2021 Hyundai Santa Fe

2021 Hyundai Santa Fe SUV AWD

Overall

★★★★★

Front Crash

★★★★★

Side Crash

★★★★★

Rollover

★★★★☆

2021 Hyundai Santa Fe SUV FWD

Overall

★★★★★

Front Crash

★★★★★

Side Crash

★★★★★

Rollover

★★★★☆

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.

Campaign: 21V524000

VISIBILITY:WINDSHIELD

Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.

Campaign: 21V00M000

AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles. The Occupant Detection System (ODS) module may not deactivate the air bag upon detection of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Campaign: 21V185000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles equipped with 2.5-litre Turbo engines. The fuel pipe connecting the high pressure fuel pump to the fuel rail may not have been tightened properly.

Campaign: 21V308000

POWER TRAIN:AUTOMATIC TRANSMISSION

Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.

Campaign: 22V746000

TRAILER HITCHES

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Campaign: 23V181000

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Campaign: 24V879000

ENGINE

The contact owned a 2021 Hyundai Santa Fe. The contact stated that while his wife was driving 50 MPH, the vehicle unexpectedly caught on fire. The contact's wife became aware that the radio was inoperable before the failure. Additionally, the contact’s wife’s eyes were irritated, and there was a hot, harsh odor which grew stronger very quickly. The odor was inside the vehicle. The contact stated that the smoke was black, and flames started shooting out from under the hood to consume the vehicle. The vehicle was a total loss. The fire was extinguished by the Murphysboro Fire Department. The Fire Department was unable to determine where the fire had started. There was a Police report filed. The vehicle was towed to an impound lot. The failure mileage was approximately 58,000.

FUEL/PROPULSION SYSTEM

The door to the gas tank is a push door which is temperamental. I can be at the pump and push the door to pop it open and it won't. I'm at the point where I have to pop my gas tank open before I even get to the gas station because to pull up to the pump and not be able to put gas in the tank is a waste of time. There is no lever to flip along side the driver seat because it is a push to open door.. it is available for inspection, however, it is temperamental. I will video it so I have proof as it works and it doesn't work. It has not been inspected by anyone only because if it is a defect in the motor for the door, I want Hyundai to recall it. I have gone on YouTube to see if there are remedies and yes, there are videos on how to open the door in case you cannot push it open. I cannot do this because I'm not ruining the back of my car as there is no compartment to open as shown in the YT video. I am not one to let my tank get down to less than 1/2 tank, especially not now. But why am I worrying about popping the door open when I'm not even at the gas station yet??

BACK OVER PREVENTION

My rear back up camera intermitting stops working. I can shift into reverse sometimes and the camera does not come on at all, other times the screen blinks and other times the screen has green lines and glitchy lines. The camera will also come on while I'm DRIVING forward

BACK OVER PREVENTION

When i select (R) reverse my camera does not come on. It started as just a flashing screen, but does not come on. It has come on momentarily while I am (D)driving. it has flashed a green screen before.

VISIBILITY/WIPER

The windshield wipers intermittently stop working. This has been occurring for 2 years and the 5dealership cannot find an issue because they always work when the car is in for service. They also now want to charge a diagnostic fee each time it's in since the car is no longer under warranty

UNKNOWN OR OTHER

Fuel door mechanism stops working leaving you unable to add fuel. Is a constant complaint in 2021 Hyundai Santa Fe vehicles. My vehicle's door mechanism as stopped working 53,000 miles as well.

POWER TRAIN

The contact owns a 2021 Hyundai Santa Fe. The contact stated that while driving approximately 5-30 MPH, the transmission failed to shift properly, and the vehicle lost motive power. The engine warning light was illuminated. The contact stated that the failure was a recurring failure. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 22V746000 (Power Train); however, the failure persisted. The dealer was contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

My check engine light came on, and my car was also feeling "sluggish" and slow to accelerate. I scheduled a service appointment at my local dealer 4 days later. At the appointment, the technician stated everything checked out okay and the check engine light was likely an "anomaly" or "outlier" but otherwise nothing to be concerned about since everything checked out "okay" and no problems were identified during their test drive. However, that very afternoon, I was driving down the interstate, where the posted speed limit is 70mph, when my check engine light came on again and suddenly lost power, drastically reducing my speed and could not accelerate faster than 39mph. Luckily, the interstate was not busy at the time (about 10:30-11:00 a.m. Saturday morning) and there were only less than 4 cars behind me that were able to easily switch lanes and pass me. I moved over to the shoulder to a complete stop and restarted my car. My check engine light remained illuminated and was still slow to accelerate and "sluggish" but was able to (slowly) reach interstate speed (60-70mph) until I reached an acceptable exit and safely made it to my destination. I have since used roadside assistance to tow the vehicle from my home to the the same dealership for inspection and service (again).

UNKNOWN OR OTHER

On March 17, 2026, the sunroof of our Hyundai Sante Fe 2021 exploded. The driver and two passengers were not hurt because the sunroof was closed and the liner in place when the explosion took place. The incident occurred on an open country highway on a sunny afternoon with no other vehicles or flying objects sighted.

ENGINE,FUEL/PROPULSION SYSTEM

My 2021 Hyundai Santa Fe (VIN [XXX] ) is experiencing severe engine instability, including rough idling, hesitation upon acceleration, and intermittent stalling. These symptoms align with TSB 26-FL-001H regarding defective GDI fuel injectors. The vehicle has stalled in traffic, creating an immediate risk of a rear-end collision. Despite being within the 100,000-mile Powertrain Warranty, the manufacturer is refusing to perform the required diagnostic tests (GDS Fuel Pressure Drop Test) to identify the leaking injectors. This failure to diagnose a known fuel system defect poses a significant safety risk to the driver and other motorists. The primary safety risk is unexpected engine stalling while the vehicle is in motion or stopped at intersections. Additionally, the loss of power during acceleration prevents the vehicle from safely merging into high-speed traffic, significantly increasing the likelihood of a collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)