2002 Hyundai Xg 350

2002 Hyundai XG 350

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SUSPENSION

TL* THE CONTACT OWNS A 2002 HYUNDAI XG350. THE CONTACT STATED THAT THE DRIVER'S SIDE REAR UPPER CONTROL ARM DETACHED FROM THE FRAME DUE TO CORROSION. THE CONTACT ALSO STATED THAT HE NOTICED THE DRIVER'S SIDE REAR TIRE LEANING. THE CONTACT ALSO STATED THAT THE FRAME WAS CORRODED. THE VEHICLE WAS NOT YET TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT CALLED MCCARTHY BLUE SPRINGS HYUNDAI (3000 NW S OUTER RD, BLUE SPRINGS, MO 64015) AND INFORMED THEM OF THE FAILURE AND SCHEDULE AN APPOINTMENT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 224,000.

POWER TRAIN

THE TORQUE CONVERTER & TRANSMISSION FLUID PUMP ARE KNOWN TO BE DEFECTIVE IN THIS TRANSMISSION, THE F5A51 MITSUBISHI/HYUNDAI TRANSMISSION. MINE STARTED GOING OUT RECENTLY, AT 75K MILES! THIS PROBLEM/DEFECT IS ALSO VERY WELL KNOWN TO HYUNDAI/KIA/MITSUBISHI AND THEY CHOOSE TO IGNORE THE ISSUE & INSTEAD TRY TO BLAME THE OWNERS & CLAIM THAT WE'VE BEEN NEGLECTFUL OR ABUSIVE TO THE TRANSMISSION WHICH IS SIMPLY NOT THE CASE. I'LL SAY THAT AGAIN, HYUNDAI & MITSUBISHI KNOW OF THE MANUFACTURING DEFECTS IN THESE PARTS AS WELL AS DEFECTS WITH THE CRANKSHAFT IN THE ENGINE BUT CHOOSE TO IGNORE IT AND CLAIM THAT THEY ARE NOT RESPONSIBLE FOR THESE PROBLEMS. THERE ARE KNOWN DEFECTS THROUGHOUT THE WHOLE CAR, LUCKILY MINE IS ONLY HAVING ISSUES WITH THOSE TWO PARTS IN THE TRANSMISSION SO FAR. PLEASE HELP ALL OF THE OTHER OWNERS OF THE VEHICLES THAT HAVE THAT TRANSMISSION & ENGINE WITH EVEN GREATER PROBLEMS THAN MY OWN.

ENGINE

TL* THE CONTACT OWNS A 2002 HYUNDAI XG350. WHILE DRIVING 40 MPH, A BURNING ODOR WAS DETECTED INSIDE THE VEHICLE AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT WAS NOT SURE OF THE ORIGIN OF THE ODOR. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 139,000.

ENGINE

MY HYUNDAI XG 350 2002 HAD A LITTLE OVER 100,000 MILES ON IT. ON 2/12/2018, WHILE DRIVING ON A ROUTE 17 SOUTH IN MAHWAH, NJ, I HEAR A HIGH PITCH CRACKING SOUND WITH A SMOKE COMING OUT OF THE CAR AND SOON THE CAR BECAME DISABLED ON THE SIDE OF HIGHWAY ROUTE 17 S LEAKING A ENGINE OILS ALL OVER THE PLACE. AT THE BODY SHOP, THEY FOUND OUT THAT THE THE BOTTOM PART OF THE ENGINE GOT CRACKED WITH A ADULT-FIST SIZE HOLE LEAKING ENGINE OILS ALL OVER THE PLACE. THE OWNER OF THE BODY SHOP MENTIONED THAT IT IS HIS FIRST TIME TO SEE THE ENGINE GOT CRACKED WITH SUCH A BIG HOLE. IT APPEARS THAT THE ENGINE HAS A MAJOR DEFECT AND COULD HAVE CAUSED A MAJOR PROBLEM UNLESS THE DRIVER QUICKLY MOVED THE CAR TO THE ROAD SIDE BEFORE IT BECAME COMPLETELY DISABLED. I FEEL SO LUCKY THAT IT DIDN'T HAPPEN WHILE MY WIFE OR MY DAUGHTERS WERE DRIVING, AND IT HAPPENED TO ME, WHILE I WAS DRIVING. ONLY SLIGHTLY OVER 100,000 MILES AND THE ENGINES GOT CRACKED, UNBELIEVABLE.

SUSPENSION

TL* THE CONTACT OWNS A 2002 HYUNDAI XG350. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION); HOWEVER, THE DEALER FAILED TO REPAIR THE VEHICLE. THE CONTACT WAS GIVEN A BUY BACK OFFER FROM THE MANUFACTURER, BUT DECLINED THE OFFER. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 03/15/16.*JB

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2002 HYUNDAI XG350. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V178000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE RECALL REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN BACK THE DEALER, WHO INFORMED THE CONTACT THAT THE RECALL REMEDY WAS NOT PERFORMED ON THE VEHICLE. THE SPECIFIC ON THE FAILURE WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,554.

AIR BAGS

IN 2007, WITH A LITTLE OVER 50,000 MILES ON MY CAR, THE AIRBAG LIGHT CAME ON. I WENT IN TO THE DEALER AND THEY SAID IT WAS A LOOSE WIRE AND RESET IT. SINCE THAT TIME, I'VE HAD SIX OTHER INCIDENTS UP THROUGH 2014 WITH THE AIRBAG LIGHT COMING BACK ON AND EVERY TIME THEY'VE RESET IT, IT HAS COME BACK ON. I HAVE EVEN HAD A MODULE REPLACED BUT IT DID NO GOOD. THE LAST TIME I WENT IN, THEY WANTED TO REPLACE THE PAD ASSEMBLY FOR $1,000 BUT WOULDN'T GUARANTEE IT WOULD WORK. THEY ALSO SAID IT MIGHT BE THE HARNESS BUT THAT PART COULDN'T BE OBTAINED. THEY ALSO SAID THEY COULDN'T GUARANTEE THAT THE AIRBAGS WOULD WORK!!! I HAVE LOOKED AT OTHER COMPLAINTS FROM SEVERAL WEBSITES AND SEE THAT THERE ARE DOZENS OF OTHER PEOPLE WITH THE SAME PROBLEM. THIS IS A SERIOUS DEFECT AND SHOULD BE RECALLED. I HAVE NO AIRBAGS. MY CAR HAS BEEN IN A MINOR TRAFFIC INCIDENT WHERE THE AIRBAG PROBABLY SHOULD HAVE DEPLOYED WHEN THE CAR HIT THE CURB BUT DIDN'T. THIS IS VERY DANGEROUS. *TR

SUSPENSION,STRUCTURE,SERVICE BRAKES

REAR SUB FRAME SEVERE CORROSION IN CRITICAL SUSPENSION & FRAME MOUNTING & ATTACHING AREAS . AND PARTIAL LOSS OF BRAKING SYSTEM DUE TO RUPTURE OF REAR BRAKE TUBE DUE TO SEVERE CORROSION IN REAR FRAME AREA. *TR

AIR BAGS

AIR BAG WARNING LIGHT STAYS ON. AT FIRST THE LIGHT TURNED OFF BUT AFTER A WEEK IT TURNED ON AND HAS REMAINED ON. REPAIR SHOP SAID THE AIR BAGS MAY DEPLOY IN AN ACCIDENT BUT NOT CERTAIN. *TR

ELECTRICAL SYSTEM,ENGINE

DRIVING ON FREEWAY ON JULY 13, ODOMETER DROPS TO ZERO OR BOUNCES AROUND, CAN'T DETERMINE SPEED WHILE DRIVING, WARNING ENGINE LIGHT TURNS ON. 7/15/2013 DEALER REPLACED SENSORS SHOPPING ON JULY 28, ODOMETER DROPS TO ZERO AND WARNING ENGINE LIGHT TURNS ON 7/28/2013 DEALER REPLACED SENSORS DRIVING ON FREEWAY ON OCTOBER 6, ODOMETER DROPS TO ZERO 10/8/2013 DEALER REPLACED ODOMETER (MILEAGE WAS 108,700) DIVING ON FREEWAY ON NOVEMBER 2, ODOMETER DROPS TO ZERO, WARNING LIGHT TURNS ON HAVEN'T DECIDED WHAT TO DO WITH CAR. *TR