2003 Kia Sedona

2003 Kia Sedona Van

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

VEHICLE SPEED CONTROL:CABLES

ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.

Campaign: 05V329000

WHEELS

ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.

Campaign: 05V232000

VEHICLE SPEED CONTROL:CABLES

ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.

Campaign: 05V013000

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

ON CERTAIN PASSENGER VEHICLES, THERE WAS A PROGRAMMING ERROR IN THE ANTI-LOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL MODULE LOGIC. THE PROGRAMMING ERROR COULD CAUSE REDUCED BRAKING FORCE AT SPEEDS BELOW 25 MPH, WHICH COULD RESULT IN INCREASED STOPPING DISTANCES.

Campaign: 03V158000

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

My Sedona keeps catching on fire not sure why but now if I get it up to temperature it automatically catches on fire I'm going into my second fire extinguishe

STEERING

The contact owns a 2003 Kia Sedona. The contact stated while driving 40 MPH, the steering wheel became difficult to steer. The contact pulled over and left the vehicle. The contact returned 2 days later and drove the vehicle home. The contact stated that the check engine, brakes and air bag warning lights were illuminated. The vehicle was not diagnosed. The manufacturer was informed of the failure and confirmed that the VIN was not under recall. The failure mileage was approximately 113,000. THE CONSUMER STATED THE VEHICLE LOST POWER STEERING AND THE BRAKES LOCKED UP. Dealer/manufacturer was contacted but no open recalls.*JB Consumer stated in addition to the prior issues has airbag lights on and brakes that lock up in the rain. Power steering was repaired but still having problems.

ELECTRICAL SYSTEM,SEATS

TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND SHUT OFF THE FRONT PASSENGER SIDE SEAT HAD EXPERIENCED A FIRE AND MELTED. THE CONTACT DISCOVERED SMOKE AND SOOT PRESENT INSIDE THE VEHICLE AND A BURN HOLE IN THE PASSENGER SEAT. NO POLICE REPORT WAS TAKEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS OPENED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER ROCK RIVER KIA (226 NORTH ALPINE RD. ROCKFORD IL) WHERE THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE CONTACT INDICATED THAT THE FRONT DRIVER SIDE SEAT HAD LATER ALSO EXPERIENCED BURNING. THE FAILURE MILEAGE WAS UNKNOWN.

ELECTRICAL SYSTEM,ENGINE

TL* THE CONTACT OWNED A 2003 KIA SEDONA. THE CONTACT STATED WHILE DRIVING AT 25 MPH THE VEHICLE HESITATED AND FAILED TO SHIFT INTO THE DESIRED GEAR WITH SMOKE COMING FROM UNDER THE HOOD. THE CONTACT MANAGED TO DRIVE THE VEHICLE HOME, PARKED THE VEHICLE, AND UPON OPENING THE HOOD SAW FLAMES. THE CONTACT STATED THAT THE FIRE DEPARTMENT WAS CALLED HOWEVER, HER NEIGHBOR ATTEMPTED TO EXTINGUISH THE FLAMES WITH A WATER HOSE UNTIL THE FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS TAKEN. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE DEALER WAS NOT NOTIFIED OF THIS ISSUE AND THE MANUFACTURER WAS NOT MADE AWARE OF THIS ISSUE. THE CONTACT MENTIONED THAT THE CHECK ENGINE AND AIR BAGS WARNING LIGHTS HAD BEEN ILLUMINATED SINCE SHE PURCHASED THE VEHICLE.

WHEELS,SERVICE BRAKES

THE BREAKS WERE CHANGED DUE TO GRINDING COM TO FIND OUT THERE WAS 1BOLT ON THE BREAK CALIBERS PUT THEM ON AND IT STILL GRINDS AND CAN NOT STOP

SERVICE BRAKES

TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING 35 MPH, THE BRAKE PEDAL SEIZED HALFWAY DOWN WHEN IT WAS DEPRESSED. AS A RESULT, THE CONTACT SWERVED ONTO THE SIDEWALK AND STOPPED 30 YARDS IN A PARKING LOT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ELECTRIC COMPUTER BRAKING MODULE DID NOT ALLOW THE BRAKES TO STOP COMPLETELY; THEREFORE, THE COMPUTER REACTED AS IF THE VEHICLE WERE TRAVELING ON ICE. THE DEALER (MORITZ KIA HURST, 110 NE LOOP 820, HURST, TX 76053, (817) 591-7063) STATED THAT THERE WAS NO RECALL FOR THE FAILURE. THE MANUFACTURER STATED THAT THEY WOULD HAVE THE DEALER INSPECT THE VEHICLE FOR FREE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,800.

TIRES

ON FEB. 25, 2018, WE PURCHASED A 2003 KIA SEDONA VAN FROM CITY START AUTO SALES IN PARADISE, CA. ALL FOUR TIRES AND THE SPARE WERE GOODYEAR INTEGRITY 215/70R15. THE TIRES READ MAX. PSI 44, BUT THE VAN SAID TO RUN AT 35 PSI. SO, ONCE A WEEK ON A COOL MORNING (BETWEEN 68-75 DEGREES OUTSIDE WITHOUT IT HAVE BEEN DRIVEN), MY WIFE OR I WOULD MAKE SURE THE TIRES WERE 34-35 PSI. DURING THIS 3 MONTH PERIOD, WE NOTICED NOTHING WRONG WITH THE TIRES. ON MAY 31, 2018, I WAS DRIVING FROM MY HOUSE IN MAGALIA, CA TO CHICO, CA. JUST AS I STARTED TO MERGE ONTO HWY 99 IN CHICO, I HEARD A THUMPING SOUND, THEN A BANG--TWICE. I IMMEDIATELY PULLED OVER AND SAW 2 TIRES HAD COMPLETELY BLOWN OUT AND ONE WAS SERIOUSLY SHOWING THE METAL BELT. I HAD TO PAY TO GET A TOW TRUCK OUT AND IMMEDIATELY PURCHASE 4 NEW TIRES. WE'VE HAD A LITTLE WORK DONE ON THE REAR-LEFT FENDER CONTINUED TO HAVE WEIRD SOUNDS COMING FROM THE LEFT REAR WHERE THE WORST BLOW OUT HAPPENED. I JUST HAVEN'T HAD TIME TO TAKE IT IN YET. I KNOW IT WAS HOTTER IN CHICO THAN AT MY HOME, BUT IT WAS PROBABLY IN THE UPPER 80'S AT THAT TIME. I HAD NO WARNING AND IF IT HAPPENED WHEN I WAS ON THE FREEWAY, IT WOULD'VE BEEN A DISASTER. THE TIRE COMPANY SHOWED US THE SPARE, SAID WE COULD USE IT AS ONE FOR A SHORT TIME, BUT EVEN IT IS SHOWING SOMETHING WRONG TO THE TIRE GUY.

STEERING

THERE BEEN WHINING NOISE DURING ACCELERATING AND DE-ACCELERATE SPEED, I HAD SOMEONE LOOK AND THOUGHT I WAS BRAKING SYSTEM. YESTERDAY MY SON WAS DRIVING IT AND TURNING RIGHT AND WE HEARD A POP, AND THE WHOLE STEERING WENT OUT. WE WERE ALMOST KILLED ON 134, HE ABLE BACK IT UP. HAD SOMEONE ELSE LOOKS AT IT RACK AND PINION. THERE BEEN MSNY CLAIMS AND NO RECALL WHY

AIR BAGS

TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING 2 MPH, THE PASSENGER SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THERE WAS NO CRASH OR FIRE. THE DRIVER SUSTAINED CUTS ON THE FACE AND ARMS. THE PASSENGER SUSTAINED SHRAPNEL IN THE RIGHT EYE WITH BRUISING, ALONG WITH GLASS IN HER FACE AND HAIR. THE FOUR PASSENGERS IN THE REAR SUSTAINED RINGING IN THE EARS. THE AMBULANCE PROVIDED ROUTINE ASSISTANCE, BUT MEDICAL ATTENTION WAS NOT PROVIDED. A POLICE REPORT WAS FILED (CASE NUMBER: 15-1706-00760). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS 163,511.

STRUCTURE

TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED WHEN IT WAS WET. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.