2007 Mazda Mazda5

2007 Mazda5 w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

STEERING:ELECTRIC POWER ASSIST SYSTEM

MAZDA IS RECALLING CERTAIN MODEL YEAR 2007-2009 MAZDA3 AND MAZDA5 VEHICLES MANUFACTURED FROM APRIL 2, 2007 THROUGH NOVEMBER 30, 2008. THESE VEHICLES MAY HAVE A CONDITION IN WHICH A SUDDEN LOSS OF POWER STEERING ASSIST COULD OCCUR AT ANY TIME WHILE DRIVING THE VEHICLE.

Campaign: 10V374000

EQUIPMENT

THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.

Campaign: 09E011000

STEERING

My 2007 mazda5 power steering stopped worked abruptly while turning on a major highway. The sudden change in steering nearly caused an accident. I checked the ODB reader for codes but none were present. Then it happened again the next day in a similar situation, the power steering shut off but this time we were able to see the dash light for the power steering failure come on. It kicked back in a minute later. Again no codes in the scanner. Upon researching how to fix this issue my search revealed that 2007-2009 Mazda 5s have a recall for this exact critical failure. My next step was to call the local dealership to schedule a fix, however they told me that our specific vehicle (according to the VIN) was not under that recall, regardless of the vehicle doing precisely what was recalled. Please review the recall if you can, this is likely affecting more vehicles than Mazda is admitting to and is extremely dangerous.

ENGINE AND ENGINE COOLING

I was driving my Mazda 5 2007 in traffic when suddenly it burst into flames on the passenger side underneath the hood

STEERING,ELECTRICAL SYSTEM

The contact owns a 2007 Mazda Mazda5. The contact stated while driving at approximately 30 MPH and approaching a traffic light, the steering wheel became difficult to maneuver. The contact drove to his residence however, it was difficult to turn the steering wheel. The contact stated that the ABS and power steering warning lights were illuminated. The vehicle was towed to an independent mechanic who was not able to determine the cause of the failure. The contact stated that the dealer was contacted and confirmed that the VIN was not included in a recall. The contact researched the failure online and found NHTSA Campaign Number: 10V374000 (Steering). The manufacturer was not notified of the recall. The approximate failure mileage was 138,000.

STRUCTURE

THERE IS MAJOR LEAKING FROM MULTIPLE UNKNOWN SOURCES, ONE PLACE THE WATER HIDES IS IN THE SPARE TIRE WHEEL WELL AND IT WAS NOT EVIDENT AT FIRST AS TO WHY THE CAR WAS MOLDING ON THE INSIDE. IT HAS TERRIBLE MICROBIAL GROWTH THAT IS EVIDENT AND I CAN ONLY IMAGINE WHAT I CANT SEE. THE CAR TO MY KNOWLEDGE HAS NEVER BEEN IN ANY ACCIDENT TO CAUSE THIS. HAD THE HEATER CORE REPLACED BECAUSE I WAS TOLD THAT COULD BE A REASON WHY THERE IS WATER IN FLOOR , IT WAS REPLACED AND I WAS INFORMED THAT THERE WAS NOTHING WRONG WITH THE ORIGINAL ONE.. THAT WAS A YEAR AGO, AND IT HAS ONLY GOTTEN WORSE . WHEN IT RAINS THE CAR IS SOAKED EVEN WHEN THE WATER THAT IS IN THE WHEEL WELL IS SUCKED UP... I HAVE SEEN OTHER SIMILAR COMPLAINTS ONLINE, I JUST DON'T KNOW WHAT TO DO . I HAVE CHILDREN ONE THAT HAS AUTISM AND ASTHMA AND THIS IS MY ONLY SOURCE OF TRANSPORTATION .... INSURANCE CLAIM WAS FILED AND THEY COVERED A CARPET CLEAN... THE SOURCE(S) IS NOT FIXED OR KNOWN!! THE SUNROOF LINES HAVE BEEN RULED OUT AS WELL THEY ARE CLEAN...

UNKNOWN OR OTHER

THE SUNROOF EXPLODED WHILE I WAS DRIVING ON FREEWAY.

STRUCTURE

SIDE SLIDING DOORS WILL OPEN WHILE DRIVING, CREATING A SAFETY HAZARD TO PASSENGERS.

STEERING

POWER STEERING LEAK

STEERING

SUDDEN POWER STEERING LOSS WHILE DRIVING ON AN ENTRY RAMP OF A HIGHWAY, ACCOMPANIED BY ILLUMINATION OF MULTIPLE LIGHTS ON THE DASHBOARD. STEERING LOSS OCCURRED WHILE VEHICLE STEERING WHEEL WAS TURNED AND VEHICLE WAS IN MOTION AND PREPARING TO MERGE ONTO HIGHWAY. STEERING WHEEL SUDDENLY AND VIOLENTLY JERKED FROM MY HANDS, CAUSING THE VEHICLE TO STEER IN THE DIRECTION OFF THE ROAD. DASH LIGHTS (INCLUDING POWER STEERING) FLASHED INTERMITTENTLY, HOWEVER WOULD REMAIN CONSTANTLY ON WHEN STEERING WAS PULLED FROM CENTER POSITION. POWER STEERING LOSS WAS SPONTANEOUS, INTERMITTENT, AND WITHOUT WARNING. VEHICLE DID NOT RECORD ANY DIAGNOSTIC FAULT CODES WHILE LIGHTS WERE DISPLAYED. SYMPTOMS VEHICLE DISPLAYED COINCIDE WITH "RECALL SUMMARY" FOUND DOCUMENTED ON NHTSA RECALL 10V374000 FOR THE 2007 MAZDA5. INCIDENT OCCURRED BRIEFLY AT LOW SPEEDS WHILE PARKING ON 08/23/2019 AND RESOLVED AFTER VEHICLE WAS TURNED OFF AND RESTARTED. INCIDENT REOCCURRED WHILE MERGING ONTO HIGHWAY AT HIGH RATE OF SPEED AS DESCRIBED ABOVE ON 08/25/2019. WHILE INCIDENT OCCURS AND LIGHTS ILLUMINATED ON DASHBOARD, THE STEERING WHEEL MOTION IS VERY RESTRICTED AND THE WHEEL AUTOMATICALLY FORCES ITSELF BACK TO THE CENTER (NEUTRAL) POSITION. THE LIGHTS ON THE DASHBOARD WILL REMAIN CONSTANTLY ILLUMINATED WITH ANY MOVEMENT OF THE STEERING WHEEL AWAY FROM THE CENTER/NEUTRAL POSITION. THE RADIO ALSO HAS HELLO DISPLAYED, AS IF THE VEHICLE WAS JUST STARTED, EVEN THOUGH THE VEHICLE IS IN MOTION AND WAS NEVER TURNED OFF.

UNKNOWN OR OTHER

THE SLIDING DOORS SEEM TO BE FROZEN AND THEY WILL NOT LATCH PROPERLY. ONE DAY WHILE MY DAUGHTERS WERE IN THE CAR WITH ME THE DOORS SLID OPEN AFTER I DROVE AWAY AND THEY THOUGHT THEY HAD CLOSED THE DOORS. THE OTHER TWO DAYS THE DOOR DID NOT SLIDE OPEN BUT THE LIGHT INDICATED THE DOOR WAS OPEN BUT WE HADN'T USED THE DOORS WE ONLY UNLOCKED THEM.

STEERING

TL* THE CONTACT OWNS A 2007 MAZDA 5. WHILE DRIVING 15 MPH, THE STEERING WHEEL FAILED TO RETURN TO ITS ORIGINAL POSITION AND STRAIGHTEN THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE CONTACT SHOULD TAKE THE VEHICLE TO THE DEALER AND THAT THERE WAS A TSB. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.