2008 Toyota Highlander Hybrid

2008 Toyota Highlander Hybrid 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Campaign: 15V689000

AIR BAGS

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.

Campaign: 11V245000

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Campaign: 12V491000

HYBRID PROPULSION SYSTEM: INVERTER

Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be heat damaged by the solder. If this occurs, various warning lamps, including the malfunction indicator lamp, slip indicator light, brake system warning light, and master warning light, will be illuminated on the instrument panel.

Campaign: 13V396000

EQUIPMENT:OTHER:LABELS

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Campaign: 09V223000

EQUIPMENT

SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.

Campaign: 09E028000

EQUIPMENT

TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.

Campaign: 09E022000

SEAT BELTS:REAR/OTHER

TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.

Campaign: 08V181000

ENGINE

The contact owned a 2008 Toyota Highlander. The contact stated that while driving at approximately 20 MPH, an abnormal, booming sound was emitted from the vehicle as heavy, black smoke entered her vehicle. Due to the smoke, the contact's vision became obstructed, and the contact immediately shifted into park and jumped out of her vehicle for safety. It was unknown if there were any warning lights. As a result, the contact injured her right hip and strained her vocal cords. The vehicle quickly became engulfed in flames as authorities were called to the scene. The fire department extinguished the flames as both a fire and a police report were filed. The vehicle was towed to an independent mechanic, where it was deemed a total loss. There was no property damage. The origin of the fire was unknown, and an investigation was opened by the insurance company. The contact sought medical attention the next day and was treated for the strain on her right hip. The manufacturer was notified of the failure, and the contact was given a case number. The contact was also informed that she would receive a response from them within 45 days. The vehicle was destroyed. The failure mileage was approximately 100,000.

SERVICE BRAKES

THERE WAS NO INCIDENT. WHEN THE BRAKE MALFUNCTION SCREEN DISPLAYED, I DROVE THE VEHICLE TO THE NEAREST TOYOTA DEALER IN PUEBLO, COLORADO. I RECEIVED THE ATTACHED SERVICE MESSAGE AND PICKING TICKET; 17june2025. IT ALSO NEEDS NEW BRAKE PADS, ROTOR ADJUSTMENT, AND 5 NEW TIRES. TOTAL~$6000. WAY TOO PRICY! I PAID FOR THE DIAGNOSTIC TEST, AND DROVE HOME CAREFULLY! THE VEHICLE HAS BEEN SITTING IN MY CARPORT SINCE, AND I AM WALKING THE CITY LIMITS FOR ALL PURPOSES. THE 12V BATTERY DIED MID-JULY, WITHOUT REPLACEMENT SINCE. I LIVE IN LA JUNTA, 70 MILES EAST OF THE DEALER. SO WE'RE LOOKING AT 99,000 TOTAL MILES AS IT SITS.

ELECTRICAL SYSTEM,SERVICE BRAKES

My 2008 Toyota Highlander Hybrid is having severe issues with the ABS system. Toyota is reporting that it needs an ABS actuator and ABS pump replacements. These were a part of Toyota's previous Customer Support Program, but the program expired before I owned the vehicle. That is EXTREMELY dangerous and the issue with the ABS system should be considered a Safety Recall that is ALWAYS available to Toyota customers to rectify and paid for by Toyota. It is a BRAKING ISSUE. It is not just brake pads, or normal wear and tear. This is a known issue and regardless of the timeline, Toyota should absolutely pay for the repair.

ELECTRICAL SYSTEM

The Intelligent power module failed on the vehicle. I read this is common for my vehicle however there is no recall matching my VIN. Vehicle was purchased out of state one year ago. We took the vehicle to a Toyota dealership who suggested I inquire about the issue because it’s possible this VIN should have been included.

ELECTRICAL SYSTEM

Odometer Fraud. The contact purchased a 2008 Toyota Highlander. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 123,399, and at the time of registration, it was discovered that the mileage was 271,890.

ELECTRICAL SYSTEM

Odometer Fraud. The contact purchased a 2008 Toyota Highlander Hybrid. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 92,000, and at the time of registration, it was discovered that the mileage was 212,000.

SERVICE BRAKES

Good Afternoon, The brake actuator and booster pump failed on my 2008 Toyota Highlander Hybrid. ABS, Brake, and VSC warning lights came on, and the brakes became weak and unsafe. A repair shop confirmed the issue with codes C1252, C1256, and C1391. I tried to fix it at a local shop last year, but the problem came back. It seems this repair can only be fully done at a Toyota dealer due to software requirements. However, the dealer repair cost is very high. I cannot afford the repair or a new car right now because of family budget limits — we have three children and rely on this vehicle every day(only one car). Toyota declined to help, even though I later found this issue was once covered under Program ZKC, which I missed. The vehicle is still unsafe and available for inspection. Thank you very much for considering my issue!

SERVICE BRAKES, HYDRAULIC

The contact owns a 2008 Toyota Highlander Hybrid. The contact stated that while driving on several occasions at various speeds, the master, brake system, ABS warning, and traction control warning lights illuminated. Additionally, the message "Brake System Malfunction - Stop in Safe Place Immediately”, check ABS/VSC system, and check braking system" messages were displayed. The vehicle was taken to an independent mechanic several times, but was not diagnosed. The manufacturer was notified of the failure. The failure mileage was approximately 227,000.

SERVICE BRAKES

Brake actuator failure. Have to manually brake, stopping distance significantly increased. 3,145$ to replace at Toyota dealership.

SERVICE BRAKES

In June 2019, Toyota issued a recall for ABS malfunction, diagnostic code C1391 - brake actuator and accumulator. New parts were issued by Toyota in 2019 as part of the recall. My vehicle experienced ABS malfunction, diagnostic code C1391 in March 2022 and was repaired by Toyota with the new and improved parts issued as part of the recall. As of October 14, 2024, my vehicle is experiencing the same issue again - ABS brake malfunction diagnostic code C1391, with the brake system light, master warning light, abs light and ABS Malfunction warning noted on the screen. The vehicle can be inspected. Toyota has inspected and confirmed it is the same issue again. The new and improved parts from 2019 should not fail within 20,000 miles. Toyota did confirm that they used the new parts issued as part of the recall and cannot explain why they failed faster than the original parts causing dangerous braking issues.