2006 Mitsubishi Outlander

2006 Mitsubishi Outlander 4-DR w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Campaign: 16V458000

SUSPENSION

Control arm became unattached losing ability to steer and cracking the subframe on the front driver side.

SUSPENSION

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. WHILE DRIVING 65 MPH, THE DRIVER'S SIDE CONTROL ARM SNAPPED IN HALF WITHOUT WARNING. THE CONTROL ARM COLLAPSED ON BOTH FRONT TIRES, WHICH CAUSED THE VEHICLE TO IMMEDIATELY HALT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WOULD BE COVERED IF IT WERE STILL UNDER WARRANTY. THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 16V458000(SUSPENSION) AND ASSOCIATED IT WITH THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

SUSPENSION

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. WHILE DRIVING 25 MPH, THE FRONT CROSS MEMBER FAILED AND DAMAGED THE EXHAUST SYSTEM, THE LOWER CONTROL ASSEMBLY, THE STEERING ASSEMBLY, THE FRONT AXLE, THE STABILITY CONTROL, AND THE SHAFT ASSEMBLY. THE VEHICLE WAS TOWED TO PERUZZI MITSUBISHI (130 LINCOLN HIGHWAY, FAIRLESS HILLS, PENNSYLVANIA 19030, PHONE (888) 481-7599). THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION) AND THE DAMAGED PARTS WERE REPLACED. THE DEALER CHARGED THE CONTACT TO REPLACE THE ADDITIONAL PARTS. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

FUEL/PROPULSION SYSTEM

THE FUEL TANK HAD TO BE REPLACED BECAUSE THE FUEL VAPORS WERE LEAKING INTO THE CAB OF THE VEHICLE, THIS WAS TRULY AN OBSTACLE TO DRIVING THE VEHICLE. THE LOCAL MISUBISHI DEALER SAID THAT THIS WAS NOT UNUSUAL THE COST TO REPLACE THE FUEL TANK AND RELATED GASKETS, HOSE LINES, C;AMPS, ETC. WAS $1,750.00. FAST FORWARD TO JAN. 9, 2017 ;THE VEHICLE WAS CALLED IN TO BE INSPECTED FOR CORROSION OF FRONT CROSS MEMBER. MISUBISHI APPLIED ANTI RUST AGENTS TO THE CROSS MEMBERS IN QUESTION. THIS IS A SECONDARY ISSUE THAT I AM CONCERNED ABOUT THE COST I PAID FOR THE FUEL TANK ISSUE AND THE CORROSION ISSE OF THE CROSS MEMBERS. HOWEVER PRIMARILY MY CONCERN IS I QUESTION THE SAFETY OF EACH MATTER ALONG WITH THE POTENTIAL THAT OTHERS OWNERS MAY BE UNAWARE OF THE CIRCUMSTANES I HAVE LISTED AND JUST MIGHT EXPEREIENCE SOMETHING VERY TRAGIC.

STRUCTURE,SERVICE BRAKES

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. WHILE APPROXIMATELY 30-35 MPH, A LOUD NOISE WAS HEARD WHEN THE BRAKES WERE DEPRESSED. THE CONTACT PULLED THE VEHICLE OFF THE ROAD, INSPECTED UNDERNEATH THE VEHICLE, AND NOTICED THAT THE FRONT DRIVER SIDE TIRE WAS UP AGAINST THE WHEEL WELL AND THAT PART OF THE TIRE LINK WAS RUSTED AND SEPARATED. THE FRONT DRIVER SIDE TIRE LINK WAS DAMAGED, BUT WAS NOT FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

STRUCTURE

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V458000 (STRUCTURE: BODY) WAS RECEIVED IN AUGUST. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

SUSPENSION

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE CONTACT STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. WHILE DRIVING 25 MPH, THE HEADLIGHTS AND TAIL LIGHTS MALFUNCTIONED. THE CONTACT STATED THAT THE HEADLIGHTS AND TAIL LIGHTS WERE VERY DIM AND WOULD TURN ON AND OFF INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 142,000.

SUSPENSION

TL* THE CONTACT OWNS A 2006 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS INVALID. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

SUSPENSION

TL* THE CONTACT OWNED A 2006 MITSUBISHI OUTLANDER. WHILE DRIVING 50-60 MPH, THE VEHICLE SWERVED UNCONTROLLABLY WITHOUT WARNING. THE CONTACT WAS CONCERNED THAT THE FRONT SUSPENSION EXPERIENCED A FAILURE. THE CONTACT STATED THAT THE VEHICLE CROSSED THREE ONCOMING LANES AND CRASHED INTO A CEMENT BARRIER. THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MINOR INJURIES TO THE LOWER BACK THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT AVAILABLE.