1995 Mitsubishi Galant

1995 Mitsubishi Galant 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES. CRACKS CAN OCCUR IN THE TOP OF THE FUEL TANK DUE TO AN IMPROPER SPOT WELD ON THE BAFFLE PLATE TO THE TOP PORTION OF THE FUEL TANK.

Campaign: 00V237000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Campaign: 00V421001

EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER VEHICLES. WHEN THE STOP LAMP SWITCH WAS ASSEMBLED, GREASE WAS INADVERTENTLY APPLIED TO THE CONTACT POINT. THIS CAN CAUSE THE CONTACT POINT TO HEAT UP CAUSING INTERNAL OPERATION ELEMENTS TO MELT ALLOWING THE SWTICH TO BECOME STUCK IN ON OR OFF POSITION.

Campaign: 98V212000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT IN JAPAN. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Campaign: 99V066002

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Campaign: 99V066001

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Campaign: 07E055000

ENGINE

TL* THE CONTACT OWNS A 1995 MITSUBISHI GALANT. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE CHECK ENGINE SENSOR LIGHT AND BRAKE SENSOR LIGHT ILLUMINATED AND CONTINUED TO FLASH OFF AND ON. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 201,000.

UNKNOWN OR OTHER

I SPRAYED MY 95 MITSUBISHI GALANT MOTOR OFF AND RINSED IT OFF, IT RAN FOR ABOUT TWENTY MINUTES AND THEN SHUT OFF. NOW ITS JUST TURNING AD WILL NOT START. *TR

ELECTRICAL SYSTEM

IT STARTED WITH MY LIGHTS AND RADIO STAYING ON EVEN WHEN THE CAR WAS OFF, IT WAS LIKE THAT FOR A FEW DAYS THEN I WAS DRIVING UP THE ROAD TO MEET SOME FRIENDS WHEN I SPELLED SOMETHING BURNING THEN SMOKE STARTED ROLLING OUT OF MY STEERING COLUMN. *TR

EXTERIOR LIGHTING

TL*THE CONTACT OWNS A 1995 MITSUBISHI GALANT. THE CONTACT STATED THAT THE ABS LIGHT IN THE VEHICLE WOULD ILLUMINATE. HE WOULD ALSO HAVE TO PULL THE FUSE ON THE DRIVER'S SIDE TURN SIGNAL BECAUSE IT APPEARED TO BE STUCK. THE FAILURE OCCURRED EVERYTIME THE VEHICLE WAS DRIVEN. THE MANUFACTURER STATED THAT THEY WOULD NOT HONOR NHTSA CAMPAIGN ID NUMBER 98V212000 (EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH) BECAUSE HIS VIN WAS NOT INCLUDED. THE CONTACT WILL PAY TO HAVE THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 155,852 AND FAILURE MILEAGE WAS APPROXIMATELY 150,000.

SUSPENSION

TL*THE CONTACT OWNS A 1995 MITSUBISHI GALANT. WHILE MAKING A LEFT TURN AT APPROXIMATELY 5 MPH, THE FRONT DRIVER'S SIDE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V421001 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). THE DEALER HAS NOT INSPECTED THE VEHICLE. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 117,000.

SERVICE BRAKES, HYDRAULIC

ANTILOCK BRAKE MALFUNCTIONED ON SEVERAL OCCASIONS WHEN THERE WAS NEED TO BRAKE SUDDENLY RESULTING IN SEVERAL NEAR CRASHES. WHEN BRAKE WAS APPLIED GRINDING NOISE HEARD AND THEN ANTI LOCK BRAKE LIGHT CAME ON AND REMAINED ON. THIS HAS OCCURRED TOO OFTEN AND MITSUBISHI NEEDS TO RECALL THIS MODEL AND FIX IT. THE LATEST INCIDENT OCCURRED ON AUGUST 5, 2007, BUT THERE HAVE BEEN SEVERAL INSTANCES OF THIS HAPPENING BEFORE. *TR

ENGINE AND ENGINE COOLING

1995 MITSUBISHI GALANT CAUGHT FIRE IN THE ENGINE COMPARTMENT. *KB PRIOR TO THE FIRE, THE HEAD GASKET COVER WAS REPLACED.(OHIO TRAFFIC CRASH REPORT) *JB

SERVICE BRAKES, HYDRAULIC

TL*- THE CONTACT STATED THAT THE 1995 MITSUBISHI GALANT ABS LIGHT TURNED ON 03/11/07. HE STATED THAT WHILE DRIVING THE VEHICLE IN THE EVENING HOURS AT THE SPEED OF 50-55 MPH THE ABS LIGHT TURNED ON. HE NOTICED A CHANGE IN THE BRAKE SYSTEM. HE STATED THAT THE BRAKE PEDAL BECAME DIFFICULT TO PRESS. HE CALLED THE DEALERSHIP ON 3/12/07, AND THEY INFORMED HIM TO CHECK AND SEE IF THE VEHICLE WAS ON RECALL ,AND IF IT WAS, TO CALL THEM BACK. THE CONTACT FOUND NO RECALL FOR THE ABS, BUT DID FIND A NUMBER OF COMPLAINTS WITH THE SAME PROBLEM. THE CONTACT STATED THAT THE ABS LIGHT CONTINUED TO STAY ON. HE STATED THAT HE HASN'T DRIVEN THE VEHICLE RECENTLY, BUT DID START IT UP, AND THE LIGHT ABS LIGHT WAS STILL ON. THE CURRENT MILEAGE WAS 150000.*AK

SUSPENSION

DT*: THE CONTACT STATED WHILE DRIVING AT 15 MPH, THERE WAS A LOUD NOISE. THE CONTACT LOOKED UNDER THE VEHICLE AND SAW THE TIRE WAS BUCKLED OUT. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE LEFT BALL JOINT HAD PULLED OUT OF THE SOCKET WHICH PULLED THE AXLE APART. THERE WAS A RECALL, NHTSA RECALL, # 99V066002 PERFORMED ON THE VEHICLE IN 2001 CONCERNING, THE SUSPENSION: FRONT: CONTROL ARM: LOWER BALL JOINT FOR THE RIGHT SIDE. THIS COMPLAINT WAS REGARDING THE LEFT LOWER BALL JOINT OF THE VEHICLE. UPDATED 09/15/06. *JB

STEERING,SUSPENSION,VISIBILITY

WHEN DRIVING THE CAR THE FRONT END WAS MAKING VERY LOUD NOISES WHICH BECAME WORSE WHEN DRIVING OVER BUMPY ROADS. I HAD ONE TIE ROD REPLACED A FEW YEARS AGO BUT THE NOISE WAS ONLY SLIGHTLY BETTER AND NO ONE COULD FIGURE OUT WHAT WAS CAUSING IT. THE NOISE GOT SEVERE AND I TOOK IT TO ANOTHER MECHANIC AND I HAD TO HAVE THE LEFT AND RIGHT TIE RODS, THE LEFT AND RIGHT SIDE STABILIZER BARS AND THE DRIVER SIDE UPPER CONTROL ARM REPLACED. THERE WAS A RECALL ON THE CAR IN APPROXIMATELY 2000 AT WHICH TIME I BROUGHT THE CAR IN TO THE DEALERSHIP WHERE THEY SUPPOSEDLY INSPECTED IT AND SAID THERE WAS NOTHING WRONG AND NO PARTS WERE REPLACED. I AM NOW HAVING THESE PROBLEMS WITH THE CAR THAT ALL SEEM TO BE RELATED TO THE RECALL REGARDING THE FRONT SUSPENSION. THERE IS ALSO A PROBLEM WITH THE ACCELERATOR PEDAL STICKING WHICH NOW NEEDS TO BE FIXED. AND ON RAINY DAYS IT HAS BECOME ALMOST IMPOSSIBLE TO DRIVE THE CAR BECAUSE THE FRONT WINDOW DEFOGGER DOES NOT SEEM TO WORK PROPERLY AND THE INSIDE OF THE CAR FOGS UP SEVERELY CAUSING ME TO HAVE TO PULL OFF THE ROAD. *NM