2004 Mazda Mazda6

2004 Mazda6 5-DR. Sport Wagon

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2004 Mazda6 5-DR. Hatchback

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2004 Mazda6 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 18V402000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 19V781000

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Campaign: 17V474000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EQUIPMENT

THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.

Campaign: 09E011000

SEAT BELTS:REAR/OTHER

ON CERTAIN PASSENGER VEHICLES, THE RIGHT AND/OR LEFT REAR SEAT BELTS MAY NOT LOCK PROPERLY DUE TO MISSING RETAINING PINS ON THE HOUSING.

Campaign: 04V582000

AIR BAGS

Have contacted Sport Durst Mazda in [XXX] about recall on air bags. Told me I had to drive vehicle to their shop. Told them the letter said Do Not Drive. They said they'd do the recall if I bring it to them. I live in [XXX]. I don't understand why I can not get repair done unless I drive my 2004 Mazda 6 station wagon with over 300 thousand miles on it to them. What do I need to do. This is my only vehicle since my 2017 Hyundai sonata was stolen and motor locked up with only 70 thousand miles on it 7-28-2025 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Very hard shifts from 1st to 3rd gear it's a automatic transmission it's getting worse it will do it at random times and it's getting to the point I'm scared to drive the car. mazda should listen to everyone else's problems with the same transmission it's ridiculous

EXTERIOR LIGHTING

The contact owns a 2004 Mazda Mazda6. The contact stated that while operating the vehicle, the driver’s and passenger’s side headlights were inoperable and failed to illuminate as needed. The contact replaced the bulbs, but the failure persisted. The vehicle was taken to the local mechanic who diagnosed that the electrical wires had shorted out due defective wire coating. The mechanic attempted to fix the failure by covering the electrical wires, but the failure persisted. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 165,000.

UNKNOWN OR OTHER

WE NO LONGER OWN THIS VEHICLE. IT WAS SOLD AT AUCTION ABOUT 3 YEARS AGO. PLEASE STOP SENDING ME THESE REAL NOTICES. VIN IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

I BOUGHT THIS CAR FOR 3,000 FROM THE OWNER HAD IT FOR 2 MONTHS, GOT OIL AND ALL FLUIDS CHANGED. WHEN I WAS LEAVING MY HOUSE A BLOCK AWAY IT TOTALLY DIED ON ME AND NOW IT WONT START AT ALL. I AM VERY FRUSTRATED BECAUSE I DONT HAVE THE MONEY TO BUY ABOTHER ONE. OR EVEN REPAIR IT.

STRUCTURE

VEHICLE SUBFRAME ALMOST COMPLETELY RUSTED OUT.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

REPEATED THROTTLE BODY ISSUES, CAR WHILE DRIVING WILL DROP TO A CRAWL WITH ERRATIC REVVING. DID THIS IN THE MIDDLE OF THE EXPRESS WAY, NEARLY CAUSING AN ACCIDENT, HAD TO BE TOWED AWAY. WILL NOT START DO TO REVVING LOOP CAUSED BY THROTTLE BODY. MULTIPLE TSB HAVE BEEN ISSUED FOR THIS PROBLEM, SO IT SEEMS THE THROTTLE BODY ISSUES PLAGUE MANY CUSTOMERS.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

"TAKATA RECALL" I PARKED MY CAR WHEN I GOT OFF WORK. THE NEXT DAY I WENT TO CRANK MY CAR IT WOULD TURN OVER BUT IT WOULDN'T START, SO I TOOK IT TO A MECHANIC AND HE SAID MY COMPUTER WAS OUT. THE VEHICLE WAS STATIONARY IN MY YARD

AIR BAGS

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 17V474000 AND 16V354000 (AIR BAGS); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED FAIRWAY LINCOLN OF SAVANNAH (10101 ABERCORN ST, SAVANNAH, GA 31406, PHONE NUMBER: (844) 921-2980) AND WAS INFORMED THAT THE PART WAS ON BACKORDER. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

AIR BAGS

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (SHORTLINE MAZDA, 90 HAVANA ST, AURORA, CO 80010 (303) 364-2200) WAS CONTACTED AND INFORMED THE CONTACT THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY AND THEY WOULD CALL THE CONTACT WHEN PARTS BECOME AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 10/26/17*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED. *JS