2005 Mazda Mazda6

2005 Mazda6 Wagon

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2005 Mazda6 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 18V402000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 19V781000

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Campaign: 17V474000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EQUIPMENT

THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.

Campaign: 09E011000

STRUCTURE,UNKNOWN OR OTHER

I NOTICED MY VEHICLE WAS STARTING TO DRIVE FUNNY. I KEEP UP ON IT VERY WELL, ROUTINE MAINTENANCE, WASH IT OFTEN, FRESH ALIGNMENTS, NEW TIRES WHEN NEEDED. SO I THOUGHT SOMETHING WAS UP AND TOOK IT INTO A GARAGE. I WAS CALLED THE NEXT DAY AND WAS TOLD I HAD A HOLE IN MY PASSENGER SIDE RIGHT SUBFRAME. I WAS VERY SURPRISED BY THIS BECAUSE THE CAR IS VERY CLEAN UNDERNEATH FOR THE YEAR AND IN GOOD CONDITION COMPARED TO THE USUAL NEW YORK RUST. I DID SOME RESEARCH AND THIS IS A ONGOING PROBLEM WITH THESE CARS AROUND MY YEAR AND SADLY MANY PEOPLE HAVE EXPERIENCED THIS. MY VEHICLE HAS NO RECALLS AND MAZDA DOESN'T WANT TO TAKE CARE OF THE BILL SO SADLY I'M STUCK WITH A CAR THAT SHOULD BE RECALLED. *TR

ELECTRICAL SYSTEM

TCM UNIT FAULTY, CAR ONLY HAS 82K MILES, READING ONLINE THIS SEEMS TO BE A FAR TOO COMMON PROBLEM, I BELIEVE THE UNIT IS FAULTY!

AIR BAGS,UNKNOWN OR OTHER

I RECEIVED A PAPER SAYING IT WAS RECALLED

ELECTRICAL SYSTEM,AIR BAGS

TL* THE CONTACT OWNS A 2005 MAZDA 6. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO NEW ENGLAND MOTORS OF FITCHBURG (LOCATED AT 71 JOHN FITCH HWY, FITCHBURG, MA 01420) WHERE IT WAS DIAGNOSED THAT UNKNOWN WIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 90,000.

AIR BAGS

TL* THE CONTACT OWNS A 2005 MAZDA MAZDA6. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED AND ATTEMPTED TO MAKE A TURN, THE DRIVER'S SIDE CURTAIN AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THE CONTACT SUSTAINED CUTS, BURNS AND BRUISES ON THE LEFT ARM. THE CONTACT DROVE HIMSELF TO AN URGENT CARE MEDICAL FACILITY. THE CONTACT CALLED THE SESI MOTORS DEALER: (734-668-6100, LOCATED AT 3990 JACKSON RD, ANN ARBOR, MI 48103) AND WAS TOLD TO BRING THE VEHICLE IN. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 133,000.

ENGINE

TL* THE CONTACT OWNS A 2005 MAZDA 6. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DIAGNOSED AND REPAIRED BY AN INDEPENDENT MECHANIC. THE THROTTLE BODY AND ACCELERATOR PEDAL WERE REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

AIR BAGS

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA 6. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 18V402000 (AIR BAGS) WAS RECEIVED IN JUNE OF 2016. THE DEALER (BLAISE ALEXANDER HYUNDAI MAZDA, 1703 W. COLLEGE AVE, STATE COLLEGE, PA) WAS CONTACTED AND STATED THAT THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *TT CONTACT STATES DEALER REPLACED AIR BAGS ON 8/10/2018 AND NO FURTHER ACTIONS IS REQUIRED. *TT

TIRES

I HAVE PRIMEWELL VALERA TOURING II TIRES THAT HAVE A DATE CODE OF 0215 AND THEY STILL HAVE AROUND 50% TREAD LEFT. THE SIDE WALLS ON ALL 4 TIRES ARE COMING APART, THEY ARE SPLIT ALMOST ALL THE WAY AROUND. THESE TIRES ARE ON MY DAUGHTERS CAR AND I DID NOT NOTICE THIS PROBLEM BECAUSE THE SPLITS WHERE ON THE OUTSIDE OF THE TIRE BUT FACING THE INSIDE, I FOUND THEM WHEN I WENT TO INSTALL THE SNOW TIRES. I CALLED PRIMEWELL AND THEY SAID THERE IS NO RECALL FOR THE SERIAL NUMBER ON THESE TIRES AND THEY WOULD NOT HELP ME AT ALL. THERE IS A RECALL ON THIS BRAND AND MODEL OF TIRE FOR THE SAME DEFECT AND READING MANY COMPLAINTS ABOUT THIS SAME PROBLEM THE RECALL NEEDS TO BE UPDATED TO COVER MORE SERIAL NUMBERS.

SEATS

LEFT DRIVER SEAT BECAME UNHINGED WHILE IN MOTION. IT LUNGES BACK AND DOES NOT SET IN PLACE. NO IMPACTS FROM ACCIDENTS. THE SWITCH TO LOWER/RAISE THE SEAT WORKS PERFECTLY. THE SEAT ROCKS BACK AND FORTH.

AIR BAGS

2006 MAZDA 6. CONSUMER WRITES IN REGARDS TO VEHICLE ACCIDENT - DAMAGES TO DRIVER SIDE DOOR, NO AIRBAGS DEPLOYED. VEHICLE TOTALED. *SMD THE CONSUMER SUFFERED A SWOLLEN AND BRUISED RIGHT KNEE, AND LUMP ON THE HEAD AND CONCUSSION FROM IMPACTING THE DOOR FRAME. DUE TO THE CONCUSSION THE DRIVER EXPERIENCED VIOLENT VOMITING AND DIZZINESS. THE CONSUMER WAS INCLUDED IN AIRBAG RECALL (8215 F), WHICH WAS COMPLETED PRIOR TO THE ACCIDENT. UPDATED 08/23/2017*JS