1996 Mitsubishi Galant

1996 Mitsubishi Galant 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES. CRACKS CAN OCCUR IN THE TOP OF THE FUEL TANK DUE TO AN IMPROPER SPOT WELD ON THE BAFFLE PLATE TO THE TOP PORTION OF THE FUEL TANK.

Campaign: 00V237000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Campaign: 00V421001

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Campaign: 99V066001

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Campaign: 07E055000

STRUCTURE

TL* THE CONTACT OWNS A 1996 MITSUBISHI GALANT. THE CONTACT STATED THAT ROUTINE MAINTENANCE WAS BEING PERFORMED ON THE VEHICLE WHEN SHE WAS NOTIFIED THAT THE FRAME WAS CORRODED. THE MECHANIC STATED THAT THE VEHICLE NEEDED TO BE DESTROYED AND WAS NO LONGER SAFE TO OPERATE. THE DAMAGE WAS BEYOND REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER COVERED UNDER WARRANTY. THE FAILURE AND THE CURRENT MILEAGE WAS 179,000.

POWER TRAIN

MY MITSUBISHI MAGNA 1996 HAD VERY LITTLE MECHANICAL PROBLEMS BEFORE LAST YEAR WHEN I WAS DRIVING ALONG AND NOTICED AND OVERREV AND SUDDEN BUMP INTO 3RD GEAR AND OVER TIME IT FADED OUT TO NOTHING AND THEN I WAS DRIVING IT AND THEN LOST 3RD GEAR COMPLETELY...IT TRYS TO GO INTO THE 3RD GEAR BUT WON'T GO IN AND FALLS INTO NEUTRAL I'VE ASKED MANY AUTO TRANSMISSION PLACES AND THEY HAVE NO IDEA BUT WERE GOING TO CHARGE ME 1000 BUCKS TO LOOK AT IT SO I HAVEN'T HAD IT FIXED AND AM NOW GETTING ANOTHER CAR BUT I STILL WANT CLOSURE. *LN

SUSPENSION

I CURRENTLY BOUGHT THE 1996 MITSUBISHI GALANT FOR MY WIFE AND 11 MONTH OLD DAUGHTER. THE DEALER TOLD ME I NEEDED A FRONT END ALIGNMENT TO GET THE PULL AND SHAKE OUT OF MY FRONT END. I TOOK IT TO AN ALIGNMENT SHOP AND THE ASE MASTER TECH. TOLD ME MY CONTROL ARMS WERE BENT DUE TO CORROSION OF THE BALL JOINT, HE THEN TOLD ME THERE WAS A RECALL ON THESE VEHICLES AND IF I DON'T GET THE PROBLEM FIXED IT COULD RESULT IN A LOSS OF STEERING. I DON'T THINK IT WOULD BE SAFE FOR MY WIFE TO LOSE STEERING WITH OUR INFANT DAUGHTER SO NOW I GOT BIGGER PROBLEMS THEN A TWENTY FIVE DOLLAR FRONT END ALIGNMENT. I'M UPSET AT THE DEALER FOR NOT INFORMING ME WITH THESE RECALLS NOT THE MANUFACTURE FOR MAKING THE BAD PART. PLEASE HELP BEFORE IT IS TOO LATE. *TR

STRUCTURE

TL*THE CONTACT OWNS A 1996 MITSUBISHI GALANT. WHILE ATTEMPTING TO CHANGE A FLAT TIRE, THE JACK WENT STRAIGHT THROUGH THE FRAME WHILE THE VEHICLE WAS BEING LIFTED. THE CONTACT HAD THE VEHICLE TOWED TO A SHOP AND THEY INFORMED HIM THAT THERE WAS EXCESSIVE RUST IN THE REAR SUBFRAME. THE CONTACT SOLD THE VEHICLE RATHER THAN HAVE IT REPAIRED. THE FAILURE MILEAGE WAS 150,000.

STRUCTURE

TL*THE CONTACT OWNS A 1996 MITSUBISHI GALANT. THE REAR WHEEL ASSEMBLY IS ATTACHED TO THE SUBFRAME, WHICH IS ATTACHED TO THE BODY. THE ENTIRE PART IS EXTREMELY RUSTED AND PREVENTED THE CONTACT FROM JACKING THE VEHICLE AND CHANGING THE TIRE. THE DEALER NOTIFIED THE CONTACT OF THIS FAILURE. THE FAILURE IS NOTICEABLE WHILE DRIVING 20 MPH. THE FAILURE MILEAGE WAS 130,000 AND CURRENT MILEAGE WAS 162,000. UPDATED 01-11-08. *KB UPDATED 12/31/07 *TR

STRUCTURE

THE REAR UNDERCARRIAGE OF MY 1996 MITSUBISHI GALANT HAS SEVERE RUST DAMAGE TO THE POINT THAT YOU CANNOT EVEN JACK UP THE CAR AS THE JACK PENETRATES THEY SUB FRAME. THE STRUT FROM THE RIGHT REAR ALSO CAME LOOSE FROM THE TOWER. THE REAR WHEELS THAT ARE ATTACHED TO THE SUB FRAME ARE EXTREMELY UNSAFE. *TR

STRUCTURE

TL* - THE CONTACT OWNS A 1996 MITSUBISHI GALANT. DURING ROUTINE MAINTENANCE CHECKS THE MECHANIC DISCOVERED RUST ON THE FRAME UNDER THE VEHICLE IN FRONT OF EACH REAR WHEEL. THE CURRENT MILEAGE WAS 157000 AND THE FAILURE MILEAGE WAS 155000. *AK UPDATED 2/27/2007 - *NM

SUSPENSION

BOTH BALL JOINTS ON THE CONSUMERS 1996 MITSUBISHI GALANT FAILED, BREAKING THE DRIVE AXLE. *TS AFTER DOING SOME RESEARCH, THE CONSUMER DISCOVERED A RECALL HAD BEEN ISSUED FOR THE BALL JOINTS. THE CONSUMER NEVER RECEIVED ANY TYPE OF NOTIFICATION. THE CONSUMER WAS TOLD BY THE MANUFACTURER THAT THE RECALL WORK HAD ALREADY BEEN DONE, HOWEVER THAT PROVED TO BE NOT TRUE AND SINCE THEN THE MANUFACTURER HAS AGREED TO PAY FOR THE COST OF THE BALL JOINT, BUT NOTHING ELSE WHICH WOULD BE A LITTLE OVER 200.00, HOWEVER THE TOTAL COST OF THE REPAIR BILLS WERE CLOSE TO 1000.00. *JB

POWER TRAIN

TRANSMISSION FLUID DIPSTICK IMPOSSIBLE TO READ, NOTIFIED DEALER, DEALER SAID THAT'S JUST HOW IT IS DESIGNED. I'M WORRIED BECAUSE TRANMISSIONS ARE A COMMON FAILURE ON THIS GENERATION OF MITSUBISHI GALANT. CAN THIS BE CORRECTED BY A DIPSTICK REDESIGN?

POWER TRAIN

THE MANUAL TRANSMISSION OF MY 1996 MITSUBISHI GALANT SLIPS OUT OF GEAR AT VARIOUS SPEEDS AND REENGAGES. CONTROL OF THE VEHICLE IS LOST WHEN THIS HAPPENS.*AK