2022 Hyundai Santa Fe

2022 Hyundai Santa Fe SUV AWD

Overall

★★★★★

Front Crash

★★★★★

Side Crash

★★★★★

Rollover

★★★★☆

2022 Hyundai Santa Fe SUV FWD

Overall

★★★★★

Front Crash

★★★★★

Side Crash

★★★★★

Rollover

★★★★☆

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.

Campaign: 21V524000

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe and Santa Cruz vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment.

Campaign: 22V197000

POWER TRAIN:AUTOMATIC TRANSMISSION

Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.

Campaign: 22V746000

TRAILER HITCHES

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Campaign: 23V181000

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Campaign: 24V879000

STRUCTURE

On May 31, 2025, I suffered a severe facial injury causing trigeminal neuralgia and concussion when the Smart Power Liftgate on my 2022 Hyundai Santa Fe XRT failed to stop or reverse upon encountering obstruction. While unloading the trunk, I went to close the liftgate, lost my balance falling forward prior to it beginning to close. It struck my face and upper body with full mechanical force, failing to trigger the automatic safety reverse/anti-pinch strip sensors. The component suffered a total safety failure, bypassing the safety mechanisms intended to prevent bodily entrapment and crushing injuries. I was forced to seek emergency medical treatment. Official Emergency Room medical records from May 2025 explicitly document the facial injuries sustained directly from this automotive component failure. The vehicle remains dangerous as the anti-pinch sensors failed to operate as legally and mechanically mandated. There have been multiple incidents where the liftgate has failed to stop with coming into contact with pressure of even my toddler briefly or our dogs, but I was not aware this vehicle was equipped with this safety feature to begin with.

LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

Vehicle on initial start up shows no issue. Driving for a short distance or stationary for a short time. Vehicle instrument panel will show a fault of Forward safety system. Errors on Lane keeping assist, High beam assist, and Driver attention warning. Smart camera module will be hot to the touch causing failure of Front view camera and Front Radar Module.

POWER TRAIN,VEHICLE SPEED CONTROL

On June 20 2026 at 2:07pm Central Time there was a check engine light displayed on the dash of my vehicle 2022 Hyundai Santa Fe Calligraphy, while it was parked in the garage of my home and was just powered up. I had then performed the vehicle diagnostics test (pictures attached) that showed that there was an issue with the 'Transmission Control System' with detail that a full system check is recommended and to schedule an appointment with a dealer. I had later proceeded to contact local dealer 'Huffines Hyundai McKinney' for service as I was due for an oil change anyway. As I was driving the vehicle from my home which was about 13 miles away from the dealership, I noticed that the vehicle had great trouble shifting from 1st gear to higher gears, that the speed would be 20mph or lower no matter how much the accelerator was pushed and I had to drive very carefully in traffic due to the low speeds. I was told at the dealership by 3pm that day that there were no active recalls on my vehicle, that the transmission related recall that was showing up on google search for that DCT code wasn't specific enough to my vehicle and to book an appointment for vehicle diagnostics and transmission repair/replacement at full cost to myself. The multi-point inspection report after oil change showed nothing about the check engine light issue or that the issue was even diagnosed by the dealership. From that day until today Aug 29 2026, I've noticed that the vehicle still has trouble shifting from the 1st gear, that the vehicle drives normally when increased time is allowed between power up and start of drive (~2min of engine running idle) and that the check engine light reappears after a trip of quick power up and drive. There was atleast one instance where I had to pullover onto the shoulder to avoid high speed traffic while driving in the right lane.

FUEL/PROPULSION SYSTEM

At approximately 67,000 miles, the vehicle experienced a sudden vibration when accelerate and decelerate. Engine light was on and vehicle had a hard time to maintain speed above 40mph. Cars were honking behind us due to the lack of speed on road. It happen all of a sudden and cause me and my wife panic at first. The car was took to the closest dealer ([XXX] Hyundai [XXX]) and they found the problem was due to an internally leaking fuel injector, requiring a complete out-of-pocket replacement. This is a known, widespread manufacturing defect directly addressed by Hyundai Technical Service Bulletin TSB #25-FL-001H (which supersedes 23-FL-002H-1). The bulletin explicitly states that 2021–2022 Hyundai Santa Fe 2.5L GDI engines suffer from premature internal fuel injector failure caused by internal filter breakage, forcing owners to pay out of pocket for a design flaw acknowledged internally by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

Symptoms are those described in Hyundai recall 236 (delayed shifting,hesitation, stalling). Vehicle has had multiple TSP services at Hyundai but symptoms persist intermittently. Software updates do not fix issue. Hyundai dealer has no other remedies.

FUEL SYSTEM, GASOLINE,BACK OVER PREVENTION

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle jerked or hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact stated that after two separate warranty repairs of the fuel injector, the failure persisted. In addition, the contact stated that the rear-view camera intermittently displayed a distorted or blank image while the vehicle was in reverse(R). The contact received notification of NHTSA Campaign Number: 24V879000 (Back Over Prevention); and was informed by the dealer that the vehicle was not covered under the recall. The manufacturer was notified of the failure, and the contact was issued a case number. The failure mileage was approximately 30,000.

POWER TRAIN

While accelerating, the 8-speed transmission sporadically hangs in 1st gear and will not change to 2nd. The motor revs to about 4000 rpm and will only travel at about 15 mph. This causes a safety hazard when attempting to enter fast moving traffic. After several attempts, the Dealer has said that they cannot duplicate this issue in their shop and has not made necessary warranty repairs to fix this vehicle. Hyundai assigned a case manager who says that since the diagnostic did not pull any codes and they could not replicate the problem, they would not make any repairs. There is about 5000 miles left on the factory warranty.

ELECTRICAL SYSTEM

The horn has now stopped working in my vehicle twice. It was replaced 01/27/2023, and is now non-functional again. I believe this to be a safety issue as I have no way to warn other drivers or pedestrians of my presence, if necessary. One example of this, was that a vehicle was proceeding into my lane on the interstate yesterday afternoon and I had to avoid them hitting my vehicle by driving onto the shoulder of the road, as I could not use my horn to let them know they were coming into my lane while I was on the side of them.

POWER TRAIN

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while pulling out of the driveway and approaching a stop sign, the message "Check Transmission Oil Immediately" was momentarily displayed. The dealer was contacted and informed the contact that the vehicle could not be diagnosed unless the message was displayed. The contact stated that the failure recurred while driving approximately 35 MPH the following day, and the engine power was reduced. The check engine warning light was illuminated. The driver contacted Bluelink and was advised to pull over safely. Bluelink and the dealer advised the driver to tow the vehicle to the dealer for assistance. The vehicle was towed to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 22V746000 (POWER TRAIN); however, the VIN was not included. The manufacturer was notified of the failure and offered to cover half the cost of the repair. The failure mileage was approximately 74,900.

AIR BAGS

This email serves as a formal dispute of the warranty denial issued by [Lester Glenn Hyundai Toms River NJ] regarding the Supplemental Restraint System (SRS) passenger airbag sensor in my 2022 Hyundai Santa Fe.The dealership has refused coverage, attributing the failure to "water damage." I strongly dispute this finding and am formally requesting a Corporate Goodwill Repair Exception or a tier-two engineering review of my vehicle due to the safety-critical nature of this component.