2005 Nissan Frontier King Cab

2005 Nissan Frontier Extended Cab

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

NISSAN IS RECALLING CERTAIN FRONT AND REAR LOWER LINKS, P/NOS. 54501ZQ00A, 54500ZQ00A, 551A1ZQ00A, 551A0ZQ00A , 54501EA00A, 54500EA00A, 551A1EA500, 551A0EA500, 54501ZR00A, AND 54500ZR00A, SOLD BETWEEN NOVEMBER 25, 2009 AND MAY 14, 2010 AS REPLACEMENT PARTS FOR MODEL YEAR 2004 THROUGH 2010 TITAN, ARMADA, AND QX56, AND MODEL YEARS 2005 THROUGH 2010 FRONTIER, XTERRA, AND PATHFINDER VEHICLES. THE LOWER CONTROL LINK ASSEMBLY HAS TWO CYLINDRICAL COLLARS FORMING THE INBOARD ATTACHMENT POINTS TO THE CHASSIS. DUE TO AN IMPROPER WELDING PROCESS SOME COLLARS MAY CONTAIN WELDS THAT DO NOT MEET STRENGTH SPECIFICATIONS.

Campaign: 10E019000

ENGINE AND ENGINE COOLING

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

Campaign: 10V517000

AIR BAGS:FRONTAL

NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.

Campaign: 08V690000

EXTERIOR LIGHTING

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E064000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.

Campaign: 06V092000

EQUIPMENT

CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, AND 1290376035. A WIRE MAY HAVE BEEN PLACED IN AN INCORRECT POSITION IN THE ELECTRICAL CONNECTOR HOUSING. THIS RESULTS IN AN INCORRECT ROUTING OF WIRES BETWEEN THE TRAILER BRAKE CONTROLLER AND THE TOWING VEHICLE WIRING SYSTEM.

Campaign: 07E046000

AIR BAGS

EL EMBLEMA DE RESINA EN LA CUBIERTA DEL MÓDULO AIRBAG DEL CONDUCTOR EN LOS VEHÍCULOS AFECTADOS PUEDE TENER DURABILIDAD REDUCIDA DEBIDO A POSIBLES VARIACIONES EN EL PROCESO DE PRODUCCIÓN DEL PROVEEDOR. EN ESTA CONDICIÓN, CON EL TIEMPO, LOS POSTES DEL EMBLEMA PUEDEN DESARROLLAR GRIETAS, Y EL EMBLEMA Y LOS COMPONENTES DE RETENCIÓN PODRÍAN DESPRENDERSE EN CASO DE QUE SE DESPLIEGUE EL AIRBAG.

AIR BAGS

The contact owns a 2005 Nissan Frontier. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

ELECTRICAL SYSTEM,ENGINE

The timing chain has gone out. Other crankshaft sensor went out while driving the vehicle at about 30mph.

POWER TRAIN

The truck loss power stalling,shuddering, bucking, want pick up speed even when excellerating, slow take off, loss of speed

ENGINE

The contact owns a 2005 Nissan Frontier. The contact stated that on several occasions while driving approximately 65 MPH, the vehicle inadvertently decelerated. The contact then stated that the check engine warning light illuminated, and the vehicle stalled. The contact was able to coast the vehicle off the roadway. The contact then stated that the check engine warning light intermittently flashed upon start-up then remained illuminated. The contact stated that he allowed the engine time to cool down then restarted the vehicle; however, after the vehicle was restarted, he depressed the accelerator pedal to regain speed but two to three minutes later the vehicle stalled again. The contact stated that occasionally, after the vehicle stalled, the vehicle was jumpstarted, but the negative side of the battery sparked from the cable. Additionally, the contact stated that the ABS warning light and the check engine warning illuminated then turned off then the vehicle stalled. The contact stated that he noticed that when the coolant temperature gauge was at an undisclosed temperature, the vehicle failed to restart. In addition, the contact added that upon research he related the failure to the NHTSA Campaign Number: 10V517000 (Engine and Engine Cooling). The vehicle was not diagnosed or repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 189,000.

POWER TRAIN

The contact owns a 2005 Nissan Frontier. The contact stated that while driving at 50 MPH, the vehicle came to a complete stop and then hesitated to accelerate. Additionally, a burning odor was detected. The vehicle was taken to the dealer and diagnosed with transmission and radiator failure. The transmission and radiator needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,700.

POWER TRAIN

The contact owns a 2005 Nissan Frontier. The contact stated while driving 75 mph, the vehicle stalled without warning. There was no warning light before or after the failure. The vehicle was towed by an independent mechanic. The mechanic performed a diagnostic test and found that coolant had leaked into the transmission and caused the transmission to fail. The vehicle was not repaired. The manufacturer was contacted and informed of the failure. The approximate failure mileage was 82,000.

AIR BAGS

AIRBAG LIGHT BLINKS CONSTANTLY. POSSIBLE FRONT AIR BAG SENSOR DEFECTIVE

UNKNOWN OR OTHER

YEAR 2013 RECALLED RADIATOR LEAKAGE INTERNAL AND CAUSED ( TRANMISSION FLUID GOT INTO RADIATOR ) . I REPORT TO NISSAN USA : THEY DENIED TO PAY FOR ITS BECAUSE HAVE BEEN TO LONG BUT NOW ITS HAPPENING TO MY TRUCK ON DATE : 10/19/2020 . PLEASE , HELP . THANKS !

POWER TRAIN

MY 2005 NISSAN FRONTIERS TRANSMISSION FAILED AT 137,000 MILES. I WAS DRIVING ON THE FREEWAY WHEN IT SEEMED TO JOLT OUT OF 5TH GEAR TO 4TH. CHECK ENGINE LIGHT CAME ON. I HEADED TO NISSAN BUT IT SEEMED TO ONLY REMAIN IN A HIGH GEAR (3RD OR 4TH). THEY DIAGNOSED IT AS A FAILED TRANSMISSION DUE TO COOLANT LEAKING INTO THE TRANSMISSION. ITS A KNOWN PROBLEM. I CALLED NISSAN HEADQUARTERS AND ASKED FOR HELP THEY SAID NO. I HAD AN EXTENDED POWERTRAIN WARRANTY THROUGH AUL, BUT BECAUSE IT WAS THE RADIATOR THAT LEAKED AND NOT A TRANSMISSION FAILURE THEY WON'T COVER IT.