1996 Subaru Legacy

1996 Subaru Legacy 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES HAVE AN ALTERNATOR PROBLEM THAT CAN RESULT IN A LOSS OF CHARGING CAPABILITY.

Campaign: 00I002000

SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.

Campaign: 01V216000

SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET

VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.

Campaign: 98V091000

AIR BAGS

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INADVERTENT AIR BAG DEPLOYMENT CAN OCCUR AFTER UNDERCARRIAGE CONTACT OF THE TOW HOOKS WITH CURBS, DIPS, SPEEDBUMPS, POTHOLES, ETC.

Campaign: 98V315000

POWER TRAIN

TL* THE CONTACT OWNS A 1996 SUBARU LEGACY. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THERE WAS A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT THEN NOTICED THAT THERE WAS SMOKE AND FLAMES COMING FROM THE REAR END OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND A FIRE REPORT WAS FILED. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THEY INSPECTED AND ADVISED THAT THE DIFFERENTIAL FAILED DUE TO THE VEHICLE BECOMING OVERHEATED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 255,000.

AIR BAGS

TL* THE CONTACT OWNS A 1996 SUBARU LEGACY. THE CONTACT WAS DRIVING 5 MPH WHEN ANOTHER VEHICLE CRASHED INTO HIS BUMPER AND THE AIR BAGS DEPLOYED. THERE WERE NO PHYSICAL DAMAGES TO THE VEHICLE AND THERE WERE NO INJURIES REPORTED. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO A LOCAL AUTO MECHANIC TO HAVE THE AIR BAGS AND THE WINDSHIELD REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE FAILURE MILEAGE WAS 108,000.

POWER TRAIN

MY DAUGHTER WAS DRIVING HER 96 SUBARU LEGACY THE OTHER DAY TO THE STORE WHEN SHE WAS ALERTED BY ANOTHER DRIVER THAT HER CAR WAS ON FIRE. LUCKILY THEY HAD A FIRE EXTINGUISHER AND WAS ABLE TO PUT IT OUT. BEECHMONT SUBARU SAID THIS WAS THE FIRST TIME THEY EVER SAW A REAR DIFFERENTIAL CATCH ON FIRE. I WANTED TO MAKE SUBARU AWARE AND MAYBE GET SOME HELP ON THIS REPAIR. MAKING SURE IT DONE CORRECTLY. IT WAS A VERY FRIGHTENING PHONE CALL FROM MY DAUGHTER. THIS WEB SITE WILL NOT ALLOW ME TO ENTER THE VIN. [XXX]. I WILL EDIT THE VIN TILL THE SITE ACCEPTS MY COMPLAINT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ELECTRICAL SYSTEM

1996 SUBURU LEGACY SHUTS DOWN ALL ELECTRICAL SYSTEM. PURCHASED IN UTAH DROVE TO DENVER AREA. WENT TO DMV TO REGISTER THEN CAR QUIT. RESTS A WHILE THEN STARTS. *TR

FUEL SYSTEM, OTHER

TL*THE CONTACT OWNS A 1996 SUBARU LEGACY. THE VEHICLE FAILED TO START AND WAS TOWED TO THE DEALER. THE DEALER ATTRIBUTED THE CAUSE OF FAILURE TO THE WIRES INSIDE THE FUEL TANK BEING BURNT BECAUSE THE INTERNAL CONNECTOR HAD LOOSE TERMINALS. THE FUEL PUMP MODULE WAS REPLACED. THE CURRENT MILEAGE IS 85,000 AND FAILURE MILEAGE WAS 84,600.

FUEL SYSTEM, GASOLINE

TL*THE CONTACT OWNS A 1996 SUBARU LEGACY. WHILE FILLING THE GAS TANK THE CONTACT NOTICED A PUDDLE OF GAS FORMING UNDER THE VEHICLE. THE FILLER PIPE RUSTED THROUGH AND CAUSED THIN HOLES. THE CURRENT AND FAILURE MILEAGES WERE 110,000.*AK

FUEL SYSTEM, GASOLINE

DT*: THE CONTACT STATED AN ODOR OF FUEL WAS DETECTED AND A PUDDLE BEGAN TO FORM ON THE GROUND WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE FUEL FILLER TUBE WAS REPLACED. UPDATED 9/5/2006 - *NM

AIR BAGS

MY 1996 SUBARU OUTBACK EXPERIENCED AN AIR BAG MALFUNCTION ON 6/14/2005. WHILE DRIVING DOWN OUR LOCAL HIGHWAY AT 55 MPH THE VEHICLE'S AIR BAG SUDDENLY DEPLOYED. THE SUDDEN DEPLOYMENT CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER BUT DUE TO THE MILEAGE ON THE VEHICLE THEY REFUSED TO CONTACT THE MANUFACTURER ABOUT REPAIRS. THE INSURANCE INSPECTOR BELIEVES THAT THE FAILURE WAS DUE TO A MALFUNCTION IN THE SYSTEM BECAUSE THERE WAS NO DAMAGE TO THE FRONT END OF THE VEHICLE TO INDICATE A 55 MPH CRASH. *NM *NM

VEHICLE SPEED CONTROL

DT: CONTACT STATED THAT WHILE PULLING INTO THE GARAGE VEHICLE ACCELERATED WITHOUT WARNING AND HIT THE REAR OF THE GARAGE AND DID DAMAGE TO THE BUILDING. THE VEHICLE WAS TOTALED. DEALER SAID THEY NEVER HEARD OF THIS PROBLEM. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK UPDATED 11/16/2005 - *NM

FUEL SYSTEM, OTHER

DT: THE CALLER SAYS HIS GAS GAUGE WILL SHOW EMPTY WHEN IT GETS DOWN TO HALF A TANK. HE STATES THAT IT DOES NOT HAPPEN ALL THE TIME. IT HAS BEEN HAPPENING FOR A MONTH. DEALER AND MANUFACTURER HAVE NOT BEEN CONTACTED YET.*AK THE CONSUMER DID CONTACT THE MANUFACTURER AND WAS TOLD TO TAKE THE VEHICLE TO THE DEALER, BUT THERE WOULD BE A CHARGE TO INSPECT THE VEHICLE. *JB