2006 Mitsubishi Endeavor

2006 Mitsubishi Endeavor 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.

Campaign: 08V454000

SEAT BELTS:FRONT

ON CERTAIN PASSENGER VEHICLES, THE RIGHT SIDE LOWER SEAT BELT ANCHOR MAY SEPARATE DURING A SEVERE VEHICLE CRASH.

Campaign: 08V022000

ELECTRICAL SYSTEM:SOFTWARE

MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2006-2008 ENDEAVOR WITH MANUAL AIR CONDITIONING. DUE TO AN INCORRECT HEATER (HVAC) CONTROLLER SIGNAL, THE AIR FLOW FROM THE AIR VENTS MAY RANDOMLY CHANGE DIRECTION AND/OR THE TEMPERATURE MAY BRIEFLY CYCLE BETWEEN HOT AND COLD.

Campaign: 10V514000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2004-2010 ENDEAVOR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND WASHINGTON D.C. COLD STATES INCLUDE NORTH DAKOTA, SOUTH DAKOTA, NEBRASKA, KANSAS, OKLAHOMA, COLORADO, WYOMING, MONTANA, IDAHO, WASHINGTON, OREGON, AND UTAH. ADJOINING STATES INCLUDE ARKANSAS, TENNESSEE, AND NORTH CAROLINA. IN SEVERE CORROSIVE ENVIRONMENTS WHERE ROAD SALTS ARE FREQUENTLY USED IN WINTER VEHICLES MAY BE EXPOSED TO ROAD DEBRIS (MUD) MIXED WITH ROAD SALT. THIS MATERIAL CAN BECOME TRAPPED BETWEEN A REINFORCING BRACKET AND THE FUEL FILLER PIPE, POTENTIALLY CAUSING CORROSION. OVER TIME, CORROSION COULD CREATE A LEAK IN THE FUEL FILLER PIPE THAT COULD RESULT IN A FUEL LEAKAGE WHEN FUELING THE VEHICLE.

Campaign: 10V065000

ELECTRICAL SYSTEM:IGNITION

MITSUBISHI IS RECALLING 120,000 MY 2004-2006 ENDEAVOR PASSENGER VEHICLES. DURING VEHICLE USE, THE IGNITION KEY INTERLOCK CABLE (WHICH IS A COMPONENT OF THE INTERLOCK SYSTEM) MAY ALLOW THE INTERLOCKING CAM TO FALL FORWARD AND ALLOW THE IGNITION KEY TO BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.

Campaign: 08V139000

FUEL SYSTEM, GASOLINE

The contact owns a 2006 Mitsubishi Endeavor. The contact stated that while driving at an undisclosed speed, he smelled an abnormal gasoline odor inside the interior of the vehicle. After a visual inspection, the contact observed corrosion on the fuel filler pipe. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number 10V065000 (Fuel System, Gasoline); the VIN was included, and had already been repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 195,000.

FUEL/PROPULSION SYSTEM

I JUST HAD TO PAY FOR A REPAIR FOR THE FUEL FILLER PIPE. IT WAS LEAKING AS I WOULD FILL THE CAR WITH GAS. THIS MODEL HAD A RECALL FOR THIS PROBLEM BUT MY CAR VIN WAS NOT INCLUDED.T HE PART THEY PUT DOWN ON THE BILL WAS "THE RECALL KIT". I FEEL THAT MINE SHOULD HAVE BEEN COVERED ALSO. *TR

FUEL/PROPULSION SYSTEM

THE GAS TANK UP ON TOP IS LEAKING GAS ONTO THE PIPE, I HAVE LOOKED IN ALL THE LOCAL JUNK YARDS AND THEY HAVE TOLD ME THAT THEIR VEHICLES IN THE YARD ALL HAVE THE SAME PROBLEM. *TR

STRUCTURE

TL* THE CONTACT OWNS A 2006 MITSUBISHI ENDEAVOR. THE CONTACT STATED THAT THE REAR DRIVER'S AND REAR PASSENGER DOORS DID NOT OPEN. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 153,000. THE VIN WAS NOT PROVIDED.

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM,VISIBILITY/WIPER

WINDSHIELD RANDOMLY FOGS OVER. HEAT SWITCHES RANDOMLY BETWEEN HEAT AND AC. GAS PEDAL STICKS EVEN WHEN APPLYING PRESSURE TO BRAKES CAR ACTS LIKE THE GAS PEDAL IS FLOORED. CAR LUNGES FORWARD EVEN WHEN BRAKES ARE APPLIED. VEHICLE CAN BE STATIONARY AND STILL LUNGES ALSO HAS HAPPENED WHEN IT'S IN MOTION HAS HAPPENED IN CITY AND AND RURAL AREAS.

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES

A.C. IS DRAINING INTO THE INTERIOR OF THE VEHICLE CAUSING THE CARPET AND FLOORING ON THE DRIVER SIDE UNDER TO THE DRIVER SEAT TO BECOME SOAKED THROUGH AND WILL NOT DRAIN OUT. ON SEVERAL OCCASIONS, FOOTWEAR HAVE SLIPPED ON THE BREAK AND GAS PEDALS DUE TO MOISTURE ACCUMULATED ON THE BOTTOM OF THE SHOE. THE SHOE IS NOT ABLE TO DRY AND PROPERLY GRIP THE GAS AND BRAKE PEDALS DUE TO THE ACCUMULATED MOISTURE SOAKED THROUGH THE CARPETING UNDER FOOT. HAVE CONTACTED LOCAL MITSUBISHI DEALERSHIP: THE A.C. ISSUE IS A KNOWN ISSUE AND THEY WILL NOT COVER THE COST OF REPAIR EVEN THOUGH IT IS CAUSING SAFETY ISSUES WITH VEHICLE STOPPING AND ACCELERATING. CONTACTED MITSUBISHI CORPORATE AND RECEIVED THE SAME COMMUNICATION THAT WAS RELAYED BY THE LOCAL DEALERSHIP.

UNKNOWN OR OTHER

THE AC GETS COLD ON THE DRIVER SIDE BUT THE PASSENGER SIDE ONLY THE HEAT WORKS. YOU CAN CHANGE THE TEMPERATURE BUT NOTHING HAPPENS IT WILL REMAIN THE SAME. I TOOK MY CAR TO THE DEALER AND WAS TOLD THAT THERE IS NO RECALL CONCERN ING THIS ISSUE BUT FROM WHAT I HAVE GATHERED FROM OTHER CUSTOMERS WHO OWN THIS TYPE OF DR THEY ARE HAVING THE EXACT SAME ISSUE. THE DEALER CAN'T FIGURE OUT WHAT IS THE PROBLEM AND I PAID $1,600 FOR AN UNFIXED AC UNIT.

ENGINE,FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2006 MITSUBISHI ENDEAVOR. THE CONTACT INQUIRED ABOUT A RECALL AND WAS INFORMED THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. THE CONTACT STATED THAT THE FUEL INDICATOR ILLUMINATED AND FUEL WAS LEAKING FROM THE VEHICLE WHILE PARKED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE CONTACT CALLED A LOCAL DEALER (VALLEY IMPORTS, 402 40TH ST S FARGO, ND 58103), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND INFORMED THE CONTACT THAT THE UNKNOWN RECALL HAD EXPIRED. THE FAILURE MILEAGE WAS UNKNOWN.

STRUCTURE

ORIGINALLY THE LIFTGATE WOULD NOT OPEN ONLY THE GLASS TOP WOULD OPEN. A COMMON ISSUE ACCORDING TO SEVERAL MITSUBISHI ENDEAVOR OWNER FORUMS FOR ENDEAVORS FROM 2004 TO 2008. RECENTLY BOTH LIFTGATE AND GLASS WOULD NOT OPEN AT ALL UNLESS I USED THE MANUAL RELEASE LOCATED ON THE INSIDE PART OF THE LIFTGATE. HOWEVER, WHILE DRIVING RECENTLY THE LIFTGATE AND OR GLASS TOP ACTUATED ITSELF CAUSING THE LIFTGATE TO UNLOCK ON ITS OWN AND OPEN. IF IT WERE NOT FOR THE DINGING OF THE DASH INFORMING ME ONE OF MY DOORS WAS OPEN I WOULD HAVE NEVER NOTICED. THIS COULD HAVE CAUSED THE CONTENTS OF MY TRUNK TO SPILL OUT ON THE ROAD AND ONLY GOD KNOWS WHAT COULD'VE HAPPENED. MY MECHANIC RECOMMENDED I CHANGE BOTH LATCHES TO BE SAFE ($100 EACH) HOWEVER THIS IS A REOCCURRING PROBLEM SO IT WOULD ONLY BE A MATTER OF TIME BEFORE I'D BE BACK HAVING TO REPLACE THEM AGAIN. I VERIFIED THIS WITH TESTIMONIALS FROM OTHER ENDEAVOR OWNERS VIA MULTIPLE FORUMS AND REPAIR BLOGS....

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2006 MITSUBISHI ENDEAVOR. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT THE FUEL FILLER PIPE WAS CORRODED AND CAUSED THE FUEL TO LEAK FROM THE FUEL FILLER PIPE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 10V065000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.