2004 Kia Rio

2004 Kia Rio 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2004 Kia Rio 4-DR. Wagon

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

CHILD SEAT

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.

Campaign: 05V557000

FUEL SYSTEM, GASOLINE:DELIVERY

ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.

Campaign: 04V179000

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

I bought this car used a little less than a week ago. There was a thumping noise under the hood so I took the car to the dealer twice for this issue. I looked under the hood tonight and found a bunch of pieces that are not bolted down and the battery is completely unsecured and can move around freely. It’s horribly unsafe because the battery being loose can affect the entire car and the parts that aren’t bolted in place are causing major issues with the AC and other systems.

UNKNOWN OR OTHER

MY WIFE GOT LOCKED IN HER CAR IN THE GARAGE AT HOME. THERE IS A SPRING ON THE DOOR LATCH THAT HOLDS UP A LEVER, THAT BROKE, CAUSING THE LEVER TO DROP AND JAM THE LOCK LEVER. WHEN SHE TRIED TO UNLOCK HER DOOR IT WOULD NOT RELEASE AND THE AUTO LOCK FUNCTION KEPT THE OTHER DOORS LOCKED TOO. WE WERE ABLE TO USE MY KEY TO QUICKLY UNLOCK AND OPEN THE PASSENGER SIDE DOOR AND GET OUT BY CRAWLING OVER THE CENTER CONSOLE. A SIMPLE GOOGLE SEARCH FOUND A FEW THOUSAND ENTRIES SHOWING THIS SAME ISSUE WITH OTHER KIA RIOS AND OPTIMAS WHERE PEOPLE ARE GETTING STUCK IN THEIR CARS.

UNKNOWN OR OTHER

TAKATA RECALL 2004 KIA RIO LOCKS IN CAR BROKEN UNABLE TO UNLOCK AND GET OUT THE CAR I DON'T KNOW IF THERE IS SOMETHING WRONG WITH THE LOCKING SYSTEM AND IT HAS BECOME A MAJOR PROBLEM

STRUCTURE

DRIVER SIDE DOOR LOCK DOES NOT ALWAYS WORK. WHEN LOCKED FROM INSIDE THE CAR YOU HAVE TO CRAWL OUT THE PASSENGER SIDE AND GO AROUND TO DRIVER DOOR, PUT THE KEY IN THE LOCK AND WIGGLE THE INSIDE DOOR LOCK LEVER. SOMETIMES IT TAKES MINUTES TO GET IT TO UNLOCK. IF YOU WERE TO HAVE TO EXIT THE VEHICLE QUICKLY IT WOULD NOT BE POSSIBLE. THIS HAS HAPPENED MULTIPLE TIME IN THIS CAR.

SUSPENSION

TL* THE CONTACT OWNS A 2004 KIA RIO. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO MULTIPLE INDEPENDENT MECHANICS AND A DEALER ON NUMEROUS OCCASIONS WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER SIDE WHEEL BEARING NEEDED TO REPLACED. THE WHEEL BEARING WAS REPLACED MULTIPLE TIMES; HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

SUSPENSION

THE KIA WAS UNDER WARRANTY AT THIS TIME: IT REQUIRED A NEW TRANSMISSION. I WAS TOLD IT WAS ABOUT TO 'DROP'. DESPITE BEING UNDER WARRANTY, I WAS MADE TO PAY FOR IT. 2007 THE PASSENGER REAR DOOR STOPPED WORKING AND WOULD NOT OPEN. IN 2008 THE ELECTRICAL WENT. NO INTERIOR LIGHTS, RADIO AND NO 'DOOR AJAR' WARNING. 2008 THE DOOR BEHIND DRIVER WOULD NOT OPEN. 2013 THE DRIVER DOOR WOULD NOT OPEN FOLLOWED BY THE HATCHBACK. RIGHT NOW ONLY 2 DOORS ARE ABLE TO BE LOCKED DUE TO THIS ISSUE. A NEW CLUTCH WAS PUT IN DURING 2012. THE SHIFTING HAS ALWAYS BEEN A LITTLE STICKY WITH IRREGULAR TIMING. I PURCHASED THIS CAR BRAND NEW AND CANNOT BELIEVE THE SAFETY ISSUES CONCERNING THE DOORS, ABOVE ALL. I CANNOT BELIEVE THAT I BOUGHT THE ONLY 'LEMON'..OR AM AMONG A FEW KIA RIO CINCO OWNERS FACING THESE PROBLEMS.

WHEELS

TL* THE CONTACT OWNS A 2004 KIA RIO. WHILE DRIVING APPROXIMATELY 50 MPH, THE WHEEL BEARING AND THE HUB FROM BOTH REAR WHEELS DETACHED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE REAR TIRE BEARINGS WERE PREVIOUSLY REPLACED MULTIPLE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000.

SUSPENSION

OK, MY CAR MAKES A THUMPING NOISE UNDER THE TIRE, THOUGHT WAS THE WHEEL BEARING IT'S NOT SOMEONE SAID IT WAS THE AXLE I DON'T KNOW ALSO, THE ENGINE LIGHT HAS BEEN ON I CHANGED THE AIR FILTER, I READ THAT SOMEONE ELSE HAD PROBLEMS WITH THE FILTER, I READ THAT THE AXLE RUSTS OUT, I THINK THIS CAR SHOULD BE RECALLED PEOPLE ARE COMPLAINING ABOUT THE SAME PROBLEMS AND KIA SHOULD FIX IT FOR FREE, I DON'T THINK I SHOULD PAY FOR THAT THE CAR DOESN'T GET DRIVEN THAT MUCH AND I CAN'T GO FAR PLACES WITH IT IN FEAR THAT IT MIGHT BREAK DOWN SOMEWHERE, I FEEL LIKE SUING KIA FOR MAKING A CRAPPY CAT THAT DOESN'T LAST. I'VE NEVER HAD A CAR LIKE THIS BEFORE, THE DOORS ARE BROKEN EVEN THE HATCH WON'T OPEN ANYMORE, WHAT THE [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 2004 KIA RIO. THE CONTACT STATED THAT THE DRIVERS SIDE DOOR FAILED TO OPEN WHEN USING THE KEY OR BY MANUALLY PULLING THE LOCK. THE CONTACT MENTIONED THAT IN ORDER TO ENTER THE VEHICLE SHE HAD TO DO SO THROUGH THE FRONT PASSENGERS DOOR. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 84,000.

VISIBILITY/WIPER

TL-THE CONTACT CT OWNS A 2004 KIA RIO. THE CONTACT STATED THAT THE WINDSHIELD DEFROSTER AND HEATING SYSTEM FAILED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE WINDSHIELD DEFROSTER AND HEAT BUTTON HAD TO BE HELD IN TO BE ABLE TO HAVE THE WINDSHIELD DEFROST AND HEAT SYSTEM OPERATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 87,050. LI