1993 Nissan Quest

1993 Nissan Quest

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.

Campaign: 00V419001

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

LEAVES AND OTHER FOREIGN MATERIAL CAN ENTER THROUGH THE COWL PANEL AIR INTAKE DURING OPERATION OF THE FRONT HEATER AND/OR AIR CONDITIONING SYSTEM RESULTING IN A BUILD-UP OF MATERIAL IN THE PLENUM. THIS CAN LEAD TO NOISE, ODORS, OR IN SOME CASES, IGNITION OF THESE MATERIALS.

Campaign: 95V222002

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

THE SERVICE BRAKE MASTER CYLINDER WAS NOT PROPERLY ASSEMBLED OR COULD HAVE BEEN DAMAGED BY THE EVACUATION AND FILLING OF THE BRAKE SYSTEM AT THE ASSEMBLY PLANT.

Campaign: 92V132001

SEAT BELTS

ONE OR BOTH OF THE BOLTS SECURING THE AUTOMATIC SEAT BELT RESTRAINT SYSTEM TRACKS TO THE B-PILLARS WERE NOT ADEQUATELY TIGHTENED.

Campaign: 92V133001

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

FUEL FILLER HOSES MAY HAVE BEEN CUT PRIOR TO INSTALLATION BY A UTILITY KNIFE USED TO OPEN THE SHIPPING BOX.

Campaign: 92V172002

SERVICE BRAKES, HYDRAULIC,STRUCTURE

STEEL BRAKE LINES TO REAR BREAKS RUSTED THROUGH IN SEVERAL PLACES - TWO LINES TO REAR THAT PASS UNDER THE FLOOR AND ALONG THE DRIVER SIDE RAIL AND OVER THE REAR LEFT WHEEL AXLE, AND ALSO AT THE AREA IMMEDIATELY BEFORE EACH REAR WHEEL CYLINDER. *TR

SEAT BELTS

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. THE CONTACT STATED THAT THE PASSENGER FRONT LAP BELT WILL NOT REMAIN SECURE INTO THE BUCKLE. AS A CONSEQUENCE, IN THE EVENT OF THE CRASH THE OCCUPANTS MAY NOT BE PROPERLY RESTRAINED, WHICH CAN CAUSE SERIOUS INJURY. HE TOOK THE VEHICLE TO THE DEALER AND A TECHNICIAN STATED THAT NO PARTS ARE AVAILABLE TO PROPERLY REMEDY THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 170,000. UPDATED 10/06/09. *LJ THE CONSUMER STATED THE VEHICLE HAS FINALLY BEEN REPAIRED. THE DEALER ORDERED AND REPLACED THE BELT BUCKLE FREE OF CHARGE UNDER WARRANTY. UPDATED 10/06/09

SUSPENSION,FUEL SYSTEM, GASOLINE,SEAT BELTS,STRUCTURE

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

FUEL SYSTEM, GASOLINE

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. AFTER PARKING THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE VENT ON THE OUTSIDE OF THE VEHICLE. AFTER A COUPLE OF MINUTES, THE SMOKE CLEARED. SHE TURNED THE KEY IN THE IGNITION AND FLAMES APPEARED UNDER THE GLOVE COMPARTMENT. THE FIRE AND POLICE DEPARTMENTS ARRIVED AT THE SCENE AND A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE DEALER STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V419001 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY); HOWEVER, THE CONTACT NEVER RECEIVED A RECALL NOTICE. THE CURRENT AND FAILURE MILEAGES WERE 200,000.

SERVICE BRAKES, HYDRAULIC

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. THE CONTACT STATED THAT HER VEHICLE WAS SQUEAKING AND THAT SHE HAD TO HOSE OFF HER FRONT ROTORS WHEN THEY OVERHEATED. HER VEHICLE WAS ALSO EXPERIENCING LONG STOPPING DISTANCES. THE FAILURES HAVE OCCURRED ON NUMEROUS OCCASIONS. RECENTLY, THE SERVICE BRAKE LIGHT ILLUMINATED FOR A COUPLE OF DAYS AND THEN DIMMED. SAFETY RECALL # 92V32001 (SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS: MASTER CYLINDER) WAS FOUND. THE FREE PORTION OF THE SAFETY RECALL NO LONGER APPLIES TO THIS VEHICLE. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 200,000.

ENGINE AND ENGINE COOLING

EXHAUST MANIFOLD BOLTS BROKEN NISSAN REPLACED BOLTS 1800.00 20,000 MILES LATER SAME PROBLEM NISSAN SAYS NOT RESPONSIBLE BECAUSE IT HAD BEEN LONGER THAN 20,000 MILES AS FAR AS I CAN TELL NISSAN DID NOT USE THE NEW IMPROVED MANIFOLD BOLTS FOR THIS REPAIR.*AK

ENGINE AND ENGINE COOLING,VISIBILITY,UNKNOWN OR OTHER

AS HAS HAPPENED TO CLOSE TO 100% OF QUEST/MERCURY VILLAGER OWNERS, I HAVE CRACKED MANIFOLDS, MISSING MANIFOLD STUDS, AND SEVERAL BROKEN MANIFOLD STUDS. THIS RESULTS IN POOR STARTS, EXHAUST LEAKS, AND A NOTICEABLE "CLACKING" (EXHAUST LEAK) UPON ACCELERATION. MY VEHICLE HAS 118K MILES. I UNDERSTAND THE LABOR FOR A COMPLETE FIX CAN RUN OVER $1000, WHILE PARTS RUN UNDER $100. I HAVE CONTACTED 1-800-NISSAN1 WITH THIS ISSUE AND THE OPERATOR WAS AWARE OF THIS VERY COMMON, SERIOUS PROBLEM AND AFFIRMED THAT I WOULD BE CONTACTED WITH ANY POSSIBLE COMPENSATION.

SEAT BELTS

FRONT DRIVERS AUTOMATIC SEAT BELT IS STUCK IN ONE STATIONARY POSITION. CONSUMER CAN HEAR MOTOR RUNNING BUT NO MOVEMENT OF SEATBELT. *AK

ENGINE AND ENGINE COOLING

INTERMITTENTLY THERE IS A GAS SMELL IN THE PASSENGER CABIN. THE SMELL COMMONLY OCCURS WHEN THE FUEL TANK IS CLOSE TO EMPTY. *AK

ENGINE AND ENGINE COOLING

CONSUMER STATES THE EXHAUST MANIFOLD STUDS HAVE BROKEN FOUR TIMES IN AS MANY YEARS, CAUSING EXHAUST LEAKS.