2002 Kia Sedona

2002 Kia Sedona Van

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SEAT BELTS:REAR/OTHER

CERTAIN MINI VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SECOND AND THIRD SEAT BELT BUCKLE ANCHOR BOLTS DO NOT COMPLY WITH THE STANDARDS.

Campaign: 03V017000

VEHICLE SPEED CONTROL:CABLES

ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.

Campaign: 05V013000

SEATS:MID/REAR ASSEMBLY

ON CERTAIN PASSENGER VEHICLES, SOME OF THE SECOND AND THIRD ROW SEAT STRIKERS INSTALLED ON THE VEHICLE FLOOR PAN HAVE BEEN IMPROPERLY HEAT TREATED AND COULD BREAK IN A CRASH.

Campaign: 03V135000

ELECTRICAL SYSTEM,SEAT BELTS

TL* THE CONTACT OWNS A 2002 KIA SEDONA EX. WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON SEVERAL OCCASIONS AND THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. ADDITIONALLY, THE CONTACT STATED THAT THE FRONT PASSENGER'S SEAT BELT TIGHTENED AND WOULD NOT RETRACT. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 131,000.

STRUCTURE

THE DOOR HANDLES ARE PLASTIC AND EVENTUALLY BROKE OFF ON THE OUTSIDE SO THAT OPENING THE DOORS -ALL 4- IS TRICKY SINCE ONLY ONE SIDE OF THE HANDLE REMAINS IN PLACE. THE INSIDE DOOR HANDLES HAVE A PLASTIC CHROME-LOOKING COATING THAT PEELS OFF AND HAS CUT OUR HANDS SEVERAL TIMES CAUSING US TO NEED BANDAGES AS SOON AS WE RUN IN THE FRONT DOOR.

AIR BAGS

TL* THE CONTACT OWNED A 2002 KIA SEDONA EX. WHILE DRIVING 45 MPH, THE CONTACT CRASHED INTO THE PRECEDING VEHICLE. ALL THE AIR BAGS FAILED TO DEPLOY. THE POLICE ARRIVED AT THE SCENE, BUT A REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO AN IMPOUND LOT. THE DEALER WAS NOT CONTACTED. THE CONTACT SUSTAINED INJURIES TO THE NECK, LOWER BACK, LEFT SHOULDER, AND CHEST, WHICH DID NOT REQUIRE MEDICAL ATTENTION. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. THE VIN WAS NOT AVAILABLE.

STRUCTURE

DRIVER DOOR WILL NOT OPEN FROM THE INSIDE OR OUTSIDE.

FUEL/PROPULSION SYSTEM

IT IS NEARLY IMPOSSIBLE TO PUMP GAS INTO THE VAN. THE PUMP KEEPS SHUTTING OFF NO MATTER HOW SLOW I PUMP OR HOW FAR I PUT THE NOZZLE INTO THE TANK.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

I WAS DRIVING NO LESS THEN THAN BLOCK FROM MY HOUSE - WHEN I NOTICE SMOKE FROM THE DRIVER SIDE FUSE PANEL AND NEXT THING YOU KNOW THE WHOLE PANEL BECAME ENGULF IN FLAMES. I CALLED THE FIRE DEPARTMENT AND ABLE TO PUT FIRE OUT- BUT UNFORTUNATELY, THE CAR BECOME TOTAL IN THE DAMAGE.

POWER TRAIN

DRIVING DOWN THE ROAD AND WHEN YOU BRAKE TO SLOW DOWN THE TRANSMISSION DOWN SHIFTS FASTER THEN IT SHOULD AND ON SNOW COVERED ROAD THE FRONT STARTS TO SLIDE WHEN IT DOES THIS AND WHEN IT SHIFTS BACK UP IT VIBRATES OTHER THEN THAT ITS FINE ANY IDEA WHAT THE PROBLEM COULD

ELECTRICAL SYSTEM,SEATS

THE VAN WAS ON FIRE IN MY YARD. ONLY THE FRONT DRIVERS FRONT SIDE CAUGHT FIRE. WHEN I FOUND IT IT WAS BLASING OUT OF THE DOOR AND WINDSHIELD. I GOT THE HOSE PIPE AN UNHOOKED THE BATTERY TO PUT THE FIRE OUT. IT MELTED THE WHOLE DASHBOARD ALL THE WAY TO THE RADIO STEERING WHEEL WINDSHIELD ONLY ON DRIVERS SIDE ALL DAMAGE WAS AT FRONT DRIVERS FRONT SIDE.I DIDN'T DRIVE THE VAN ALDAY THAT DAY.

ELECTRICAL SYSTEM

TAKATA RECALL. I WAS AT HOME I HEARD SOME KIND OF NOISE OUT SIDE LIKE A HORN BLOWING SO I LOOK OUT AND MY VAN WAS ON FIRE ON THE DRIVERS SIDE AND I RAN FOR THE HOSE TO PUT IT OUT THEN I CALLED 911AN THE FIRE DEPT. CAME AN THE ARSSON DEPT AND HE SAID IT WAS IN THE SEAT TO THE FUSS BOX AND THAT'S WHAT CAUSED THE FIRE MY CAR IS TOTALED CAN YOU PLEASE LET ME KNOW THE WHOLE VAN ON DRIVERS SIDE IS TOTALED I HAVE NO WAY TO GO NOW .

TIRES

DROVE HOME FROM WORK AT 35 MPH. THE NEXT MORNING NOTICED TIRE TREAD HAD SEPARATED FROM THE SIDEWALL AROUND MUCH OF THE PERIMETER OF THE TIRE. TIRE WAS FLAT.