2006 Mazda Rx-8

2006 Mazda RX-8 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 18V402000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North America Operations (Mazda) is recalling certain 2005-2006 Mazda MPV vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. On July 9, 2019 this recall was expanded to include certain 2005-2009 RX-8 vehicles that were previously recalled under 17V-011 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 18V404000

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Campaign: 17V474000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles. Heat from the engine and the exhaust may cause the main fuel pump pipe to crack.

Campaign: 17V354000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles manufactured April 10, 2003, to February 18, 2008. The affected vehicles have fuel pump sealing rings that may deteriorate due to exposure to heat from the engine or exhaust pipe.

Campaign: 16V793000

ENGINE

The contact's grandson owns a 2006 Mazda RX-8. The contact stated that while her grandson was driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to an independent mechanic, who informed the contact that the vehicle had an oil pressure failure. The manufacturer was not made aware of the failure. The failure mileage was unknown.

STEERING

THERE IS A WHITE BUSHING THAT BREAKS AND IS NOT REPLACEABLE. THE WHOLE STEERING COLUMN HAS TO BE REPLACED. THE FACT THAT THIS CAR WAS MADE WITH THIS FLAW IS BEYOND MY COMPREHENSION. THE STEERING WHEEL BECOMES VERY LOOSE AND UNSAFE TO DRIVE.

FUEL/PROPULSION SYSTEM

PERRY MAZDA OF SANTA BARBARA CA IS REFUSING TO REPAIR MY RECALL BECAUSE THE FUEL PUMP CURRENTLY INSTALLED IS AN AFTERMARKET PART. I'VE CONTACTED MAZDA, BUT THE REPRESENTATIVE I SPOKE WITH AGREED WITH THE TECHNICIAN THAT THEY CAN'T REPAIR MY RECALL. HE IS LOOKING INTO ANOTHER SOLUTION SO I CAN GET MY REGISTRATION, BUT I'M MAKING SURE THEIR ACTING LEGALLY.

POWER TRAIN,UNKNOWN OR OTHER

THE BRACKET FOR THE CLUTCH PEDAL HAS BROKEN 4 TIMES. THE MILAGE IS CURRENTLY 81,000. I'VE CONTACTED MAZDA CORP AND THE DEALER I BOUGHT IT FROM NEW. THEY'RE SAYING UNLESS THERE'S A RECALL WE HAVE TO KEEP BUYING A NEW PEDAL/BRACKET ASSEMBLY. THE METAL THEY USED IS SOFT AND WEAK CAUSING YOU TO LOSE CONTROL OF THE CLUTCH. PEDAL GETS STUCK TOO. IT HAPPENS WHILE DRIVING AND AT IDLE. DANGEROUS GOING UP OR DOWN HILLS EVEN AT INTERSECTIONS IT'LL DISABLE YOUR ABILITY TO MOVE. WHEN MAZDA DOES A REPAIR THE PUT THE SAME WEAK JUNK NOT BOTHERING TO REINFORCE OR EVEN FIX THEIR PROBLEM. LOOK IT UP ON THE WEB. JUST ABOUT EVERYONE WITH A MANUAL RX8 HAS THE SAME PROBLEM.

STEERING

I'M WRITING TO STATE ON MY RX8 SHINKA 2006 MAZDA HAS A STEERING WHEEL PROBLEM MOST CONCERNING. I HAVE OWNED IT AND MAINTAINED IT. AS I WAS LEAVING MY BANK I NOTICED A WHITE GASKET OF KIND ON THE FLOOR OF THE DRIVERS SIDE. I WENT TO DRIVE MY CAR AND THERE WAS A LOT OF PLAY IN MOVING THE STEERING WHEEL. AT FIRST I TRIED UNLOCKING AND LOCKING THE STEERING COLUMN. THIS WAS NO GOOD. THERE WAS STILL PLAY IN THE STEERING WHEEL. MEANING YOU CAN MOVE THE STEERING WHEEL COLUMN UP AND DOWN WITH OUTSIDE UNLOCKING THE COLUMN. THIS SHOULD NOT BE AN ISSUE. IT'S JUST LIKE THE AIR BAG RECALL. I SHOULDN'T HAVE TO WORRY THAT MY STEERING WHEEL WILL FAIL WHILE DRIVING MY AWESOME CAR!

ENGINE

TAKATA RECALL THE VEHICLE WAS STUTTERING AS I WAS DRIVING HOME IT WASN'T HOT OR OVERHEATING OR LOW ON OIL, I DROVE IT HOME AND SHUT IT OFF I THEN LATER TRIED TO START IT IT WOULDN'T START IT JUST CRANKED AND CRANKED IT WOULDN'T EVEN START OR TRY TO , THE APEX SEALS ON THIS CAR WENT OUT WHICH IS DUE TO THE LOSS OF COMPRESSION WHICH ULTIMATELY CAUSED THE SPUTTERING, MAZDA IS WELL AWARE OF THIS ISSUE AS IT WAS RECALLED ALMOST A YEAR AGO BUT I DIDN'T HAVE THE ISSUE SO I DIDN'T SEE A NEED TO GET IT REPLACED ! THIS ISSUE IS UNACCEPTABLE AS NOW I'M WITHOUT A CAR PLEASE HELP ME OUT !

POWER TRAIN

THE CLUTCH PEDAL BINDS UP,OR STICKS DURING RELEASING FROM THE FLOOR,WAS REPLACED BEFORE AND STILL HAS THE SAME ISSUE AND MY LOCAL MAZDA DEALERSHIP DOES NOT WANT TO HEAR THE COMPLAINT,NOW I WILL PAY OUT OF POCKET FOR THEIR REPEATED DEFECT!

UNKNOWN OR OTHER,ENGINE

MY VEHICLE EXPERIENCED A DEFECT KNOWN TO MAZDA TO THE EXTENT OF THEM ISSUING A RECALL (OR SSP) IN THE CANADIAN MARKET DUE TO USE OF CORROSIVES AND EXCESSIVE WET SEASONS CAUSING BUILD UP ON AND CORROSION OF THE OIL COOLER LINES. MAZDA CLEARLY STATED IN THE CANADIAN SSP (#76) THAT EXTENSIVE CORROSION COULD CAUSE A LEAK AND/OR LOSS OF PRESSURE, AND KNOWING THAT A LOSS OF PRESSURE OR A SIGNIFICANT AMOUNT OF OIL WHILE THE CAR WAS IN OPERATION WOULD CAUSE DRASTIC MECHANICAL ENGINE FAILURE BY WAY OF BURNING OUT THE SEALS/ROTORS/BEARINGS AND EVENTUAL SEIZURE OR TOTAL LOSS OF COMPRESSION IN THE MOTOR. THE LOSS OF OIL PRESSURE DUE TO CORROSION DIRECTLY RESULTING FROM THIS CAUSED MY APEX SEALS TO OVERHEAT AND NO LONGER PROVIDE A SEAL TO ALLOW THE MOTOR TO HOLD COMPRESSION. DUE TO THIS FAILURE DIRECTLY CAUSED BY THE KNOWN DEFECT, AND THE FACT THAT THE ISSUE WAS PUT IN PLACE FOR CANADA DUE TO THEIR HIGH PROPENSITY FOR EXTENDED WET SEASONS AND HIGH USE OF CORROSIVES TO ALLEVIATE WINTERY CONDITIONS ON THE ROADWAYS, MAZDA SHOULD ALSO HAVE ISSUED REGIONAL OR CASE-BY-CASE RECALLS OF VEHICLES THAT EXPERIENCE THIS SAME DEFECT IN AREAS OF THE UNITED STATES THAT EXPERIENCE SIMILAR CONDITIONS. HAD I BEEN TRAVELLING ON THE HIGHWAY AND NOT ON A 25MPH CITY ROAD, I COULD HAVE EXPERIENCE A MAJOR ACCIDENT OR INCIDENT BECAUSE OF MY MOTOR FAILURE. THERE ARE NUMEROUS OTHER CASES OF THIS DEFECT SHOWING IN AMERICAN VEHICLES ACROSS THE COUNTRY, FROM NEAR ME (IN NEW ENGLAND) TO CALIFORNIA THAT HAVE BEEN REPORTED ONLINE. I CAN CONTACT THE LICENSED MECHNIC WHO DEALT WITH THE VEHICLE FOR COPIES OF HIS WORK ORDERS, AND I HAVE RECEIPTS TO PROVE THAT I PURCHASED OIL COOLER LINES AS REPLACEMENTS BEFORE I KNEW OF THE LOSS OF COMPRESSION AND RUINED MOTOR. MAZDA USA WAS OF NO HELP IN ALLEVIATING THE PROBLEM, AND I AM NOW OUT THOUSANDS OF DOLLARS ON A VEHICLE THAT I HAD RECENTLY PURCHASED BEFORE THE EVENT OCCURRED

POWER TRAIN

I WAS DRIVING TO WORK ON THE EVENING OF FEBRUARY 21ST. I WAS STOPPED AT A STOP LIGHT AND THE LIGHT TURNED GREEN SO I PRESSED ON THE CLUTCH TO GET THE CAR IN GEAR, WHEN I PUSHED DOWN HOWEVER, THE CLUTCH MADE A LARGE SNAPPING SOUND AND MOVED DOWN A LITTLE FURTHER THAN USUAL. I WENT TO PUT THE CAR BACK INTO GEAR ANYWAY AND NOTICED THAT THE CLUTCH WAS MUCH LOOSER THAN BEFORE. IT WAS WIGGLING FROM SIDE TO SIDE AND HAD MUCH MORE DEAD SPACE BEFORE IT CAUGHT ON THE ACTUAL CLUTCH. I ALSO NOTICED IT WAS MUCH MUCH HARDER TO GET MY CAR INTO GEAR. I HAVE TO PUSH AND SLAM THE STICK INTO GEAR IN ORDER TO GET IT TO FIT. I DID SOME RESEARCH AND THIS WAS ACTUALLY A VERY COMMON PROBLEM FOR THE 2004-2007 MAZDA RX-8'S. THE CAR CAN STILL BE DRIVEN, HOWEVER I BELIEVE THE FULL CLUTCH SHAFT COULD SNAP OFF IF PRESSED TO HARD.

POWER TRAIN

CLUTCH PEDAL SNAP OFF ISSUE WITH RX-8 OWNERS CONTINUES TO BE A SERIOUS SAFETY CONCERN, AS THE WELDS HOLDING THE PEDAL TOGETHER CAN AND WILL SNAP, LEAVING THE DRIVER UNABLE TO CHANGE GEARS OR USE THEIR VEHICLE, EVEN IF IN OPERATION AND AT HIGHWAY SPEEDS. THIS ISSUE HAS OCCURRED WITH MY VEHICLE AS OF 11/20/17. THE WARRANTY MAZDA HAS ISSUED SIMPLY IS NOT GOOD ENOUGH, AS THE WARRANTY SIMPLY REPLACES THE BROKEN CLUTCH PEDAL BRACKET WITH ONE OF THE SAME DESIGN & FLAW THAT WILL LEAD TO THE SAME FAILURE. MY VEHICLE WAS IN MOTION AND I WAS ATTEMPTING TO CHANGE GEARS ACCELERATING WHEN THIS OCCURRED.