2019 Kia Stinger

2019 Kia Stinger 4 DR AWD

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2019 Kia Stinger 4 DR FWD

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia Motors America (Kia) recalled certain 2019 Stinger vehicles equipped with 3.3L T-GDI engines on August 27, 2020. On December 30, 2020, Kia expanded the recall population and added certain 2018-2021 Stinger vehicles. While driving, an engine compartment fire may occur in the area where the Anti-lock Brake Hydraulic Electronic Control Unit (HECU) is located.

Campaign: 20V518000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Kia America, Inc. (Kia) is recalling certain 2018-2021 Stinger vehicles. The fuel control valve plunger may stick inside the high pressure fuel pump, causing over-pressurization and loss of drive power.

Campaign: 23V634000

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER:HOSES/PLUMBING

Kia America, Inc. (Kia) is recalling certain 2019-2020 K900, and 2018-2023 Stinger vehicles equipped with a 3.3-liter turbo gasoline direct injection engine. The left turbocharger oil feed pipe and hose assembly may deteriorate and leak oil.

Campaign: 24V169000

FUEL/PROPULSION SYSTEM

My 2019 Kia Stinger 2.0T, VIN [XXX], suffered catastrophic engine failure at 32,000 miles due to a replacement fuel injector installed by an authorized Kia dealership. On XXX, Galeana Kia of [XXX], replaced the fuel injector on cylinder 3 under fault codes P0300 and P0303 and returned vehicle as "operating as designed." I paid for this repair out of pocket. On XXX— 57 days post-repair — Galeana Kia's own technician documented verbatim: "Found injector stuck opened. Performed compression test and found low compression on cylinder 3 due to piston ring failure. Injector stuck open washed out piston rings." The failed injector was the replacement part Galeana Kia installed on XXX Full engine replacement is estimated at $12,000. Kia America has not resolved this matter despite 11 weeks of documented engagement under case 26100462. Safety concern: sudden engine failure at highway speed. Parts quality concern: OEM replacement injector failed causing catastrophic engine damage. Request NHTSA investigate whether other 2019 Stinger 2.0T vehicles may have fuel system or injector failures creating similar risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VISIBILITY/WIPER

I was driving on the highway & my sunroof exploded. At first i thought someone had dropped something off a bridge , but i realized from the damages. Sunroof exploded. The glass caused damage to my paint !

ENGINE

Oil pressure sensor failure on the engine, there is an open TSB for this same issue/same engine on other Kia models but not the Stinger. Dealer verified that the oil pressure is fine and that it is the sensor, independently verified by a third party shop. Dealer charge is over $3k for the repair and third party is just about $2k.

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

My 2019 Kia Stinger GT2 with approximately 25,000 miles has been out of service since February 12, 2026 for diagnosis and repair of a system issue. The vehicle has remained at the dealership for over two months. Multiple repair attempts have been made, including escalation to Kia corporate engineering. Despite these efforts, the issue has not been clearly diagnosed and no permanent repair has been completed. The vehicle is currently unusable, and the inability to identify the root cause raises concerns that the issue could result in unpredictable or recurring system behavior. Given the reliance on electronic and computer-controlled systems, there is concern about safe and reliable operation if the vehicle is returned without a confirmed fix. The manufacturer has not provided a clear resolution or timeline.

STRUCTURE

The roof trim panel separates from the vehicle while driving. Depending on the car's speed the metal, plastic and rubber strip is lifted up and off the car and into the slip stream behind the vehicle creating a serious hazard for cars behind us. We examined the strip and determined the plastic clips that hold this panel in place do not function as intended, or fail to adequately hold this large section of trim in place during driving conditions. We brought this to the attention to the Kia dealership and were told "Warranty replacement items are not covered after 12 months". They offered to replace the item but we believe it is material craftsmanship and a design flaw that allows this trim to fall off the car while driving.

ELECTRICAL SYSTEM

Wiring harness has been severed, chewed through, or burnt. Multiple times. If my phone listed down below does not work call [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

The issue involves the high-pressure fuel pump covered under Recall 23V634000 (Kia SC281). When the recall was marked as “completed” at the dealership, only a software update was performed. The required inspection of the fuel pump and potential replacement were never carried out. Two years later, the vehicle began experiencing problems consistent with the recall defect, including loss of power and engine performance issues. This indicates the recall remedy was not properly completed, and the defective fuel pump was left in place. The safety risk is that the vehicle may lose motive power while driving, increasing the likelihood of a crash. This problem could potentially affect other owners if recalls are being closed without full inspection or replacement. The symptoms have been observed during regular driving and can be reproduced. The vehicle has not yet been inspected by Kia for the current issue beyond the original recall visit. Warning lights and drivability issues began appearing recently, which align with the defect described in the recall notice. The high-pressure fuel pump is available for inspection upon request.

FUEL/PROPULSION SYSTEM

The car had fuel pump recall I had it fixed on 10/24 now the car has the same issue but your kia refuses to fix it. My warranty company is replaceing the fuel pump but not the reprogramming of it but why is it my issue if it is a recall to begin with that wasn’t fixed or I would not need a high pressure fuel pump and have the same problem. Kia states they only fix one time so now I’m responsible to have it programmed when it was a recall to begin with

ENGINE

I brought my vehicle in for the recall SC300 and they discovered that my oil pressure switch is leaking which is on top of the engine. This is causing a leak and oil pressure light to come on intermittently. Same part as the Kia Sorento, cadenza, and the Sedona that all had the warranty extended recall to 15 years or 150,000 miles. Every Kia forum has people complaining about the same issue and being charged $3000-5000. This can cause an engine fire if left unchecked just like the recall SC300. There is a backlog for that part to come in to fix the issue and people are driving with the light flickering because they don’t know the oil pressure switch is leaking over there engine and down to the EPU which could start a fire as well.

FUEL/PROPULSION SYSTEM

Car was idling louder than usual, engine light came on. Car felt like it wanted to go forward while in park. Dealership diagnosed bad fuel pump and sensor. Had to replace fuel pump, sensor and gaskets with fuel line too.