2003 Subaru Baja

2003 Subaru Baja 4-DR. 4x2

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V002000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V001000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V003000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Subaru Baja vehicles manufactured January 22, 2003, to July 21, 2004, 2004-2005 Impreza vehicles manufactured January 28, 2003, to May 31, 2005, 2003-2008 Subaru Legacy vehicles manufactured January 22, 2003, to May 2, 2008, 2003-2008 Subaru Outback vehicles manufactured February 18, 2003, to May 5, 2008, and 2005 Saab 9-2x vehicles manufactured February 11, 2004, to March 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.

Campaign: 15V323000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy, Outback, 2006-2008 Impreza, Tribeca, 2006 Saab 9-2x, and 2003-2006 Baja vehicles originally sold or that have ever been registered in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 16V359000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy, Outback, and Baja vehicles originally sold or that have ever been registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming, or "Zone C.". These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 16V361000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy, Outback, 2009-2011 Legacy, Outback, Forester, 2006-2011 Impreza, Tribeca, 2003-2006 Baja, and 2006 Saab 9-2x vehicles originally sold or that have ever been registered in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Campaign: 16V358000

AIR BAGS

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy and Outback vehicles, and 2003-2005 Baja vehicles sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan, American Samoa, Florida and adjacent counties in southern Georgia, as well as the coastal areas of Alabama, Louisiana, Mississippi and Texas. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Campaign: 14V763000

POWER TRAIN:AUTOMATIC TRANSMISSION

CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.

Campaign: 02V282000

ENGINE AND ENGINE COOLING:COOLING SYSTEM

ON CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 4-CYLINDER ENGINES, THE WATER PUMP PULLEY CENTER HOLE WAS IMPROPERLY MACHINED.

Campaign: 02V240000

ELECTRICAL SYSTEM

My cars abs light came on and the speedometer, rpm gauge, and electrical system started failing while driving. I immediately pulled over. The car caught fire around the alternator. The fire was minor, as I found the damage after towing the car home. If it had been worse, I could’ve been injured and burned. When I went to fix the car, we found that the wires were taped together with electrical tape and the other end had a form of glue on it. After we bought the car, the dealership kept calling checking on the vehicle, making me believe it was a known issue by them. This issue will cost me to fix the wiring, but I am unsure how much yet.

SUSPENSION

Vehicle purchased in NC in April, 2025. Registered the vehicle in VA (where I live) a week later once I received the NC title. On [XXX], I took the vehicle to get it inspected. It failed the Virginia State Safety Inspection for the suspension - rust on the rear subframe near right rear wheel well. I found the following information online with regards to this issue: These recalls were issued for the 2003-2006 Subaru Baja , specifically those in the "salt-belt" states for "poor paint quality on the subframe components which led to rusting and potential for subframe failure." The recall numbers that I was able to locate online are O3V-153 and WWM-96. I have already reached out to the Customer Advocacy Department of Subaru of America and they are unable to help me because this particular VIN was not tied to this recall. I am unable to get this vehicle inspected because it does not pass due to this issue. This was a KNOWN issue for this year make and model vehicle in the states in which this vehicle has been titled over the last 20+ years. Because of the issue that was found during my state inspection combined with the fact that this vehicle has been titled in "salt-belt" states, I feel that it should been included in with this recall and as such, repaired by Subaru of America. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING,SUSPENSION,SERVICE BRAKES

At the beginning of April, I purchased a 2003 Subaru Baja from Roseville Auto Center for $10,500 and was reassured by the salesman that it passed a safety inspection and that there were no leaks in the head gasket. I did my own inspection under the hood and underneath the vehicle. I found there to be undercoat sealant which made sense as the vehicle was from Pennsylvania. I asked about the rust condition of the car to which I was once again reassured that it was okay. I took the car home and the following week I took it to my mechanic to see where I should start on modifications and upgrades. However, upon doing a multipoint inspection with the car on a lift he discovered that the undercoat sealant had been sprayed over duct tape to conceal rust holes in the running boards. Further, the undercoat had been sprayed after the frame had gotten significantly damaged by rust, not as a preventative measure as it’s intended to be used. The frame has severe rust damage as does the steering, suspension, and worst of all, the brakes. The backing plates for the brakes are almost entirely disintegrated. Additionally, my mechanic discovered that there was oil and coolant which had leaked from the engine, indicating that there was in fact a head gasket leak. So, this vehicle is in an unusably unsafe condition with a head gasket leak which makes it unreliable. The vehicle was purchased under false pretenses due to intentional misrepresentation by the salesman regarding the reliability and safety of the vehicle. Furthermore, I’ve spoken to multiple mechanics and a dealership and none of them want to attach their name to this vehicle because of the liability attached to it due to these safety issues. Beyond this I have done extensive research to find out how much it would cost to repair these issues and replace these parts myself and it would cost me more than the cost of the vehicle let alone the actual value of the car. Finally, I am going to be unable to sell the vehicle for anyt

STRUCTURE

The contact owns a 2003 Subaru Baja. The contact stated that upon inspection the vehicle, the contact discovered severe corrosion to the rear subframe. The contact called the manufacturer and was referred to a specialist. The contact was yet to receive a call back from the specialist. The dealer was notified of the failure and the contact was informed that other model vehicles had experienced a similar failure. Upon investigation, the contact discovered that there was no recall for the subframe corrosion. The vehicle was not repaired. The failure mileage was approximately 180,000.

ENGINE

Subaru water pump pulley center hole was improperly machined

POWER TRAIN

The contact owns a 2003 Subaru Baja. The contact stated that while attempting to park the vehicle, the vehicle would move forward inadvertently until the contact applied the parking brake. The dealer was made aware of the failure but informed the contact that the VIN was not associated with any recalls. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 02V282000 (Power Train). The failure mileage was approximately 165,000.

ENGINE

THE CAR HAS BEEN USING OIL A LOT AND IT'S NOT LEAKING OUT AND IT SMELLS LIKE BURNT OIL AND SMOKES

AIR BAGS

TAKATA RECALL -- FAILURE TO COMPLY

AIR BAGS

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SUBARU BAJA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V361000 (AIR BAGS). THE CONTACT CALLED MID HUDSON SUBARU AT 845-296-1152 (LOCATED AT 1715 U.S. 9, WAPPINGERS FALLS, NY 12590) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT CALLED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2003 SUBARU BAJA. WHEN THE VEHICLE WAS STATIONARY OR WHEN DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED A STRONG ODOR OF FUEL COMING THROUGH THE VENTS. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE ODOR WAS ONLY NOTICED DURING COLD WEATHER. THE CONTACT CALLED MIKE SHAW SUBARU AT (303) 438-7500 (LOCATED AT 1650 W 104TH AVE, DENVER, CO 80234) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.