1990 Toyota 4runner

1990 Toyota 4Runner 4-DR. 4x4

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

STEERING:LINKAGES:ROD:RELAY:CONNECTING

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A FATIGUE CRACK MAY DEVELOP IN THE STEERING RELAY ROD.

Campaign: 05V389000

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E049000

UNKNOWN OR OTHER,SERVICE BRAKES

CLUTCH/BRAKE PEDAL BRACKET BROKE/CRACKED AFTER PRESSING THE CLUTCH PEDAL. WAS ORIGINALLY DIAGNOSED AS A BAD CLUTCH AND ALMOST PULLED THE PLUG TO GET THE CLUTCH REPLACED. WOULD HAVE BEEN A LOAD OF WASTED MONEY ON A POOR DIAGNOSIS. PEDAL BRACKET CRACKED WITH CLUTCH PEDAL WAS PRESSED TO START THE CAR. HEARD LOUR CRACK, CAR STARTED, BUT WOULD NOT GO INTO GEAR.

ENGINE

THIS SPECIFIC TOYOTA FORERUNNER MODEL HAD A RECALL FOR GASKET FAILURE. WE HAD IT REPLACED AT APPX 74,000 MILES DONE BY TOYOTA AS A COURTESY RECALL. THIS TRUCK CURRENTLY HAS VERY LOW MILEAGE CONSIDERING THE AGE OF THE TRUCK, ABOUT 148,000 MILES. IT RECENTLY ALMOST CAUGHT FIRE OVERHEATING AFTER ANOTHER GASKET FAILURE. WE FEEL THAT EITHER THE ORIGINAL REPAIR WAS NOT PROPERLY COMPLETED OR ANOTHER FAULTY GASKET WAS INSTALLED. IT'S AMAZING THAT BOTH TIMES THE GASKET FAILED AT AROUND THE SAME MILEAGE, 75,000. THIS CAR HAS BEEN EXTREMELY WELL MAINTAINED AND GARAGED WITH A SINGLE OWNER.

POWER TRAIN,SERVICE BRAKES

TL*THE CONTACT OWNS A 1990 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE BRACKET SUB-ASSEMBLY THAT HELD THE CLUTCH AND BRAKE PEDAL WAS FRACTURED. AS A RESULT, THE CONTACT WAS UNABLE TO DEPRESS THE BRAKE PEDAL OR THE CLUTCH. THE DEALER REPAIRED THE FAILURE AT LEAST THREE TIMES IN LESS THAN ONE YEAR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 150,000. ..UPDATED 11/14/12 *BF UPDATED 11/14/12

ENGINE AND ENGINE COOLING

FAN BLADE DISINTEGRATED AT HIGHWAY SPEED. DENTED HOOD, CRACKED BATTERY, RUINED SHROUD AND ALTERNATOR BELT. *TR

STRUCTURE

DT*: THE CONTACT STATED THERE WAS A PROBLEM WITH THE REAR END OF THE VEHICLE. THE WELDS ON THE REAR SUBFRAME OF THE VEHICLE POPPED AND FRACTURED WHICH CAUSED THE READ END TO FALL OFF. THE WELD DID NOT FRACTURE, BUT INSTEAD POPPED AWAY FROM THE REAR END WHICH HELD THE REAR SWAY BAR ONTO THE AXLE. THE WELDS POPPED ON BOTH SIDES. THE TRUCK HAD NEVER HAD A HITCH OR CARRIED A HEAVY LOAD ON THE VEHICLE.

ENGINE AND ENGINE COOLING

I BROUGHT MY TOYOTA TO THE REPAIR SHOP,THE REPAIRMAN TOLD ME MY CAR HAS A DEFECTIVE HEAD GASKET AND TOLD ME TO CALL THE TOYOTA DEALER FOR REPAIR. I CALLED THE DEALER THEY TOLD ME THAT THE HEAD GASKET HAD BEEN REPAIRED. THEY WILL NOT PAY FOR IT AGAIN. I THINK THAT IS NOT FAIR FOR A CONSUMER TO PAY FOR A DEFECTIVE ENGINE. KEEPS BLOWING HEAD GASKET BUT ONLY REPAIR ONCE IS NOT ENOUGH. *JB

STEERING

1990 4 RUNNER WAS INVOLVED IN AN ACCIDENT WHICH OCCURRED DUE TO FAULTY STEERING RELAY ROD. *TS THE CONSUMER RECEIVED A RECALL FOR THE STEERING RELAY ROD SEVERAL YEARS AFTER THE COMPONENT HAD ALREADY FAILED. THE VEHICLE WAS INVOLVED IN A SINGLE CAR ACCIDENT IN WHICH THE VEHICLE ROLLED OVER. CONSEQUENTLY THE CONSUMER SUSTAINED SERIOUS INJURIES AND THE VEHICLE WAS TOTALLY DESTROYED. THE CONSUMER NOW REALIZES THAT THE ACCIDENT WAS LIKELY DUE TO THE STEERING RELAY ROD PROBLEM MENTIONED IN THE RECALL. *NM

POWER TRAIN

CLUTCH PEDAL BRACKET FAILURE NO EVENTS WERE PRESENT LEADING UP TO THE FAILURE OF MY CLUTCH PEDAL BRACKET ASSEMBLY. WHILE APPROACHING A STOPLIGHT IN TRAFFIC I DEPRESSED MY CLUTCH PEDAL IN ORDER TO GEAR DOWN FOR THE STOP. WHILE DEPRESSING THE PEDAL I HEARD A LOUD SNAP - THE SOUND OF THE CLUTCH PEDAL BRACKET BREAKING. WITH THE BRACKET BROKEN THERE WAS NO ACCEPTABLE WAY TO DISENGAGE THE CLUTCH AND GET THE VEHICLE OUT OF GEAR TO STOP FOR THE STOP LIGHT. I SLAMMED ON THE BRAKES AND BROUGHT THE VEHICLE TO A STOP (WHICH STALLED THE VEHICLE) BEFORE REAR ENDING THE CAR IN FRONT OF ME. ONCE THE LIGHT TURNED GREEN I HAD TO USE THE STARTER WITH THE VEHICLE IN GEAR TO CLEAR THE INTERSECTION. THE VEHICLE HAS BEEN TOWED TO MY RESIDENCE SO I CAN DECIDE HOW TO FIX THIS. IT SEEMS TOYOTA KNOWS OF THE PROBLEM AND OFFERS AN "UPGRADED" BRACKET AT A PREMIUM PRICE ALONG WITH A PREMIUM INSTALLATION FEE. AFTER BROWSING THE INTERNET IT SEEMS AS IF THIS PROBLEM IS VERY COMMON AMONG TOYOTA TRUCK, 4-RUNNER AND T-100 OWNERS ALIKE. THIS TYPE OF PROBLEM COULD BE LIFE THREATENING! *NM

ENGINE AND ENGINE COOLING

HEAD GASKET PROBLEM. VALVE PROBLEMS

ENGINE AND ENGINE COOLING

WHILE THE VEHICLE WAS PARKED, THE CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH THE VEHICLE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR AN INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE HEAD GASKET WAS CRACKED AND NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *JB