2005 Subaru Legacy

2005 Subaru Legacy 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V003000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V002000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V001000

ELECTRICAL SYSTEM:IGNITION:SWITCH

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.

Campaign: 19V297000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Subaru Baja vehicles manufactured January 22, 2003, to July 21, 2004, 2004-2005 Impreza vehicles manufactured January 28, 2003, to May 31, 2005, 2003-2008 Subaru Legacy vehicles manufactured January 22, 2003, to May 2, 2008, 2003-2008 Subaru Outback vehicles manufactured February 18, 2003, to May 5, 2008, and 2005 Saab 9-2x vehicles manufactured February 11, 2004, to March 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.

Campaign: 15V323000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines. Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.

Campaign: 14V311000

AIR BAGS

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy and Outback vehicles, and 2003-2005 Baja vehicles sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan, American Samoa, Florida and adjacent counties in southern Georgia, as well as the coastal areas of Alabama, Louisiana, Mississippi and Texas. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Campaign: 14V763000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Subaru is recalling certain model year 2005-2009 Outback and Legacy vehicles manufactured from December 2003, through April 2009 and currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.

Campaign: 13V110000

AIR BAGS:SIDE/WINDOW

THE LEFT AND RIGHT SIDE CURTAIN AIR BAGS IN CERTAIN VEHICLES INVOLVED IN THIS CAMPAIGN MAY NOT FULLY DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. DURING A SIDE IMPACT TEST CONDUCTED BY THE INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS), THE TEST RESULTS INDICATED THAT THERE WAS A DIFFERENCE BETWEEN THE IIHS TEST RESULTS AND THE RESULT OF SIDE IMPACT TESTS CONDUCTED BY FHI.

Campaign: 04V274000

SERVICE BRAKES, HYDRAULIC

The contact owns a 2005 Subaru Legacy. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was depressed to the floorboard. The contact downshifted to slow down, and the vehicle came to a stop. The ABS warning light was illuminated. The contact inspected the vehicle and became aware that at the rear of the vehicle there was brake fluid leaking onto the ground. The vehicle was towed to the residence. The dealer was made aware of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V311000 (Service Brakes, Hydraulic); in 2014. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 134,000.

SERVICE BRAKES

While driving to work, my brake pedal went to the floor and I lost 90% of braking power. After managing to get the car back home, and topping up brake fluid, I noticed a puddle of it right in front of the passenger rear wheel. After doing research, found that this was a problem for this car, covered under recall WQK-47. Having bought this car used a few months ago, I checked and apparently this recall had been performed, but was obviously not successful in preventing the failure of my brakes. After researching the recall, found that there were 2 remedies depending on the inspection performed by the dealer when the car was brought in for the original recall work. According to the service records, the application of a protective rustproofing wax material was performed, which was supposed to prevent the deterioration of the brake lines. The other remedy for the recall was to replace the brake lines, which was not done on my vehicle. After this issue happened, I brought my vehicle to my Subaru dealer, and contacted Subaru of America to open a case. After a week and minimal communication or information from Subaru of America, I received a call stating they would not cover my brake lines under the recall, even though they failed at the exact point specified by the safety recall, showing that the repair previously done was not effective in ensuring the safety of the vehicle.

SERVICE BRAKES

Brake lines were definitely not replaced even though known to be defective and prone to corrosion and leaks. Almost got into a accident because the known recalled area let go on the highway

SERVICE BRAKES, HYDRAULIC

The contact owns a 2005 Subaru Legacy. The contact received notification of NHTSA Campaign Number: 14V311000 (Service Brakes, Hydraulic); however, the dealer refused to perform the recall. The contact stated that the dealer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving 35 MPH, while braking for a traffic light, the brake pedal was depressed and went to the floorboard. The contact was able to stop the vehicle and had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the rear passenger side brake line had corroded and needed to be replaced. The vehicle was not repaired by the dealer since the dealer stated the vehicle was not registered in the listed states on the recall notification. The failure mileage was 229,126. Parts distribution disconnect.

SERVICE BRAKES

The vehicles brake lines have corroded and started to leak, resulting in the stopping distance increasing and the vehicle not being safe to drive. When getting the airbag recall performed at the Subaru dealership 3 years ago I mentioned the brake line recall. They stated they inspected the lines, and no issue was present. There is now an obvious issue with the brake line corroding and failing. Subaru is telling me there is no active recall.

SERVICE BRAKES

I noticed a small puddle of fluid by the right rear wheel and immediately brought the vehicle over to Premier Subaru of Fremont, CA for an inspection. Premier Subaru diagnosed the problem as the right rear hard brake line failure and leak due to excessive corrosion. Premier Subaru provided a repair estimate of $3,997.17; stating that this issue needs immediate attention. Back in 2014, there was a service campaign to address this issue; #14V311000 and my car received this service. I've contacted Subaru of America (SOA), Customer Advocacy, about this issue and they are not willing to provide any assistance to address this current issue, even though it is directly related to the 2014 campaign. I am the second owner of this car purchasing it in 2011. The car is in excellent mechanical condition having only 135,000 miles (averaging ~7,100 miles/year) and has spent the last 7 years in the San Francisco, CA area. Pictures of the undercarriage of the car are available should you need them.

SERVICE BRAKES, HYDRAULIC,STRUCTURE

The contact owns a 2005 Subaru Legacy. The contact stated that the hydraulic brake lines were leaking. The brake warning light was illuminated. The vehicle was taken to the local dealer and the contact was informed that there was rust covering the subframe of the vehicle and fuel tank. The dealer declined to complete a recall repair under NHTSA Campaign Number: 14V311000 (Service Brakes, Hydraulic). The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 115,000.

VEHICLE SPEED CONTROL

While driving, cruise control and check engine light comes on and then the car won't accelerate. Engine revs really high and when pushing accelerator pedal, car will not move. The check engine code states "throttle position sensor". This has happened more than 20 times

SERVICE BRAKES

The rear brakes on the above referenced vehicle failed due to environmental corrosion. This is aligned with recall WQK47-2 which was open for the effected vehicle. The vehicle was transported to Suburban Subaru of Vernon CT for recall resolution. The dealership service department was not willing to complete the repair for different reasons. The vehicle was returned to me, with the rear brakes inoperable, but upon review of NHTSA.gov and Subaru's recall lookup, the recall was marked as Completed. The Service Writer communication with me and the provided Service Invoice from Suburban Subaru of Vernon CT clearly state that the recall was not completed. This is in direct conflict with the reporting to Subaru and NHTSA with regards to Recall Compliance. I reached out to Subaru Customer Advocacy for resolution of this documentation compliance but there was no direct path to re-open the recall and rectify the situation.

SERVICE BRAKES

Car is a Subaru Legacy GT 2005 Brake lines were corroded and burst and almost caused major accident on highway. Subaru is not taking responsibility of the recall since the car is in Florida now. Originally it was in New Hampshire which was designated as a recall state I called their customer recall line and they refused to repair it. this was part of a 200,000 + recall. Car only has 20,000 miles. Subaru is putting everyone’s safety at risk by not taking care of their recalls.