2004 Mitsubishi Outlander

2004 Mitsubishi Outlander 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

VISIBILITY:WINDSHIELD WIPER/WASHER

ON CERTAIN SPORT UTILITY VEHICLES LOCATED IN THE CARIBBEAN, DUE TO A SOFTWARE PROGRAMMING ERROR IN THE ELECTRONIC TIMING AND CONTROL SYSTEM (ETACS), WHILE USING THE INTERMITTENT WIPER MODE, THE INTERMITTENT WIPER SWEEP TIME INTERVAL MAY INCREASE AS MUCH AS 6.8 SECOND BETWEEN WIPER SWEEPS.

Campaign: 03V429000

TRAILER HITCHES

CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.

Campaign: 04V197000

EQUIPMENT:OTHER:LABELS

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.

Campaign: 04V428000

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Campaign: 16V458000

SUSPENSION

The contact owns a 2004 Mitsubishi Outlander. The contact stated that while driving at a slow speed, the front subframe detached. The contact stated that the driver’s side front wheel was pointing outwards. The contact received notification of NHTSA Campaign Number: 16V458000 (Suspension) however, the part to do the recall repair was not yet available. The vehicle was towed to the local dealer. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 180,000. Parts distribution disconnect.

SUSPENSION,UNKNOWN OR OTHER

The entire undercarriage is rusted out, it was taken to Ricart near columbus ohio where they simply sprayed an anti rust coating over the existing rust. There is now rusted holes and the vehicle has spun out driving in straight due to control arm issues and whatever else. The vehicle is not believed to be road safe and needs to be addressed.

STEERING,SUSPENSION

THE FRONT CONTROL ARM WHERE IT BOLTS TO THE K FRAME RUSTED AWAY COMPLETLY RESULTING IN THE FRONT DRIVERS TIRE TO COME OFF. WAS IN A GET IN GO PARKING LOT TURNING WHEN THIS HAPPENED LUCKLY NO ONE WAS HURT.

SUSPENSION

REAR SUBFRAME RUSTED THROUGH WHILE MOVING SLOWLY IN DRIVEWAY CAUSING THE DRIVER'S SIDE REAR WHEEL TO MISALIGN, MAKING THE CAR UNABLE TO MOVE. CAR WAS TOWED TO REPAIR SHOP WHERE REAR SUBFRAME WAS REPLACED.

STRUCTURE

TL* THE CONTACT OWNS A 2004 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME FRACTURED DUE TO RUST. THE VEHICLE WAS TAKEN TO DES MOINES MITSUBISHI (4475 MERLE HAY RD, DES MOINES, IA 50310, (515) 270-8100) FOR AN UNKNOWN RECALL REPAIR THAT INVOLVED EITHER REPLACING THE SUBFRAME OR APPLYING AN ANTI-CORROSION FLUID. THE CONTACT STATED THAT THE SUBFRAME WAS ALREADY RUSTED WHEN THE ANTI-CORROSION FLUID WAS APPLIED. THE MANUFACTURER WAS CONTACTED AND PROVIDED A CASE NUMBER. THE DISTRICT MANAGER WAS TO CALL THE CONTACT BACK. THE MANUFACTURER REMOVED THE ORIGINAL RECALL FROM THE CONTACT'S VIN AFTER THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 147,087.

SUSPENSION,STRUCTURE

2004 MITSUBISHI OUTLANDER. CONSUMER WRITES IN REGARDS TO CORROSION RECALL NOTICE INSTRUCTION ISSUES - DEALERSHIP APPLIED CORROSION SPRAY TO FRONT CROSS MEMBER AND LOWER CONTROL ARM BEFORE CONSULTING CONSUMER. *SMD *TR

SUSPENSION,STRUCTURE

TL* THE CONTACT OWNS A 2004 MITSUBISHI OUTLANDER. WHILE DRIVING 25-30 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR SUSPENSION WAS FRACTURED AND THAT THE DRIVER'S SIDE REAR WHEEL SEPARATED FROM THE VEHICLE. THE CONTACT STATED THAT THE FRACTURE WAS DUE TO SEVERE RUST. THE CONTACT WAS INFORMED THAT THE SUBFRAME SHOWED SEVERE AND EXTREME RUST. WALPOLE MITSUBISHI (575 BOSTON PROVIDENCE HWY, EAST WALPOLE, MA 02032, (508) 660-7000) WAS CONTACTED ABOUT THE FAILURE ON THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

STRUCTURE

I RECEIVED A SAFETY RECALL REGARDING THE FRONT CROSS BODY REGARDING RUST AND CORROSION. MY FRONT CROSS BODY FAILED WITH TOTAL RUST THROUGH. MECHANIC SHOWED ME THAT THE REAR CROSS BODY IS ALSO AFFECTED AND HAS A RUST THROUGH HOLE THE SIZE OF MY FIST. MITSUBISHI HAS REFUSED TO COVER THE REAR. THIS IS A TRUE SAFETY HAZARD AND NEEDS TO BE COVERED BY MITSUBISHI. *JS

AIR BAGS

TL* THE CONTACT OWNED A 2004 MITSUBISHI OUTLANDER. WHILE DRIVING APPROXIMATELY 50 MPH THROUGH A ROUNDABOUT, THE DRIVER LOST CONTROL OF THE STEERING WHEEL. THE FRONT PASSENGER PULLED THE MIDDLE EMERGENCY BRAKE TO STOP THE VEHICLE. AS A RESULT, THE VEHICLE FLIPPED OVER FOUR TIMES AND LANDED ON ITS ROOF. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER AND PASSENGERS WERE UNINJURED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW LOT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 280,000.

SUSPENSION,ENGINE

2004 MITSUBISHI OUTLANDER. CONSUMER WRITES IN REGARDS TO VEHICLE DRIVER SIDE LOWER CONTROL ARM / ENGINE CRADLE MALFUNCTION. CONSUMER SEEKS REIMBURSEMENT FOR LOWER CONTROL ARM CORROSION RECALL NOTICE REPAIRS. *SMD THE CONSUMER STATED THE ON NOVEMBER 20, 2015 THE LOWER CONTROL ARM ON THE DRIVER'S SIDE OF THE VEHICLE BROKE AWAY FROM THE ENGINE CRADLE. THE DRIVER'S SIDE TIRE SNAPPED BACK INTO THE WHEEL WELL. THE CONSUMER CONTACTED THE MANUFACTURER FOR REIMBURSEMENT BUT, THE MANUFACTURER HAD NOT RESPONDED. UPDATED 05/1/2017 *JS