1997 Mitsubishi Montero

1997 Mitsubishi Montero 4-DR. 4x4

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

UNKNOWN OR OTHER

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.

Campaign: 98V205000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER.

Campaign: 98V220000

SUSPENSION,POWER TRAIN,TIRES

TL* THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. WHILE DRIVING BETWEEN 55 AND 65 MPH, THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BALL JOINTS, WHEEL BEARINGS, TRANSMISSION MOUNT, UNIVERSAL BOLT, AND TIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 00V311001 (ENGINE AND ENGINE COOLING), BUT THE VIN WAS EXCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000.

ENGINE

VEHICLE LOST POWER STEERING AND STALLED. CRANKSHAFT PULLEY BOLT FELL OUT AND HARMONIC BALANCER FELL OFF.CAUSING LOSS OF CONTROL AND LIFE THREATENING SITUATION. *TR

ENGINE

COMMON PROBLEM WITH THESE, CRANK SHAFT PULLEY BOLT DEFECTIVE SHOULD HAVE RECALLED ALL OF THEM. *TR

STEERING,POWER TRAIN

CRANKSHAFT PULLEY BOLT CAME LOOSE CAUSING LOSS OF STEERING. HAD TO STEER VERY HARD MANUALLY TO PARK CAR. DANGEROUS SITUATION. *TR

ELECTRICAL SYSTEM,SEATS

ON 5/31/14, MY 1997 MITSUBISHI MONTERO WAS PARKED IN MY DRIVEWAY. WHEN I WENT TO GET INTO THE VEHICLE, I NOTICED A LARGE BURN IN THE BACK OF THE DRIVER'S SIDE SEAT. AFTER CALLING MITSUBISHI, THE FIRE DEPARTMENT CAME SINCE IT WAS STILL SMOLDERING AND DISCONNECTED THE BATTERY. THEY BELIEVED IT TO BE AN ELECTRICAL SHORT. AFTER MANY FOLLOW-UP CALLS TO MITSUBISHI, THEY BELIEVE IT WAS CAUSED BY WEAR AND TEAR SINCE THE CAR WAS 17 YEARS OLD. ALL OF THE COST TO FIX THE ISSUE WAS ON ME AS THE OWNER. *TR

ENGINE AND ENGINE COOLING

1997 MITSUBISH MONTERO 3.5 LITER AUTOMATIC- CRANK SHAFT BOLT HAS COME OUT ON 5 SEPARATE OCCASIONS AND HAS COST OVER $3000 TO HAVE IT REPLACED. THE INSIDE OF THE CRANKSHAFT WHERE THE BOLT GOES IS COMPLETELY STRIPPED TO THE POINT I NOW HAVE TO REPLACE THE ENGINE. THIS IS NOT AN ISOLATED ISSUE AS THIS APPEARS TO BE AN INHERENT PROBLEM WITH ALL YEARS OF MONTEROS. THERE SHOULD BE A RECALL FOR THIS AND MITSUBISHI SHOULD COVER THE COST FOR THERE NEGLIGENCE. *TR

ENGINE AND ENGINE COOLING

CRANKSHAFT PULLEY PIN/BOLT GETS SHEARED OFF. DASH LIGHTS COME ON AND VEHICLE POWER STEERING STOPS WORKING AS THE PUMP IS NOT TURNING BECAUSE THE PROBLEM AFFECT THE ENTIRE PULLEY SYSTEM. IT ALSO AFFECTS THE TIMING GEAR/BELT/HARMONIC BALANCER. THIS IS THE 3RD TIME IN AS MANY YEARS THIS HAS HAPPENED. THIS IS THE 2ND MECHANIC WHO HAS TOLD ME THAT IT'S AN ENGINE DEFECT BECAUSE THE PIN/BOLT IS TOO SHORT. THERE IS NO WARNING BEFORE IT HAPPENS. IT OCCURS UNDER NORMAL CITY DRIVING CONDITIONS AT LOW OR NO SPEED. *TR

FUEL SYSTEM, GASOLINE,UNKNOWN OR OTHER

THE VEHICLE WAS PARKED AND IDLING. I WAS IN THE DRIVER'S SEAT WHEN A FIRE BROKE OUT AND THE FLAMES CAUSED ME SEVERE BURNS TO MY BODY. I WAS NEARLY ASPHYXIATED. THE CAR WAS A TOTAL LOSS. *TR

ENGINE AND ENGINE COOLING

1997 MITSUBISHI MONTERO CRANKSHAFT PULLEY CAME LOOSE THREE TIMES WHICH CREATED NO POWER STEERING AND NO CHARGING OF THE BATTERY PURCHASED NEW CRANKSHAFT PULLEY BUT DID NOT HELP THE THIRD TIME INSTALLED A LOCK WASHER ON THE BOLT AND RE TORQUED TO SPEC LAST WEEK. *TR

STEERING

STEERING TERMINAL CAME OFF MAKING THE VEHICLE GO IN DANGER. *TR