1996 Mazda 626

1996 Mazda 626 DX 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ELECTRICAL SYSTEM:IGNITION:SWITCH

Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.

Campaign: 15V674000

FUEL SYSTEM, GASOLINE

CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT, AND XT6 PASSENGER VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. CERTAIN SPX FILTRAN FUEL FILTERS WITH A 90-DEGREE ANGLE INLET TUBE, MODEL 800F300-S2, SOLD AS REPLACEMENT FILTERS FOR 19983-1994 SUBARU VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. FUEL MAY LEAK FROM THE FILTER DUE TO NON-CONFORMING BRAZING WELDS WHERE THE INLET TUBE IS CONNECTED TO THE FILTER CAN.

Campaign: 05E065000

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE SAS SENSOR UNIT. THESE VEHICLES CAN EXPERIENCE AIR BAG DEPLOYMENTS IN MINOR UNDERCARRIAGE IMPACTS.

Campaign: 98V249000

ELECTRICAL SYSTEM,ENGINE

TL* THE CONTACT OWNS A 1996 MAZDA 626. WHILE DRIVING, THE CHECK ENGINE SENSOR LIGHT SUDDENLY ILLUMINATED AND THE INSTRUMENT PANEL LIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE WIRE HARNESS WAS REPLACED. APPROXIMATELY SIX MONTHS LATER, THE VEHICLE EXPERIENCED THE SAME FAILURE. WHILE OPERATING THE VEHICLE, THE ENGINE HEAD GASKET MALFUNCTIONED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 165,000.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 1996 MAZDA 626. THE CONTACT STATED THAT THERE WAS A PROGRESSING ELECTRICAL FAILURE AND UNKNOWN WARNING LIGHTS REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. THE VENT CONTROLS FAILED TO WORK FOR THE AIR CONDITIONER AND HEATER. THE VEHICLE WAS TAKEN TO FOUR DIFFERENT INDEPENDENT REPAIR SHOPS AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE DEALER WAS UNABLE TO PROVIDE A REASONABLE TIME FRAME TO RECEIVE THE PARTS FROM THE MANUFACTURER. THE CONTACT CALLED THE DEALER FOR MONTHS AND WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT. UPDATED 05/10/16*LJ

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 1996 MAZDA 626. AFTER PLACING THE KEY IN THE IGNITION AND STARTING THE VEHICLE, THE CONTACT NOTICED A FUEL ODOR UNDER THE HOOD OF THE VEHICLE. THE CONTACT TURNED THE VEHICLE OFF FOR A WHILE AND PROCEEDED TO TURN THE VEHICLE BACK ON WITH THE FRONT DRIVER AND PASSENGER SIDE WINDOWS ROLLED DOWN. THE CONTACT COULD NO LONGER SMELL THE FUEL ODOR AND A WARNING LIGHT WAS ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 1996 MAZDA 626. AFTER REFUELING THE VEHICLE, A STRONG ODOR OF FUEL EMITTED OUTSIDE OF THE VEHICLE. THERE WAS NO FUEL VISIBLE ON THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE TOP OF THE FUEL TANK EXHIBITED A THREE INCH CRACK. THE MECHANIC WOULD NEED TO FIND A NEW FUEL TANK FOR THE REPLACEMENT. IN ADDITION, THE ENGINE AIR INTAKE VALVE AND RADIATOR WERE FAULTY. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 132,000.

SEAT BELTS,STRUCTURE,FUEL/PROPULSION SYSTEM

THREE INCH CRACK IN TOP OF RULE TANK ,SEAT BELTS BROKE AND SLOW TO ROLE BACK UP AND PLASTIC PARTS USED IN DOOR OPENING MECHANISM BROKE. *TR

FUEL/PROPULSION SYSTEM

I SMELLED GAS WHENEVER I WOULD GET GAS FOR THE CAR OR SPEED UP THE CAR. SO I TOOK THE CAR TO MY MECHANIC AND HE SAID IT WAS SOME SORT OF A PROBLEM WITH THE GAS TANK. I NEED TO KNOW WHAT IT IS. *TR

AIR BAGS,VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1996 MAZDA 626. THE CONTACT STATED THAT WHILE THE SHIFTER WAS IN THE PARK POSITION AND POWERED ON, THE VEHICLE SUDDENLY EXPERIENCED AN UNINTENDED ACCELERATION AND CRASHED INTO A BRICK PILLAR. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED AN INJURED BACK THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 213,365.

POWER TRAIN

TL* THE CONTACT OWNS A 1996 MAZDA 626. THE CONTACT STATED THAT WHILE REVERSING FROM A DRIVEWAY, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THE TORQUE CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. *TR

POWER TRAIN

1996 MAZDA 626 O/D LIGHT FLASHING AND TRANSMISSION NOT SHIFTING. *TR

AIR BAGS

AIRBAGS DEPLOYED IN MY 1996 MAZDA 626. WITHOUT ANY REASON, WHILE DRIVING. CAUSING SCRAPES AND BRUISING, AND THE WINDSHIELD TO CRACK. *TR