2005 Kia Rio

2005 Kia Rio 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

CHILD SEAT

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.

Campaign: 05V557000

STEERING,POWER TRAIN,AIR BAGS

I WAS DRIVING ON PUBLIC STREET LOSS CONTROL DUE TO A POT HOLE IN THE STREET THE CAR LOST CONTROL FLIPPING SLIDING THEN FLIP UP RIGHT TILL IT CAME TO A STOP ON APT WALL THEN WHEN IT WAS ALL OVER AND DONE THE AIRBAG DEPLOYED GO OFF ON MY ARM RIGHT ARM GIVING ME SECOND TO THIRD DEGREE BURNS THE PURPOSE OF THE AIR BAG ? I HAVE BROKEN BACK CAR WAS TOTALED NOW I GOT CHRONIC PAIN EVERYDAY I LOST MY CAR AM LIMITED ON MOBILEBILITY WAS GOING GET SCREWS PLACED ON MY BACK AND UN ABLE TO SET WALK OR STAND DO TO CHRONIC PAIN

AIR BAGS,SEAT BELTS

TL* THE CONTACT OWNS A 2005 KIA RIO. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS RANDOMLY FLASHED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V244000 (AIR BAGS); HOWEVER, THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE VEHICLE WAS TO BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

STEERING,ELECTRICAL SYSTEM,ENGINE

WHEN THE CAR IS EXPOSED TO MOISTURE, EITHER FROM UNDERNEATH BY DRIVING THROUGH A SMALL PUDDLE OR FROM ABOVE IN A RAINSTORM, THE ENGINE COMPARTMENT GETS WET AND CAUSES THE SERPENTINE BELT TO SLIP. THIS RESULTS IN SUDDEN LOSS OF POWER STEERING AND ALTERNATOR FAILURE, WHICH CAN LEAD TO THE CAR'S POWER CUTTING OUT IN THE MIDDLE OF THE ROAD. THIS IS AN OBVIOUS DRIVING HAZARD, BUT I AM TOLD THAT THIS IS A COMMON ISSUE DUE TO THE CONSTRUCTION OF THE ENGINE COMPARTMENT IN KIA VEHICLES RATHER THAN A PRECIPITATING MECHANICAL FAILURE CAUSING IT.

ENGINE

TL* THE CONTACT OWNS A 2005 KIA RIO. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP. THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS INSPECTED AND TAGGED WITH LICENSE PLATES ONE HOUR BEFORE THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 65,125.

VISIBILITY

THE BLOWER STOPPED BLOWING AIR. FOR A SHORT WHILE IT WOULD COME ON, RARE OCCASIONS AND EVENTUALLY STOPPED WORKING. CHANGED THE BLOWER MOTOR AND RESISTOR, STILL DIDN'T WORK. PULLED THE DASH APART TO CHANGE THE BLOWER SWITCH AND FOUND THAT IT HAD MELTED THE PLASTIC CONNECTOR. NOT SURE WHAT CAUSED THE MALFUNCTION, HOWEVER ONCE THE NEW SWITCH WAS PUT IT THE BLOWER WORKED. *TR

ENGINE AND ENGINE COOLING,FUEL/PROPULSION SYSTEM

NOT REALLY A SAFETY ISSUE BUT MAYBE YOU CAN HELP, PLEASE. I CHECK ENGINE LIGHT CAME ON TELLING ME I'M AT LESS THAN 90% EFFICIENCY RELATIVE TO POLLUTION. WHEN THE MECHANIC CHECKS THE CO2 AND OTHER POLLUTION REQUIREMENTS I'M OK. I STILL GET GREAT MILEAGE AND GOOD POWER. THE PROBLEM IS THE COMPUTER SAYS THE CONVERTER IS OFF AND HENCE CAN'T GET A STICKER BUT THE CAR IS NOT POLLUTING ?? IF I LIVED OUT SIDE A BIG CITY WHERE THEY DO NOT TRACK THIS STUFF THERE WOULD BE NO PROBLEM. PS THE COST TO REPLACE THE CAT CONVERTER IS OVER $1400.00. WHILE IT US STILL 90% EFFECTIVE??? WHAT GIVES PLEASE HELP. THANKS, *TR

STRUCTURE

KIA RIO 2005 IS A VERY POORLY BUILT CAR. THE PASSENGERS DOOR WILL NOT OPEN, A MECHANISM IN THE DOOR IS BROKEN. SINCE THE DOOR WON'T OPEN NO ONE SEEMS TO KNOW HOW TO REPAIR THIS PROBLEM. THE DOOR PANEL CAN NOT BE REMOVED FROM THE DOOR WITHOUT THE DOOR BEING OPEN. NEVER AGAIN WILL I BUY A KIA OF ANY KIND. *TR

VEHICLE SPEED CONTROL,ENGINE

I HAVE A 2005 KIA RIO (VIN PROVIDED LATER) PURCHASED 2006, LOW MILES. SUMMER 2011 CAR STALLED, STOPPED & CHECK ENGINE LIGHT CAME ON & HAD IT TOWED TO THE NEAREST SHOP, NTB. REPLACED TIMING BELT & NO DAMAGE TO MY MOTOR. I FOUND OUT THE TIMING BELT NEEDED CHANGING AT 60K MILES (MINE WAS LOWER). THE MECHANIC WASN'T ABLE TO DETERMINE A REASON FOR THE CHECK ENGINE LIGHT. ANOTHER SUGGESTED A BAD SENSOR & WIPED SOMETHING OFF UNDER THE HOOD. THE LIGHT WENT OFF AFTER DRIVING LESS THAN 5 MILES. REPLACED THE ALTERNATOR APRIL 2013 (NEW ALTERNATOR, BELT & PARTS STILL UNDER WARRANTY). JUNE 2013 THE CHECK ENGINE LIGHT STARTED COMING ON WHEN PARKED UPWARD ON AN STEEP HILL, ESP WHEN OUTSIDE TEMP WAS VERY HOT (TX). THE LIGHT WOULD REMAIN ON UNTIL AFTER PARKING IT IN A COVERED GARAGE & DRIVING HRS LATER. JULY 2013 MANDATORY CAR INSPECTION. WEEK OR 2 LATER, PROBLEMS W/ RPM STARTED; DURING TAKE AFTER IDLE. ABOUT 2WKS LATER, AC SPEED SUDDENLY SLOWED & BECAME WARMER. 2DAYS LATER CHECK ENGINE LIGHT ON & A STRANGE NOISE NEAR THE DRIVER'S SIDE. AGAIN, TOWED TO THE NEAREST SHOP, THE SAME NTB. ALL ELECTRICAL COMPONENTS WAS STILL WORKING. AT THE SHOP THE CAR STARTED BUT NOT LONG. THEY WERE PUZZLED. AFTER 2DAYS I WAS TOLD MY MOTOR WAS BAD & NEEDED REPLACED. NO ONE HAD AN EXPLANATION.I HAD TO HAVE MY CAR, ONLY TRANSPORTATION FOR ME & MY KIDS TOWED HOME. I TALKED TO DIFFERENT MECHANICS THAT AGREE I HAVE A BAD SENSOR & CATALYST WHICH CAUSED MY MOTOR TO LOCK (PRE-IGNITION). THERE ARE SEVERAL BLOGS/ARTICLES W/THIS SAME PROBLEM. HOWEVER, KIA HAS NEVER SAID ANYTHING ABOUT THE 2005 RIO FUEL PROBLEMS, ONLY THE 2004 & SUPPOSEDLY CORRECTING IT. BUT IT WASN'T & MECHANICS CAN'T DIAGNOSE IT. SOMETHING IS WRONG & NEEDS INVESTIGATING. A FATAL ACCIDENT COULD HAVE OCCURRED IF I HAD BEEN DRIVING ON THE HWY. KIA SHOULD TAKE RESPONSIBILITY FOR LOST $ AND TIME BC THEY ONLY BANDAGED THE PROBLEM & NOT ACTUALLY FIXING IT.

STRUCTURE

THE PASSENGER DOOR WON'T OPEN. AND THIS IS A PROBLEM THAT MANY KIA RIO OWNERS HAVE WITH THEIR CAR. CAR IS A PIECE OF JUNK. IT IS BY FAR THE WORST CAR I HAVE EVER OWNED. *TR

ENGINE

THE ENGINE STOPPED IN TRAFFIC ON HWY, WIFE WAS IN DANGER OF BEING HIT BY OTHER VEHICLES,NO POWER TO GET TO EDGE OF ROADWAY ON BRIDGE, HEAVY CONSTRUCTION, HAD TO CLIMB OUT PASSENGER DOOR, DOWN EMBANKMENT TO SAFETY. TOWED VEHICLE HOME TO FIND ENGINE LOCKED UP. MAINTENANCE DONE REGULAR BELTS, TIRES,OIL CHANGES AND BATTERY REPLACED. ONLY FUEL GAUGE ISSUE IS ALL PROBLEMS, ASK DEALER WAS TOLD TO BRING IN FOR ESTIMATE 300.00 TO CHECK.AFTER ISSUE ON HIGHWAY FIND OUT TIMING BELT AND ENGINE PROBLEMS HAVE OCCUR ON THIS MODEL SINCE 2001. SAD FOR VETERAN UNABLE TO MAKE REPAIRS DUE TO DISABILITY. NEVER BUY OR RECOMMEND KIA TO ANYONE. *TR