1997 Mazda B-Series

1997 Mazda B-Series Pickup 2-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING,STRUCTURE

AT INSPECTION STATION MEYER & SONS, 62 SHEFFIELD ROAD, EGREMONT, MA 01258: DIRECTIONAL LIGHTS CHECK; BUMPERS/FENDERS CHECK BOTH FAILED; THERE IS A CRACK IN THE DRIVER SIDE REAR TAIL LIGHT DOME, WHICH DOES NOT AFFECT THE OPERATION OF ANY LIGHTS. THERE IS A LARGE RUST SPOT IN THE DRIVER SIDE REAR WHEEL WELL. WE DO NOT BELIEVE A CRACKED LIGHT GLOBE AND RUST HOLES SHOULD FAIL THE TRUCK INSPECTION!!!

POWER TRAIN

TL* THE CONTACT OWNS A 1997 MAZDA B-SERIES 4000. WHILE DRIVING AT ANY SPEED, THE CLUTCH FAILED TO OPERATE WHEN ATTEMPTING TO CHANGE GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS A FRACTURED STEEL CASTING LOCATED UNDER THE STEERING WHEEL AND BEHIND THE CLUTCH AND BRAKE PEDALS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.

VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1997 MAZDA B4000( N/A). THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH PROCEEDING TO A TRAFFIC STOP SIGNAL WHEN UNEXPECTEDLY, SMOKE EXPELLED UNDERNEATH THE INSTRUMENT PANEL AND HOOD AREA WHICH CAUSED THE DRIVER TO PULL OVER TO THE SIDE OF THE ROAD. A TEMPORARY FIX WAS PERFORMED AND THE VEHICLE WAS ABLE TO RESUME OPERATION. DURING THE TRAVEL THERE WAS COMPLETE LOSS OF BRAKE POWER AND THE EMERGENCY BRAKE WAS ENGAGED TO BRING THE VEHICLE TO A STOP. THE CONTACT INSTALLED A NEW BRAKE RESERVOIR AND DEACTIVATION SWITCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS CONTRIBUTED TO THE DEACTIVATION SWITCH AND THE TECHNICIAN BLEED THE BRAKE SYSTEM. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THERE WAS A RECALL FOR THE VEHICLE UNDER NHTSA CAMPAIGN ID NUMBER 09V414000 (VEHICLESPEED CONTROL: CRUISE CONTROL). THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 165,000

SUSPENSION

FRONT AND REAR LEAF SPRING SUPPORT MOUNTS ROTTED AWAY. *TR

FUEL SYSTEM, GASOLINE

UPON FILLING MAZDA 1997 B-2300 TRUCK WITH GAS NOTICED A STREAM OF FUEL LEAKING UNDER THE GAS TANK INCHES AWAY FROM EXHAUST. THIS IS A VERY SERIOUS FIRE HAZARD AND WANT TO KNOW WHAT CAN BE DONE. *JB

SEATS

THE DRIVER'S SEAT BACK IN MY MAZDA PICKUP TRUCK UNEXPECTEDLY RELEASED FALLING BACKWARDS WHILE DRIVING. FORTUNATELY I WAS GOING SLOWLY IN A PARKING LOT AT THE TIME AND THERE WAS NO LOSS OF CONTROL. I FOUND THE LARGE TORX-HEAD SCREWS THAT ANCHOR THE SEAT BACK TO THE RECLINING FRAME HAD SHEARED OFF.

ELECTRICAL SYSTEM

1997 MAZDA PICKUP CAUGHT FIRE WHILE PARKED. *BF THE CONSUMER WAS INFORMED THE FIRE MAY HAVE BEEN A RESULT OF STICKING CONTACTS IN THE ELECTRICAL SYSTEM. UPDATED 08/28/07. *JB

STEERING

VEHICLE WAS PULLING TO THE RIGHT WHILE DRIVING 25 MPH, AND THEN THE VEHICLE STOPPED WHILE IN MOTION. VEHICLE WAS TOWED TO CONSUMER'S HOUSE, WHERE CONSUMER DISCOVERED THAT TIE ROD BROKE. *AK

FUEL SYSTEM, GASOLINE

THE CONSUMER STATED THE FILLER NECK TUBE HAS RUSTED. AS A RESULT FUEL VAPORS SEEPED INTO THE PASSENGER COMPARTMENT. A RECALL FOR THE FUEL TANK FILLER NECK HAS BEEN ISSUED, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS OUTSIDE OF THE REMEDY SCOPE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB

POWER TRAIN

MY 1997 626 IS HAVING A SEVERE TRANSMISSION PROBLEM. THERE IS ONLY 60000 MILES ON IT. CONSIDERING THE NUMBER OF COMPLAINTS FILES ON THIS ISSUE, I SINCERELY HOPE THAT MAZDA DOES SOMETHING ABOUT (RECALL OR BETTER GO OUT OF BUSINESS). *NLM