2002 Toyota 4runner

2002 Toyota 4Runner 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★☆☆☆

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

Campaign: 05V225000

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E049000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

TIRES

THIS IS FOR TIRE SIZE P265 75 16. To start, I've seen multiple other complaints describing the same scenario and type of incident. Driving along the highway at appropriate speeds, I hear a whoosh/deep pitch rumble, then my vehicle began to vibrate violently. I was luckily able to pull over but had to swerve to regain control of my vehicle once the rumbling and vibration got too severe since it happened so quickly. Witnessed my driver side rear tire completely shredded, no damage along tread material, only on sidewall with multiple tears/punctures. This was a center lane on the highway with no debris. I'm now noticing other similar "tear/wear" signs on my other 3 tires on the vehicle. All specifically on the sidewall along the aggressive tread that the AT3W tires were known to have for extra grip. It just seems to be separating over time.

STRUCTURE,UNKNOWN OR OTHER

Frame rot

STRUCTURE

The contact owns a 2002 Toyota 4Runner. The contact stated that while inspecting underneath the vehicle, he noticed that there was a hole in the subframe and that the subframe and sway bar were corroded. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

LATCHES/LOCKS/LINKAGES

The contact owns a 2002 Toyota 4Runner. The contact stated while pulling the door handle to unlock the doors, the auto unlock function failed to unlock the doors. The contact had to press the unlock button to unlock the vehicle. The vehicle was taken to the dealer to be diagnosed and the dealer stated that a failure was not found. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 150,000.

STRUCTURE

Frame is excessively rusted. The recall that already exists for this issue only covers certain frames from Japan made with this steel. However, the same frames were imported to America and a large percentage of 4Runners were made with the same steel and didn’t receive a recall. Mine is one of them.

UNKNOWN OR OTHER

frame rust saftey hazardous? midas mechanic pointed out to me while work being done on exhaust march 2022

SUSPENSION,STRUCTURE

The contact owns a 2002 Toyota 4Runner. The contact stated that while driving 60 MPH through a slight right curve, the vehicle independently shifted from side to side without warning nearly causing the vehicle to flip. The contact had an independent mechanic inspect the vehicle and the mechanic discovered severe corrosion throughout the entire subframe of the vehicle. The mechanic informed him that the entire subframe needed to be replaced to ensure safe driving. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 115,000.

UNKNOWN OR OTHER

Frame rusted through from the inside out. There isnt even any surface rust where the hole started. Its just a hole in the middle of clean metal. The rest of the frame rail is solid. Rear suspension arm mount is also rusted out and starting to come off. The entire structural integrity of the frame is in question, even though externally, theres only slight surface rust. The frame should not be rusting this way.

STRUCTURE

Premature rusted frame throughout, vehicle is garaged and well maintained 117,000 miles on my 2002 Toyota 4Runner. Auto body specialist estimates $3k-$4k to restore, at least.

SUSPENSION,STRUCTURE

Frame and rear passenger control arm bracket, rotted out .only there, 2 nd time this has happened, same spot but on my previous 2001 4runner