2006 Hyundai Azera

2006 Hyundai Azera 4-DR w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Hyundai Motor America (Hyundai) is recalling certain 2006-2011 Hyundai Azera and 2006 Hyundai Sonata vehicles. Water may enter the Anti-lock Brake (ABS) Module and result in an electrical short .

Campaign: 18V026000

EXTERIOR LIGHTING:HEADLIGHTS

HYUNDAI-KIA IS RECALLING 4,085 REPLACEMENT HEADLAMP ASSEMBLIES SOLD FOR USE ON 2006-2008 SONATA AND AZERA VEHICLES. THESE HEADLAMP ASSEMBLIES MAY NOT HAVE BEEN ALIGNED PROPERLY AND FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 08E021000

SUSPENSION:REAR

Hyundai is recalling certain model year 2006-2010 Sonata vehicles manufactured March 1, 2005, through January 21, 2010; and model year 2006-2011 Azera vehicles manufactured September 27, 2005, through November 22, 2010 originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt and water can enter portions of the rear crossmember, leading to corrosion of the crossmember steel. This may lead to detachment of one of the rear control arms.

Campaign: 13V354000

AIR BAGS:FRONTAL

HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 AZERA VEHICLES MANUFACTURED FROM SEPTEMBER 27, 2005, THROUGH OCTOBER 1, 2008. THE WIRING HARNESS FOR THE RIGHT FRONT SEAT BELT TENSION SENSOR MAY SUSTAIN DAMAGE AFTER REPEATED USE OF THE SEAT BELT. IF THE SEAT BELT TENSION SENSOR WIRING BECOMES DAMAGED THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH NECESSITATING FRONT AIR BAG DEPLOYMENT.

Campaign: 09V497000

EXTERIOR LIGHTING

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Campaign: 09V280000

AIR BAGS:FRONTAL

HYUNDAI DE PUERTO RICO IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 AZERA VEHICLES MANUFACTURED FROM SEPTEMBER 27, 2005, THROUGH OCTOBER 1, 2008. THE WIRING HARNESS FOR THE RIGHT FRONT SEAT BELT TENSION SENSOR MAY SUSTAIN DAMAGE AFTER REPEATED USE OF THE SEAT BELT. IF THE SEAT BELT TENSION SENSOR WIRING BECOMES DAMAGED THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH NECESSITATING FRONT AIR BAG DEPLOYMENT.

Campaign: 10V007000

SUSPENSION,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

When driving, if you encounter even a small bump in the road, the car jumps as if it were a train jumping the tracks and getting back on track. If it's raining, it feels as though the vehicle is sliding across the road. (Finally, realizing that I WAS sliding across the road).

SUSPENSION,STRUCTURE

The contact owns a 2006 Hyundai Azera. The contact stated while driving at an undisclosed speed, the rear driver's side wheel unexpectedly collapsed. The vehicle was towed to an independent mechanic, who diagnosed that the sub frame had severe corrosion, causing the rear control arm to detach. The contact was informed that the sub frame needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 13V354000 (Suspension); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 193,430.

AIR BAGS,SEAT BELTS

The air bag light came on for the front passenger seat. I took it to Grayson Hyundai & they tried to get part #88840-3L500-J9 which is the latch right front buckle assembly. I was told there was no part available because my car is a 2006 & manufactures are only required to carry parts for 10 years. I was also told if the air bags worried me to trade cars. I would think the seat belt buckle for a safety feature like the air bag would have to always be available. I have owned this car since 2006, it only has 26,600 miles on it. It has always been garage kept & literally looks like a new one EXCEPT I have NO air bags. Also, today I was told part #88840-3L500-J9 is on a National Parts List, whatever that means. Surely this has happened to someone else. I just decided to report it.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

The vehicle has a random, chronic no start issue. Everything appears to be working normally, and you will turn the key with no crank. All the dashboard lights work, everything is as normal except it wont turn over. The dealer will not help. They refuse to even attempt replacing parts with my approval, just to try to rule things out. Due to my own investigation into the problem, we have successfully replaced the transmission inhibitor switch twice with good results. That switch will not allow the engine to crank if the car thinks the transmission is not in park. The first time the repair worked for 1 year, and the second time 6-8 months. I'm having the problem again, not sure where to turn for help. Dealer is useless, local shops have no better ideas than I do.

SERVICE BRAKES, AIR,ELECTRICAL SYSTEM

The contact owns a 2006 Hyundai Azera. The contact stated while driving at an undisclosed speed, the anti-lock braking system malfunctioned then failed to respond. The ABS warning light was illuminated. Additionally, the contact stated that the check engine warning light illuminated, and the vehicle stalled and failed to restart. The insurance company was notified of the failure and the vehicle was towed to the residence. Additionally, the contact stated that multiple relays were installed in the vehicle and previously failed while driving. The vehicle was taken to an undisclosed dealer where it was diagnosed that the ABS relay switch box was faulty and the vehicle was repaired under NHTSA Campaign Number: 18V026000 (Service Brakes, Hydraulic) however, the failure recurred. The undisclosed dealer was notified of the failure and the contact was advised to bring the vehicle to the dealer to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 150,000.

AIR BAGS

The contact owns a 2006 Hyundai Azera. The contact stated that the air bag warning light had illuminated and remained illuminated on the instrument panel for a year. The vehicle was taken to the dealer and diagnosed but no cause for the failure was found. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 307,000. The contact stated the vehicle was taken to the dealer but informed there was nothing wrong with the vehicle. Also, the contact received a recall for the airbag but no longer has the recall notice.

AIR BAGS

The contact owns a 2006 Hyundai Azera. The contact stated that on numerous occasions, the air bag warning light illuminated. The vehicle was taken to the dealer several times. The contact was then referred by the dealer to a different dealer where it was diagnosed and produced code: B1489 and B1495. The contact then stated that the pod reset was performed, and the ECU was not responding however, the contact stated that she was not informed of which part needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 10V007000 (Air Bags, Seat Belts). The manufacturer was not notified of the failure. The failure mileage was approximately 83,000.

SUSPENSION

The contact owns a 2006 Hyundai Azera. The contact stated while driving approximately 70 MPH, the vehicle rode over a slight bump in the roadway and the rear-end of the vehicle started swaying to the left and the right. The contact pulled over and stopped the vehicle to check for a flat tire and observed that the tires were inflated. The contact stated that the failure was intermittent but occurred at various speeds while driving over a slight bump in the road. The contact stated no warning light was illuminated. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The contact looked under the vehicle and saw that the rear driver’s side upper control arm and the rear mount had detached from the frame. The vehicle was not diagnosed or repaired. The contact researched online and determined that the failure was related to NHTSA Campaign Number: 13V354000 (Suspension). The manufacturer had been informed of the failure. The failure mileage was approximately 215,000.

STRUCTURE,SUSPENSION

The contact owns a 2006 Hyundai Azera. The contact stated while driving approximately 2 MPH and reversing out of her driveway there was a loud clunking noise heard. The contact stopped the vehicle and placed it in park(P) and observed that the driver's side rear tire had collapsed inward toward the wheel well. The contact stated that the crossmember had detached from the subframe and was on the driveway. The contact stated no warning light was illuminated. The contact had the vehicle towed to an independent mechanic who diagnosed that the crossmember had fractured from excessive rust and that the rear suspension needed to be replaced. The vehicle was repaired. The contact had the vehicle repaired in 2018 under NHTSA Campaign Number: 13V354000 (Suspension). The contact related the current failure to the recall. The manufacturer had been informed of the failure. The failure mileage was approximately 58,000.

ENGINE

Without warning, my car lost power as I was driving on the interstate. I started changing lanes to get over to the shoulder, and before I got to the shoulder smoke began to come out of the hood then flames started. I was able to pull over and get myself and my special needs son out of the car with the help of others who saw the flames and also pulled over. 911 was called and police and fire came. The firefighters put out my engine fire with their chemical suppressants. My car does not have an active recall on it, but other makes and models with this same engine do, so I never receivedany warming about this problem happening with my same engine. I have always had it serviced at the dealership. This was very traumatic.