2004 Toyota Highlander

2004 Toyota Highlander 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE AND ENGINE COOLING

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Campaign: 11V539000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Campaign: 11V112000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Campaign: 06V253000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Campaign: 10V499000

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Campaign: 04V181000

STEERING,ENGINE

Hello, I am the Buyer of the subject Vehicle, Upon doing my research, I found out several reports stating that The subject vehicle's 2.4L engine has manufacturing defect, that causes Head Bolts to get stripped/melt down in to oil causing Engine failures and Life threating risk in the middle of the road.

AIR BAGS,WHEELS

My car malfunctioned my tire locked up while I was driving on the high way causing me to spin out of control and skid all the way into a guard rail totalled my car out and not one air bag went off

AIR BAGS

The passenger airbag occupancy sensor in my car has stopped sensing a passenger has been stuck on "OFF" for the past 2-6 months (I believe) even when an adult is sitting in the seat. I don't know exactly when this problem began because there was never any warning light or error message which is a massive safety oversight since I could have been in accident with no knowledge that it wasn't working properly. The car is currently at the dealership and they are telling me it's $1300 to replace the sensor and that there is no way to bypass the sensor and just have it "ON" for the safety of my passenger. There is already a recall for this same system in newer Highlanders, but why is there no support for older Highlanders?

STRUCTURE

The contact owns a 2004 Toyota Highlander. The contact stated while driving at an undisclosed speed, the front bumper inadvertently detached. The vehicle was taken to an independent mechanic where it was determined that the front lower bumper covers had been attached with mounting tabs and that the bumper assembly had failed and needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 190,000.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE AND PRESSING TO BRAKE PEDAL, THE PEDAL FAILED TO RETURN TO THE IDLE POSITION. THE VEHICLE STABILITY CONTROL MESSAGE DISPLAYED ON THE INSTRUMENT PANEL AND THE VEHICLE FAILED TO EXCEED 40 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS THEN DRIVEN TO THE LOCAL DEALER GROOVE TOYOTA LOCATED AT 5460 S BROADWAY, ENGLEWOOD, CO 80113 HOWEVER, THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE MANUFACTURER WAS NOT YET CONTACTED. THE FAILURE MILEAGE WAS 126,000.

STEERING,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

WHILE TRAVELING THROUGH A HIGHWAY CONSTRUCTION ZONE MY CAR SUDDENLY BECAME HARD TO STEER, AND MY SPEED BECAME GREATER, TRIED TO (BREAK) DECELERATE THE CAR BEGAN SLIDING OUT OF CONTROL-PLOWING INTO THE ROAD CONSTRUCTION BARRIERS PART LODGED IN FRONT PASSENGER WINDSHIELD. THE CAR WENT THROUGH THE DITCH BECAME AIRBORNE THROUGH A ROD IRON FENCE SHATTERED THE REAR SECOND-ROW RIGHT SIDE WINDOW SPUN OUT , AND CAME TO REST JUST FEET FROM THE SOME PILEINGS. THIS IS THE INFORMATION OF MY DAUGHTER WHOM IS AN OUT OF STATE COLLEGE SENIOR AND VERY SHAKEN UP FROM THIS ORDEAL, THIS HER STATEMENT TO THE BEST OF MY KNOWLEDGE. POSSIBLY THE PLACEMENT OF THE 🚧 COULD HAVE BEEN A CONTRIBUTOR, AND THE UNCONTROLLABLE ACCELERATION. VEHICLE WAS BOUGHT USED A YEAR AGO. CAN YOU HELP UP LEARN WHY?

VEHICLE SPEED CONTROL

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS LOW SPEEDS, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. UPON APPLYING MINIMAL PRESSURE TO THE ACCELERATOR PEDAL, THE ACCELERATOR PEDAL BECAME STUCK AND THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE, A DUMPSTER, AND ALMOST STRUCK A GROUP OF CHILDREN BEFORE COMING TO A STOP. IN AN ATTEMPT TO STOP THE VEHICLE, PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL AND THEN THE BRAKE PEDAL. THE VEHICLE FINALLY STOPPED AND WAS TURNED OFF. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SEVERE PAIN TO THE NECK AND BACK, WHICH REQUIRED MEDICAL ATTENTION. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE CRASH. THE VEHICLE WAS SUBJECT TO NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 170,000.

SEAT BELTS

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT ASSEMBLY MALFUNCTIONED AND THE FABRIC MATERIAL STRAP BECAME FRAYED AND SHREDDED AT THE BUCKLE LOCATION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (ATLANTIC TOYOTA IN LYNN, MASSACHUSETTS) AND MANUFACTURER WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 150,000. *JS

UNKNOWN OR OTHER

THE TRANSFER CASE IS LEAKING AFTER ONLY 68000 MILES. THE LEAKING OIL DROPS OVER THE HEATED EXHAUST PIPE WHICH CAUSES FUME IN THE CABIN THROUGH AIR CONDITION AND FAN

ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM,SERVICE BRAKES

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, WHILE DEPRESSING THE BRAKE PEDAL, THE PEDAL TRAVELED TO THE FLOOR. THE TRACTION CONTROL, CHECK ENGINE, VSC, AND BRAKE INDICATORS ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 10V499000 (SERVICE BRAKES), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT OBSERVED BRAKE FLUID LEAKING FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,489.