2007 Subaru Outback

2007 Subaru Outback 4-DR Wagon w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

2007 Subaru Outback 4-DR w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V003000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V001000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 20V002000

ELECTRICAL SYSTEM:IGNITION:SWITCH

Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.

Campaign: 19V297000

ELECTRICAL SYSTEM

Subaru of America, Inc. (Subaru) is recalling certain model year 2007-2009 model year Legacy and Outback vehicles, 2008-2014 Impreza vehicles and 2009-2013 Forester vehicles, all equipped with turbo-charged engines. The relay that controls the secondary air injection pump may fail, causing the pump to continuously operate and overheat.

Campaign: 16V738000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Subaru of America, Inc. (Subaru) is recalling certain model year 2005-2009 Outback and Legacy, 2008-2011 Impreza and 2008-2014 Impreza WRX/STI, and 2009-2013 Forester vehicles, currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines. Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.

Campaign: 14V311000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Subaru Baja vehicles manufactured January 22, 2003, to July 21, 2004, 2004-2005 Impreza vehicles manufactured January 28, 2003, to May 31, 2005, 2003-2008 Subaru Legacy vehicles manufactured January 22, 2003, to May 2, 2008, 2003-2008 Subaru Outback vehicles manufactured February 18, 2003, to May 5, 2008, and 2005 Saab 9-2x vehicles manufactured February 11, 2004, to March 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.

Campaign: 15V323000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Subaru is recalling certain model year 2005-2009 Outback and Legacy vehicles manufactured from December 2003, through April 2009 and currently, or formerly, registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.

Campaign: 13V110000

AIR BAGS

The contact owns a 2007 Subaru Outback. The contact received notification of NHTSA Campaign Number: 20V003000 (Air Bags). The vehicle was taken to the local dealer for the recall repair; however, the dealer declined to repair the vehicle due to possible damage to the dashboard while replacing the air bags. The vehicle was not diagnosed or repaired. The contact had not experienced a failure. The manufacturer was made aware of the issue.

SERVICE BRAKES

Lost brakes. Corroded brake lines. Recall was completed for this very issue. Fix was ineffective.

SERVICE BRAKES

2007 Subaru Legacy Outback 2.5i automatic. Had recall campaign 14V311 completed in 2018 for brake lines. According to Subaru brake lines were rustproofed and/or replaced. 9 June 2024 I start vehicle and place it into drive in doing so applying brake pedal to allow selection of transmission range. Pedal goes to floor without feedback pressure. No brakes. I check rear of car to find large amounts of brake fluid covering rear passenger wheel well area. Brake line has failed at rear junction as described in recall. Recall was not curative and did not address safety fault. 73k miles.

POWER TRAIN

Both front driver and passenger side CV Boots have failed prematurely on several occasions well before the expected life and mileage expectancy for these parts (they have been replaced on four separate occasions). The CV boots hold grease in to provide lubrication to the axels. Safety was at risk as lack of lubrication increased chances of axel and associated component damage (braking and steering) at higher driving speeds. Subaru dealer has verified on each of the four separate occasions that the CV boots failed prematurely. The car has never seen any off road or rough condition driving conditions. The vehicle has always been meticulously maintained and all preventive maintenance requirements complete ahead of or on schedule and any recommended repairs by authorized mechanics are addressed immediately. Was urged by Subaru Dealer to contact Subaru of America (SOA) about the CV boots again failing prematurely. Previously, SOA was contacted and acknowledged parts should not have failed in the timeframes as it had. This time with even less mileage and time in service, Subaru is refusing to address the problem and replace the Subaru OEM parts at their expense.

STEERING,SUSPENSION,POWER TRAIN

Driving down the freeway, snowy conditions, going roughly 50 mph in a straight line, no curves or turns in sight, hit a very small hump in the road and suddenly I found myself sideways from what seems like a rear steer situation, i corrected as best i could and luckily i was in the only section of the road that didn't have a wall, ended up backwards in a shallow ditch. No immediate damage noted, I was able to drive away, but confidence with driving in snowy and icy conditions has been severely diminished (been driving in snow and ice for 20+ years). My previous vehicle, 1988 chevy s10 was WAY more reliable in the snow that this thing. I have since felt this car try and "kick out" while going well under the speed limit but in slightly icy conditions. The only reason I can think that this hasnt happened again is due to myself being aware of the isssue, new struts and brand new $600 dollar tires i recently purchased. This is a huge issue, and Subaru needs to own up to it, I know i'm not the only one who's experienced this.

AIR BAGS

A couple of months ago I noticed the airbag lamp stayed on after starting my car. After I had parked and later restarted the car, the airbag light went off as normal. A month or so later the airbag light again stayed on after starting the car. I also noticed that the passenger airbag indicator (on or off) didn’t seem to be working. It didn’t say “on” or “off”. It only said “Passenger”. I took it to the dealer and they diagnosed it and said I needed a new overhead lamp assembly that would cost $400 installed. They said it would take several days (it took over 2 weeks) to get the part. In the meantime, they could not tell me whether the airbag system would function properly in an accident. The part was ordered and I kept driving the car, hoping the airbag light wouldn’t stay on which was very stressful. The repair was finally made today and appears to be functioning properly. After some online research, I found out that this is a known issue with these cars. There is a soldered connection inside the overhead lamp assembly that was either improperly or insufficiently soldered or used defective solder. People have videos posted online of them taking the assembly apart and re-soldering the connection which appears to resolve the issue. I wasn’t comfortable doing that since properly functioning airbags are a critical safety component. I believe that Subaru either knows about this or should know. I would bet they have fixed this issue on newer vehicles. But lots of these vehicles still on the road.

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

All rear lights, rear hatch lock, brake lights all failed due to wiring going from the body to the hatch getting cut from the action of opening and closing the hatch door. This seems to be a pretty common thing with at least the 2005-2007 models years.

AIR BAGS,SEAT BELTS

The Airbag light on my dash was lighting intermittently. I called Kendall Subaru here in Fairbanks, AK and was told I shouldn't drive the car as such a light indicated a problem with my airbags and that even a low level bump could set them off or that they might not function at all in a major accident. I scheduled an appointment to have this problem diagnosed. They told me there was a fault in the wiring and that I'd have to have the passenger seat indicator replaced. I have done some online research and found that there are several instances of faulty soldering in the wiring for the indicator. This would seem to me to be a reason for Subaru to issue a safety recall as a pot hole hit could set this thing off or people could get killed because the airbag didn't deploy! Kendall told me that they didn't have the part in stock. It would be in in 7-10 days. That was a month ago. I have noticed that since my vehicle was in for diagnosis, that the light has only come on whe the car is started, like it's supposed to!

SUSPENSION,STRUCTURE

The contact owns a 2007 Subaru Outback. The contact stated that while driving at an undisclosed speed, the vehicle went over a bump in the roadway and went sideways. The vehicle was taken to an independent mechanic and it was diagnosed that the rear stabilizer bar had detached. The vehicle was not repaired. The manufacturer was made aware of the failure and a complaint was filed. The failure mileage was 190,000.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2007 SUBARU OUTBACK. THE CONTACT STATED THAT SHE NOTICED THAT THERE WERE FOUR WIRES NEAR THE REAR DEFROSTER THAT WERE CUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND DIAGNOSED THAT THE WIRES CONTROLLED THE WINDSHIELD WIPERS, HATCH DOOR LOCK, DEFROSTER, AND REAR STOP LIGHTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS 181,313.