2013 Lexus Ct200h

2013 Lexus CT200H 5 HB FWD

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

Hydraulic pump problem

SERVICE BRAKES

The brake booster and pump are a known issue for all CT200 models 2011-2013. The brakes do not work as intended which is a safety issue. The attached file is acknowledgement by Lexus that this is an issue. Though they are not covering the problem

ENGINE

Early morning cold start in open loop engine starts to rattle and knock. Cleaned out EGR system, including intake manifold. Engine still rattles and knocks. Swapped out ignition coils and fuel injectors with new still and still the same thing. DTC sets after a week of troubleshooting for P0303, P0301, and P0300. Switched cylinder ignition coils and fuel injectors from cylinder 1 to 2 and 3 to 4. Same DTC sets after drive cycle. Leak down test confirms cylinder 3 has head gasket leak. Registration was just paid and was going to have it smog test. Unable to pass smog due to check engine light. I had went to Lexus dealer to have them update my car for EGR update according to TSB (see attachment) but they wouldn’t do it unless I pay $300 SMFH!!! What a day! Which engineer suggested this stupid design?!?! And wtf the EGR cooler, more like a heater, has coolant running into housing which raises the engine coolant temp. Exhaust gas may go up to a temp of 600 degrees!! Look at live data and monitor catalyst temp from OBD2. This design was to intentionally cause a head gasket failure. Blades in EGR cooler gets clogged with carbon build up, where carbon will eventually break up into chunks/pebbles that will cause pre-ignition during compression stroke, pinging the engine which will result in misfires and damage the catalyst. One of the worst designs I’ve ever encountered as a car owner. This is ridiculous that this issue has been brought up countless times from thousands of testimony’s of same incident but not even a single word for these models. CT200h and Prius years 2012-2015 have this same dam problem and everyone knows this, even the CA BAR(Bureau of automotive repair). What is it that we as car owners, who abide by the law, and pay our fair share of taxes gets this “setup to fail” deal???

SERVICE BRAKES

dash lit up like a xmas tree; braking became immediately unpredictable, spongy, and difficult to stop the car. error code c1391.

SERVICE BRAKES

My Ct200h has now recently started to leak fluid from the brake system has started to malfunction due to this known problem by Lexus on their 2013 CT200h brake booster/master cylinder as well as the actuator system problem which they had previously put out a statement for. This is absolutely incomprehensible the scope of a dangerous situation this could have put my family in. Imagine if the brakes would have fully malfunctioned and I slammed into the back of a 18- wheeler, the whole top of this car is coming off including everyones heads in the car. I hope this reaches a competent individual who understands the scope of the malfunctioning in the brake system. This is supposed to slow a 2 ton car going from 65 mph to 0 at any instance, if the system malfunctions at the wrong time LIVES ARE PUT AT RISK. I have full service records through the dealer and constantly do routine maintenance with the dealer. I am highly disappointed in with this matter.

SERVICE BRAKES

There is a noise I am hearing while breaking which is the actuator trying to build pressure, but the pressure is being leaked out of the accumulator in the brake master cylinder, all of the “Brake” and “ABS” lights come on and you will hear the actuator about every three seconds or so. This is a dangerous mechanism which has been known already on a multitude of these same models. Please fix this, as it could have been a dangerous situation this vehicle could have put my family in.

ENGINE

At about 165-170,000 miles Lexus dealer advised leaking oil from timing chain area. Apparently it is a known issue from this engine (both CT200h and Prius) suffer from this issue. Didn't realize there is a TSB but since way out of warranty and not a recall they offered to fix for $3500. Hard to see the leak as it is in the timing chain area so it rarely comes out of the engine itself. This should be something that Lexus/Toyota should advise their customers. Few months later car was totaled in an accident so I got rid of it.

ENGINE

I have to replace my 2013 Ct engine. When I started it, there was a horrible knocking noise. This came as a surprise, as it was fine the day before. I had it towed to Lexus. I was told that there was no oil in the engine and it needs to be replaced. What????? 1. No warning light came on 2. I had an oil change recently ( within the 5K scheduled maintenance). I was quoted a price of $6960.35 to replace the engine with an engine with around 92K miles ( about the same as what I have). I did some investigation and called Lexus customer engagement. I reached out to Lexus. They offered me $1500 towards the repair. The car is still in the shop. Owners of the CT200h have reportedly been told by Lexus dealers that this is regular oil consumption. However, Toyota did issue a technical service bulletin for these engines. However, they only did so for the ones installed in the Prius and had the same problem. Overall, CT200h owners were left hanging with an engine that uses an incredible amount of oil. I was told in a forum of Lexus owners ( discussion group) to contact this organization for help on this matter. Please investigate this issue.

ELECTRICAL SYSTEM,ENGINE

DRIVING ON HIGHWAY AND ALL OF A SUDDEN AFTER A LOUD NOISE THE bottom of the vehicle went on fire. we called the fire department who put out the fire. After looking at the bottom I notice that the crankcase had a big hole. it seems that a valve went right through the cracnkcase. resulting in hot engine oil going on fire. The car is only 5 months old and Carmax will not pay for the repair which could cost me 5,000 dollars. I paid 27,000 for the car.

ENGINE AND ENGINE COOLING

UNKNOWN: However, the engine is using 2 quarts of oil in less than 100 miles of traveling. It has been taken to the dealer several times for this problem of. Using oil through the engine with no leaks in the oil pan.