2005 Honda Odyssey

2005 Honda Odyssey w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Delphi Automotive Systems, LLC (Delphi) is recalling certain replacement fuel pump modules, part number FG1155-11B1, sold for use in 2005-2010 Honda Odyssey vehicles. The affected fuel pump may send an incorrect fuel reading to the fuel gauge possibly causing the vehicle to run out of fuel. The fuel gauge will always read 3/4 full to full regardless of the actual level.

Campaign: 14E049000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

American Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.

Campaign: 14V112000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2007 ODYSSEY AND ACURA RL VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS A LUBRICANT FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Campaign: 10V504000

STRUCTURE:BODY:HATCHBACK/LIFTGATE

HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.

Campaign: 10V055000

STEERING:COLUMN

ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.

Campaign: 05V039000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.

Campaign: 05V132000

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

THE FRONTAL AIR BAG SYSTEM HAS TWO EXTERNAL IMPACT SENSORS. ON CERTAIN MINI VANS,SOME SENSORS WERE INSUFFICIENTLY SEALED DURING MANUFACTURING. IF WATER ENTERS A SENSOR, CORROSION CAN OCCUR. CORRODED SENSORS COULD SHORT CIRCUIT INTERNALLY. IF SENSORS FAIL, THE SRS WARNING LAMP ON THE INSTRUMENT PANEL WILL TURN ON AND REMAIN ILLUMINATED.

Campaign: 05V344000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

ON CERTAIN VEHICLES, A COIL WIRE INSIDE THE FUEL PUMP RELAY MAY BREAK, CAUSING THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.

Campaign: 07V097000

SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

ON CERTAIN MINIVANS, THE ANTI-LOCK BRAKE SYSTEM (ABS) USES A SENSOR ON EACH WHEEL TO DETECT WHEEL SPEED. SOME SENSORS ON THE REAR WHEELS WERE INSTALLED INCORRECTLY, WHICH MEANS THE SENSOR MAY REPORT THE WRONG WHEEL SPEED TO THE ABS CONTROL UNIT.

Campaign: 04V536000

ENGINE

I bought the 2005 Odyssey van in 12/2015. It now has 192,426 miles on it. Three or four times every year since I bought it, the engine will suddenly surge when coming to a stop sign or light, with my right foot on the brake pedal, braking and slowing the van for the stop sign or light. The engine revs to about 5000 or 6000 RPMs. It is as if the engine is flooring the gas pedal. Every time, I have been able to push the brake pedal down hard, even though the car continues to slowly roll forward, and shove it into neutral. I have to then tap the gas pedal to stop the engine accelerating. It then goes back to idling normally. Note, it even happened to me one time when I put it into reverse while parking! So very scary each and every time it happens. On [XXX], I took the van to Don Jacobs Honda Dealership, Lexington, KY. They said there were no reports of this ever happening to anyone else. They charged me $3216.06, with most of the cost for a new timing belt/water pump and a valve adjustment. When their repairs did not solve the problem, I called them. They said they would like to put a monitor on the van and drive it until the surge happened again. I told them to let me drive the van with the monitor, as the next surge might not happen for several months, and I needed to drive the van on a daily basis for work. They said they weren't allowed to let customers use the monitor! I finally had time today to research the surging problem. I noticed on [XXX] that this problem with Honda has never been figured out or fixed! And it keeps happening on even newer Honda Odysseys! I now have the resources to quit driving this van. I would be willing to donate the van to the NHTSA so that they may research and try to figure out how to stop this defect! No telling how many people have been injured or killed due to this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EXTERIOR LIGHTING,ENGINE

The engine VCM system is burning oil and destroying emissions systems on the vehicle. Catalytic converters are mainly affected as burned oil goes through the exhaust system. The check engine light comes on and the the engine starts to misfire and very abrupt engine vibrations make it into the cabin.

POWER TRAIN,ENGINE

The transmission was making noise and missing and the vehicle was not picking up speed.

TIRES

I Purchased Cooper Evolution M+S 235/65 R16 tires that I purchased from Tire kingdom at 220 Linto BLVD Delray Beach FL. 33444. The set of tires have low miles on them and tread wear is great. When I got the tires I felt a vibration in the tires from the front pretty quickly. I had my whole front end of my car replaced including beairings, no help. So I spent money and replaced the 2 front tires with the same tires and they were very young tires and a wheel alignment and the shaking was mitigated in the front but the car still vibrated slightly. The wheel alignment had the steering wheel off center so I went back another wheel alignment to correct and I mention to them the car is vibrating still if they can inspect the tires and when we looked the front LH tire had tread seperation which looked like someone took a knife andtried to carve the tread at the seem off the tire it went in about 3 inches plus. Tire kingdom accused me of hitting something I was like we barley drive this car and why would and I hit absolutely nothing. So they analyzed it and prorated me another tire of the same brand. So now we are on 7 new tires for one mini van that barely gets driven. I went to Orlando and my back rear of the van was vibrating the last 10 miles I had to take the side streets. I went to Walmart and purchased brand new Good years for my van and there is now zero vibration I love it. My my van has been vibrating the day I got the Cooper Evolutions and I went through 7 tires a new front end and replaced rear spindles because I could believe tire with such amazing tread life would vibrate a car like that. If I went for a prorated #8 tire I would still have vibrations. I called cooper tires to complian they gave me a claim number 2003880477 and said bring to tire kindom who refused the tires. We called back Cooper who only again said bring to tire kingdom . I have all 4 tires waiting to be inspected with the 4th tire completly out of shape without air in it. Tire kindome no help

CHILD SEAT

The contact owns a Dorel Disney Baby Car Seat, Model Name: Light ‘N Comfy 35, Manufactured Date: August 06, 2021, installed in a 2005 Honda Odyssey. The contact stated while placing the car seat onto the base in the vehicle, the car seat would not latch securely. The manufacturer was contacted and stated that the car seat was not included in a recall. The car seat was not replaced.

STRUCTURE

I have a 2005 Honda Odyssey. About 6 months ago the drivers side sliding door fell off the tracks. This happened while we were trying to close the door but it would not slide at all. We were out at a restaurant and it was imperative that the door had to be shut because it was not safe to drive in that condition. We were able to somewhat put it back on but it can not be used at all at this time. When the door fell off, it gouged the side of the van, damaged the gas filler door, and the rear door is hard to close. I don't know if its closed or not until I get in the car and see that the indicator light on. Also, the car alarm goes off on its own even though my son disabled it. It's very disruptive. After do some research, I have learned that this is an ongoing problem with Honda Odysseys. Honda needs to be held responsible because this is obviously a manufacturer defect. I can not afford to spend $1000 to replace it nor should it have to spend money to fix it.

ELECTRICAL SYSTEM

The sliding doors would not open by any of the control switches and would not open manually to allow persons seated in back two rows to exit in emergency.

ELECTRICAL SYSTEM

Van turns off while driving after front lights is turn on or radio with charging a phone

STEERING,SERVICE BRAKES,ENGINE

The contact owns a 2005 Honda Odyssey. The contact stated while driving approximately 25 MPH, the vehicle lost motive power, power steering and braking functionality before the vehicle stalled. The contact was able to coast into a parking lot. The contact did not notice any warning lights being illuminated. The contact had the vehicle towed to her residence. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the drive belt needed to be replaced. The vehicle was repaired. The contact stated that the vehicle had become difficult to turn with the occasional recurring loss of power steering functionality. The contact related the steering failure to NHTSA Campaign Number: 05V039000 (Steering). The manufacturer had not been informed of the failure. The failure mileage was approximately 190,000.

ELECTRICAL SYSTEM

The contact owns a 2005 Honda Odyssey. The contact stated that the battery would intermittently drain overnight while the vehicle was turned off. The contact had taken the vehicle to several dealers including New Century Honda (1235 S Brand Blvd, Glendale, CA 91204), AutoNation Honda Valencia (23551 Magic Mountain Pkwy, Valencia, CA 91355) and several independent mechanics who replaced the battery; however, the mechanics were unable to determine the cause of the failure. The contact stated that the battery would last for a three to six-month period before the failure would occur again. The manufacturer was not notified of the failure. Upon his own investigation, the contact stated that the failure may be linked to the rear driver sliding door after the door failed to open electronically, and could only be opened manually. The vehicle was not repaired. The failure mileage was approximately 100,000. The contact states that there is an issue with the rear sliding door. This may be the cause of the battery drainage since the door often cannot be electrically opened, only manually.