turned off the vehicle. The vehicle was started; however, the failure reoccurred. The vehicle was taken to the dealer, where it was diagnosed with a corroded connector and broken pin at the leak detection pump in the rear of the vehicle. The contact was informed that the leak detection module and wiring harness needed to be replaced. The vehicle was not repaired. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 81,000.

POWER TRAIN,ELECTRICAL SYSTEM

Car was put into reverse to perform a T turn to drive in the opposite direction on 1/14. The "D" button was depressed to place the car into Drive. The car quickly accelerated backwards and crashed into the mailbox. Service Advisor at the David McDavid Honda Dealership was contacted yesterday regarding the issue but no response has been received yet. It is unknown if the backup camera was visible since attempts were being made to try to stop the car. Not much time was allowed.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

Back up camera stopped working, no blown fuses and the system updates I can do on the car from the touch screen say everything is up to date. My car has no open/not repaired recall for this.

FORWARD COLLISION AVOIDANCE

The Honda Sensing suite's CMBS uses a combination of a front-facing camera and a radar sensor, it detected a sewerage as a hole and steel plates as a hole and made a sudden unsafe stop. Collision Mitigation Braking System (CMBS) experiencing a false positive. We were going to like 15-20 over the steel plate and it made an emergency unsafe stop. It keeps doing it over and over. At this point it’s becoming really unsafe so I wanted to report it. It stopped all of sudden and made my neck in pain as my wife’s back. No the problem has not been talked to the dealer or they never told me about this kinds of problems will happen. No any warning lamps.

UNKNOWN OR OTHER,SERVICE BRAKES

While stopped at a train track, I used the Brake Hold feature and it was on when suddenly without touching peddles the car went forward and I hit the car in front of me

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

On [XXX] while driving my 2019 Honda Insight Touring at approximately 35 mph on [XXX] , the vehicle’s automatic emergency braking system suddenly activated without any obstacle present. The car braked very hard, creating a dangerous situation in traffic. This was not the first time it has happened. The same issue occurred on two separate occasions in 2022, also with no vehicles or obstacles nearby. Each time, the system engaged abruptly and without warning. I am concerned about the safety risk of the Collision Mitigation Braking System (CMBS) activating erroneously, as it could easily cause a rear-end collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER,VISIBILITY/WIPER

The air conditioning system in my 2019 Honda Insight Touring Edition has failed three times in the last 3 years. Why is this a safety issue? In Southern California summer temperatures reach into the 90s and driving without air conditioning is impossible for any distance. For example today it is 93 degrees Fahrenheit in Los Angeles. It's impossible to use my car without air conditioning. Additionally, the A/C failure causes water vapor to condense on the windshield glass making it difficult to see through it and is an additional safety issue. The AC failure in the Honda Insights is a known issue to Honda USA. They have extended warranties of the air conditioning units to 10 years. This acknwledgement proves that Honda know of the issue and don't want to resolve it for consumers.