2001 Kia Rio

2001 Kia Rio 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

WHEELS

CERTAIN PASSENGER VEHICLES MAY HAVE A MANUFACTURING FLAW THAT COULD CAUSE THE WHEELS TO CRACK UNDER LONG TERM DRIVING FATIGUE. IF CRACKS OCCUR, WHEEL NOISE AND VIBRATION WILL RESULT AND BECOME PROGRESSIVELY WORSE OVER TIME.

Campaign: 05V159000

FUEL SYSTEM, GASOLINE:DELIVERY

ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.

Campaign: 04V179000

FUEL SYSTEM, GASOLINE

ON CERTAIN PASSENGER VEHICLES, FUEL LEAKS MAY DEVELOP AT THE FUEL DISTRIBUTOR ASSEMBLY BECAUSE OF QUALITY DEVIATIONS.

Campaign: 03V352000

UNKNOWN OR OTHER

DOOR LOCKS ON BOTH FRONT DOORS STUCK IN THE LOCKED POSITION.

STRUCTURE,LATCHES/LOCKS/LINKAGES,ENGINE

PARKED CAR AT WORK CAME BACK OUT AND THE DOOR LOCK WAS DOWN TRIED TO PULL UP BUT IS STUCK OR CAUGHT ON SOMETHING. THE WAY THE SCREWS ARE IN THE DOOR 2 OF THEM CANNOT BE TAKEN OUT WITHOUT HAVING THE DOOR OPEN. WITH LONG LEGS ITS VERY DIFFICULT TO GET IN AND OUT OF VEHICLE!!! ALSO TROUBLE WITH THE ENGINE MISFIRING OF SPARKPLUG WITH SOME LOSS OF POWER. *TR

ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,EQUIPMENT

IT IS DIFFICULT TO ENTER THE CAR WITH THE KEY AND WHEN I PULL THE DOOR HANDLE THE LOCK DROPS DOWN TO THE CLOSE POSITION AND I CAN'T GET OUT THIS HAPPENS ON THE DRIVER'S SIDE AND THE FRONT PASSENGER SIDE,I HAVE TO HOLD THE LOCK ON THE UP POSITION WITH A PIECE OF METAL OR LEAVE THE REAR DOORS UNLOCKED IN CASE I HAVE TO JUMP OUT..THIS CAR IS A LEMON I HAVE REPLACED SENSORS ALTERNATOR, STARTER, AC PARTS AND MANY OTHER PARTS THE ONLY THING GOOD IS THE TRANSMISSION AND THE ENGINE... *JS

STEERING,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,TIRES,WHEELS

CONSUMER COMPLAINT: ODI CASE NUMBER: 10136024 COMPONENT: WHEELS GAS IGNITION? YOU TELL ME? WHEN ARE THESE PEOPLE GOING TO BE COMPENSATED FOR THEIR LEMONS KIA-2001 DETAILS: DT: THE CONSUMER WAS INVOLVED IN AN ACCIDENT AND A TIRE BLEW OUT. AFTER THE VEHICLE STOPPED SPINNING, THE CONSUMER GOT OUT OF THE VEHICLE AND IT BURST INTO FLAMES, THE FIRE DEPARTMENT CAME AND THEY SAID FIRE STARTED FROM HEAT OF POWER EQUIPMENT AND THE IGNITION BURNED. THIS HAPPENED ON AUGUST 6, 2005. *AK THE CONSUMER STATED SHE WAS NOT INFORMED ABOUT THE RECALL REGARDING THE WHEELS. THE CONSUMERS DAUGHTER COMPLAINED THAT THE STEERING WHEEL VIBRATED FROM THE TIME THE VEHICLE WAS PURCHASED. THE SAME TIRE THAT THE BLEW OUT WAS THE SAME ONE THAT HAD BEEN REPLACED NUMEROUS TIMES. *JB OCCURRENCES: 1 INJURIES: 0 FAIL DATE: 08/06/2005 DEATHS: 0 DATE ADDED TO DATABASE: 9/9/2005 [FILE] YOUR OWN COMPLAINT ON THIS MODEL CAR. *TR

WHEELS

I WAS ON A MAJOR INTERSTATE DOING THE SPEED LIMIT OF 65 MPH WHEN I HEARD A LOUD POP SOUND. THE CAR STARTED TO SHAKE AND I THOUGHT I HAD A FLAT TIRE. I IMMEDIATELY PUT ON MY HAZARD LIGHTS AND SLOWED DOWN TO REACH THE NEAREST EXIT RAMP. I WAS ALONE IN THE CAR AND THANK GOD I HAD NO CHILDREN IN THE CAR AND AS SOON AS I REACHED THE EXIT RAMP I GOT OFF THE EXIT AND CALLED AAA. THEY SENT A TOW TRUCK BUT WHEN THE DRIVER WENT TO PUT THE CAR UP HE NOTICED THE RIGHT BACK WHEEL WAS EXTREMELY LOOSE AND THEN CALLED FOR A FLAT BED. WHILE BEING TOWED TO MY MECHANIC WITH THE CAR ON THE FLAT BED THE WHEEL CAME COMPLETELY OFF. I LOOKED ONLINE FOR RECALLS ON MY CAR AND THERE WAS ONE ISSUED IN 4/20/2005 AND I WAS NEVER NOTIFIED BY KIA OR THE DEALER WHERE I PURCHASED THE CAR ABOUT THIS ISSUE WHEN THE RECALL BEGAN ON 6/22/2005. I AM WORRIED NOW THAT I MAY HAVE TO PAY OUT OF POCKET FOR THIS REPAIR WHICH KIA MOTORS SHOULD HAVE NOTIFIED ME ON. *JS

LATCHES/LOCKS/LINKAGES

BOTH DOOR LOCKS GET STUCK ON BOTH THE PASSENGER SIDE AND DRIVERS SIDE. WE HAVE HAD TO CLIMB IN THE BACK SEAT TO EXIT THE CAR. THIS IS VERY DANGEROUS AND COULD CAUSE DEATH OR INJURY IF A FIRE AND COULD NOT EXIT THE CAR. *TR

FUEL SYSTEM, GASOLINE

I BOUGHT A 2001 KIA RIO IN 2007 AND WITHIN 8 MONTHS MY FUEL PUMP HAD TO BE REPLACED. A YEAR LATER MY CAR STARTED SPUTTERING AND SHUTTING OFF RANDOMLY WHILE I DROVE IT. I ENDED UP HAVING TO REPLACE THE FUEL PUMP TWO MORE TIMES. I RECENTLY TOOK IT TO THE DEALERSHIP WERE THEY INFORMED ME I NEEDED ANOTHER FUEL PUMP. IM SORRY BUT THERE IS SOMETHING WRONG IF I HAVE TO REPLACE THE FUEL PUMP AND FILTER 4 TIMES IN A 2 YEAR TIME SPAN. NOW MY CAR DOES NOT EVEN RUN, AND I REFUSE TO REPLACE THE FUEL PUMP AGAIN WHEN I KNOW IT WONT DO ANYTHING. *TR

FUEL SYSTEM, GASOLINE

REF 2001 KIA RIO. PERPETUAL INTERMITTENT FAILURE OF FUEL PUMP TO OPERATE. FUEL PUMP REPLACED, RELAY REPLACED, AND ECM REPLACED. PUMP WON'T TURN ON AT START UP AND PERIODICALLY, THE PUMP STOPS OPERATING AFTER IT DOES COME ON WHILE DRIVING. NO WARNING. CAUSES SAFETY PROBLEM ON ROAD BY NOT HAVING ANY POWER TO MOVE CAR OFF ROAD. *TR

SUSPENSION

TL* THE CONTACT OWNS A 2001 KIA RIO. THE CONTACT STATED WAS DRIVING APPROXIMATELY 60 MPH AND ATTEMPTING TO SWITCH LANES WHEN SHE HEARD AN UNUSUAL NOISE SIMILAR TO RUMBLING METAL, FOLLOWED BY A LOUD CLUNK. THE CONTACT WAS BARELY ABLE TO MAINTAIN CONTROL OF THE VEHICLE YET WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROADWAY. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE SHE WAS ADVISED THAT THE WHEEL BEARING SPACER WOULD NEED REPLACING. THE DEALER MADE REPAIRS TO THE VEHICLE YET THE FAILURE RECURRED WITHIN SIX MONTHS. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED EIGHT TIMES FOR THE FAILURE SINCE PURCHASE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 81,000.

ELECTRICAL SYSTEM

THIS IS A KIA RIO 4 DR. 2001 ..WITH 12,000 APROX MILES WHEN THE ECU FUSE BROKE, ON HWY 127 NEAR DEATH VALLEY ..HAD TO GET TOWED INTO MY DESTINATION.IT TOOK ABOUT 5 DAYS TO GET A PART FROM CALIF,UPS TO ME FROM A FRIEND, I CHANGED THE FUEL LEVEL SENSOR,,WHICH I THOUGHT WAS THE PROBLEM...THE NEAREST KIA DEALER WAS 80 MILES AWAY IN LAS VEGAS,,,I LATER DISCOVERED THAT IT WAS A BLOWN ECU FUSE..NOT A SENSOR..I THEN DROVE THE CAR APTROX 500 MILES BACK TO CALOIF,WHEN IT BLEW AGAIN ON THE HWY 15 NEAR FONTANA,...I TOOK THE CAR TO KIA DEALER IN ONTARIO CALIF, THEY ONLY DID 2 WARRANTY ITEMS ON THE CAR.#1 WAS AN UPGRADE OF THE ECM.AND #2 REPLACED A FUEL DIST SENSOR////THE DEALER SAID IT WOULD FIX THE FUSE ISSUE,,,WHICH I TOLD THEM UP FRONT. THEY RETURNED THE CAR I WAS GOING BACK TO NEVADA IT BLEW A FUSE ECU ON HWY 15 HAD IT TOWED HOME AGAIN,,,,THE DEALER PICKED UP THE CAR FROM RIALTO 10 MILES AWAY FROM MY PARENTS....THEY HAD THE CAR 4 DAYS AND TOLD ME IT WOULD TAKE APROX 600$ TO GET UNDER THE DASH WHERE THEY BELIEVE THERE IS A SHORT THAT IS CAUSING THIS ECU TO BLOW,,I HAD THE CAR RETURNED ON MY AAA AGAIN TOOK IT FOR A SECOND OPINION,,,AGAIN THEY ALSO SAID IT COULD BE UNDER THE DASH AND THE AMOUNT THEY WANTED TO FIX IT AND KEEP THE CAR FOR ABOUT 3 OR 4 DAYS TO MAKE SURE THE PROBLEM WAS FIXED. THE DEALER NEVER TEST DROVE THE CAR AFTER THE WARRANTY WORK..AS PER THE INVOICE MILEAGE IN AND MILEAGE OUT...THEY SAID THEY COULD NOT DUPLICATE THE PROBLEM...AGAIN...AFTER THE 2ND OPINION..I HAD TO TOW IT AGAIN WHEN I WAS DRIVING IT HOME ON THE STREETS..THAT WAS 55 MILES FROM MY PARENTS HOUSE... I HAVE ALL THE AAA RECORDS ON TOWING ...I'M OUT OF TOWS... THIS CAR COULD CAUSE AN ACCIDENT ....ONLY BECAUSE THE CAR WILL STOP RUNNING WITH OUT ANY NOTICE AND SO FAR I WAS LUCKY THAT NOTHING WENT WRONG. *TR