2000 Subaru Legacy

2000 Subaru Legacy 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2000 Subaru Legacy 4-DR. Wagon

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermarket applications on or after July 26, 2013, and may may leak fuel from the base of a fuel line connection when the gas tank is full.

Campaign: 13E065000

SUSPENSION:REAR

THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.

Campaign: 03V153000

POWER TRAIN:DRIVELINE:CENTER SUPPORT BEARING

VEHICLE DESCRIPTION: SEDAN L MODEL PASSENGER VEHICLES. ANTI-RUST COATING WAS INCORRECTLY APPLIED TO THE TRANSVERSE LINK MOUNTING SURFACE OF THE VEHICLE BODY. OVER TIME THE COATING SHRINKS, CAUSING A TORQUE DECREASE OF THE BOLT THAT SECURES THE TRANSVERSE LINK BRACKET TO THE VEHICLE BODY.

Campaign: 99V249000

STEERING:LINKAGES:TIE ROD ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT-SIDE STEERING KNUCKLE ARM WAS INCORRECTLY ASSEMBLED.

Campaign: 00V091000

SUSPENSION,STRUCTURE

TL* THE CONTACT OWNS A 2000 SUBARU LEGACY. WHILE THE VEHICLE WAS UNDERGOING A STATE INSPECTION, THE CONTACT WAS INFORMED THAT THE REAR SUSPENSION SHOWED SEVERE RUST. THE CONTACT STATED THAT THE VEHICLE HAD BEEN REPAIRED TWICE PER NHTSA CAMPAIGN NUMBER: 03V153000 (SUSPENSION) BY PATRIOT SUBARU OF SACO (LOCATED AT 769 PORTLAND RD, SACO, ME 04072, (207) 284-7900). THE CONTACT WAS INFORMED THAT THERE WERE TWO SUB SECTIONS UNDERNEATH THE VEHICLE THAT NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 182,159. *BF CONSUMER STATES THAT THE RECALLS THAT WERE PERFORMED WERE NOT DONE PROPERLY WHICH CAUSED THE FAILURE. THERE WAS NOT ENOUGH UNDERCOATING ON THE BOTTOM OF THE VEHICLE. *DL

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 SUBARU LEGACY. WHILE DRIVING VARIOUS SPEEDS IN BELOW FREEZING TEMPERATURE, THE CONTACT DETECTED AN ODOR OF FUEL COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 156,000.

FUEL/PROPULSION SYSTEM

STRONG FUEL SMELL WHEN STARTING IN COLD WEATHER.

AIR BAGS

TL* THE CONTACT OWNS A 2000 SUBARU LEGACY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V323000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TIRES

TL* THE CONTACT OWNS A CONTINENTAL EXTREME CONTACT TIRE, SIZE: 205/55R16. THE CONTACT STATED THAT THE DRIVER OF THE VEHICLE WAS TRAVELING APPROXIMATELY 50 MPH WHEN THE FRONT PASSENGER'S SIDE TIRE SUSTAINED A BLOW OUT. THE CONTACT ALSO DISCOVERED A BLISTER ON THE SIDEWALL OF THE REAR PASSENGER'S SIDE TIRE. THE MANUFACTURER WAS NOT CONTACTED IN REFERENCE TO THE DEFECT. THE FAILURE MILEAGE OF THE TIRE WAS 155. THE VEHICLE FAILURE MILEAGE WAS 135,904.

AIR BAGS

CAR SLID ON BLACK ICE OFF THE ROAD, DOWN A VERY STEEP EMBANKMENT, INTO THE SIDE OF A BUILDING, AND TOTALED THE FRONT END OF THE CAR. THE AIR BAGS DID NOT DEPLOY. *TR

ELECTRICAL SYSTEM,VISIBILITY,STRUCTURE

DRIVING TO WORK CAR RUNNING FOR APPROXIMATELY 20 MIN. THE WINDOW CONTROL SWITCH INSIDE THE DRIVER SIDE DOOR SMOKED AND QUICKLY CAUGHT FIRE. I IMMEDIATELY SLOWED DOWN AND PULLED OVER TO THE RIGHT SHOULDER AND TURNED OFF THE CARD. I OPENED THE DOOR AND STEPPED OUT. WITHIN A FEW SECONDS THE PANEL ON THE CAR DOOR ALSO CAUGHT FIRE AND STARTING MELTING. I HAD BEACH TOWEL IN THE BACK OF THE CAR, AND TRIED TO SMOTHER THE FIRE WITH THE TOWEL, BUT QUICKLY DECIDED THE FIRE WAS TOO LARGE, GROWING TOO QUICKLY AND WAS ACTUALLY INSIDE THE DOOR. I GAVE UP ON THE TOWEL, AND IN LAST DITCH EFFORT TO THE SAVE THE CAR I GRABBED, AND TORE OFF THE PLASTIC DOOR PANEL AND THREW IT TO GROUND. SOME OF THE MELTED PLASTIC FROM THE DOOR PANEL DID GET ON MY HANDS, AND I RECEIVED SEVERAL BURNS TO MY FINGERS THAT REQUIRED MEDICAL ATTENTION. I WAS THEN ABLE TO EXTINGUISH THE REMAINING FIRE. THE CAR IS CURRENTLY AT A BODY SHOP FOR REPAIR. THE DAMAGE TO THE CAR APPEARS TO BE LIMITED TO THE DRIVER'S SIDE DOOR. *TR

ENGINE

I HAVE BEEN EXPERIENCING A VERY POWERFUL FUEL SMELL EMITTING FROM THE AREAS OF THE ENGINE. WHEN I POP THE HOOD THE SMELL IS THE STRONGEST. THE SMELL IS OF RAW GASOLINE (NOT EXHAUST OR ANYTHING OF THAT SORT) AND PERMEATES INTO THE CABIN AND ALL AROUND THE VEHICLE. THE ODOR EMERGES ONLY ON COLD DAYS, SPECIFICALLY TEMPERATURES THAT DROP BELOW 39 F. THE ODOR GROWS MORE POTENT AS THE CAR RUNS AND IF I ACTIVATE THE HEAT BLOWERS YOU AND SMELL IT EVEN MORE. THE ODOR EVEN LAST LONG AFTER THE CAR IS SHUT OFF, EXISTING AROUND THE ENGINE FOR HOURS AFTER SHUT DOWN. *TR

SUSPENSION

TL* THE CONTACT OWNS A 2000 SUBARU LEGACY. THE CONTACT STATED THAT THE REAR SUSPENSION WAS COMPLETELY RUSTED. THE DEALER STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER: 03V153000 (SUSPENSION), BUT THE MANUFACTURER STATED THAT THEY WOULD NOT REPAIR THE VEHICLE UNDER THE RECALL BECAUSE OF THE MILEAGE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 181,000. *TR

SUSPENSION,STRUCTURE

REAR SUBFRAME RUSTED AND BROKEN A PART - DEALER DEEMED CAR UNSAFE TO DRIVE. *TR