1991 Mazda Protege

1991 Mazda Protege 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ELECTRICAL SYSTEM:IGNITION:SWITCH

Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.

Campaign: 15V674000

ELECTRICAL SYSTEM

TL* THE CONTACT OWNED A 1991 MAZDA PROTEGE. WHILE DRIVING VARIOUS SPEEDS, SMOKE APPEARED UNDER THE HOOD. THERE WERE NO FLAMES VISIBLE AND NO INJURIES. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS UNKNOWN.

AIR BAGS,SEAT BELTS

TL* THE CONTACT OWNS A 1991 MAZDA PROTEGE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING RAIN WEATHER CONDITIONS, THE VEHICLE WENT OVER A POTHOLE CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND STOPPING ON THE SHOULDER OF THE ROAD. THE CONTACT THEN ATTEMPTED TO DRIVE AND THE VEHICLE SPUN CRASHING THE FRONT OF THE VEHICLE INTO A TREE. THE SEAT BELT DETACHED AND THE CONTACT WAS RELEASED FROM THE REAR WINDOW. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE CONTACT RECEIVED KNEE, HEAD, AND BACK INJURIES WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 03/15/16*LJ *TR

STRUCTURE

REAR STRUT TOWERS RUST RIGHT THROUGH. *TR

SEAT BELTS

THE AUTOMATIC SHOULDER BELT WOULD RETRACT SLOWER AND SLOWER UNTIL IT FINALLY STOPPED RETRACTING. THE CONSEQUENCES WERE: ON APRIL 18, 2005 I WAS GIVEN A FIX-IT TICKET FOR NOT WEARING MY SHOULDER HARNESS.*AK THE AUTOMATIC HARNESS NO LONGER FULLY RETRACTS, SO IT IS USELESS.

SEAT BELTS

THE SEAT BELT CORD ON MY 1991 MAZDA PROTEGE HAS BECOME INOPERABLE AND THEREFORE I HAVE NO TOP SEAT BELT ON MY CARS DRIVER SIDE. *AK

STRUCTURE

WHILE DRIVING, THE VEHICLE'S HOOD DETACHED RESULTING IN THE HOOD HITTING THE WINDSHIELD.*MR *CB *JB

SEAT BELTS

DRIVER SIDE SEAT BELT WILL NOT RETURN TO THE RETACTOR, LEAVING THE OCCUPANT UNRESTRAINED. DEALER NOTIFED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

POWER TRAIN

TRANSMITION LOCKED UP GOING 65 MPH. *AK

STRUCTURE

TRUNK LID WAS IN THE UP POSITION AND TRUNK CAME DOWN AND HIT CONSUMER'S DAUGHTER ON HEAD. *AK CONSUMER STATES NOTHING TO KEEP THE TRUNK LID IN UPRIGHT POSITION. A SLIGHT WIND OR ELEVATION COULD BLOW THE OPEN LID DOWN AND MAY CAUSE SERIOUS INJURY. *YH

SEAT BELTS

SEAT BELT SEAT BELT WARNING LIGHT AND BEEP GO ON AND OFF INTERMITTENTLY WHILE DRIVING DUE TO AN ELECTRICAL CONNECTOR WEARING THROUGH IN THE DRIVERS SHOULDER BELT RETRACTOR LOCATED IN THE CENTER CONSOLE. REPLACED SEVERAL TIMES UNDER WARRANTY. PART IS NEARLY $300. SEVERAL PEOPLE I KNOW WITH THIS MODEL AND YEAR HAVE THE SAME PROBLEM.*AK