2005 Toyota Highlander

2005 Toyota Highlander 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Campaign: 16V396000

ENGINE AND ENGINE COOLING

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Campaign: 11V539000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Campaign: 11V112000

EQUIPMENT:OTHER:LABELS

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Campaign: 10V035000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Campaign: 06V253000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Campaign: 10V499000

ENGINE

My 2025 Acura MDX (under 10,000 miles) has failed to restart after the automatic idle stop engaged at stoplights and drive-thru lines at least 7 separate times. When I release the brake, the engine often remains off and the vehicle will not move, leaving me stopped in traffic. I have not yet required a jump start, but on several occasions the vehicle came very close to not restarting at all. This most recently occurred at a sandwich shop drive-thru. These incidents occurred in normal drive mode and in normal weather conditions. No abnormal driving conditions were present when the failures happened. Other owners online report the same problem, with some needing to carry jumper cables. I believe this is a serious safety risk because the vehicle can stall unexpectedly in intersections and traffic when the auto stop-start system activates. I am now concerned about relying on this vehicle in traffic because I cannot trust it to restart when stopped.

ELECTRICAL SYSTEM

Odometer Fraud. The contact purchased a 2005 Toyota Highlander. The contact discovered that there was a mileage discrepancy after the purchase of the vehicle. The vehicle was a private sale. At the time of the purchase, the mileage was 123,000. It was later discovered upon checking Carfax that the mileage was 254,000.

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER

All at once the windows, moon roof, blinkers, reverse lights, running lights and brake lights stopped working - also the automatic headlight function stopped working and we must turn on and off the headlights or risk draining the battery. It's interesting to note that the flashers work, but the blinkers do not. The wipers, radio, cruise control, etc. are all fine. It appears all fuses associated with these items are intact - I don't know how to check the viability of the relays, but have been told it could be a relay and or a ground wire. I've purchased a new multifunction blinker headlight replacement switch AND a master window replacement switch to see if this will resolve the issue - but the fact that it happened all at the same time concerns me that it could be electrical or wiring. All the wires under the dash are intact.

STRUCTURE

The contact owns a 2005 Toyota Highlander. The contact stated that while the vehicle was on a lift at the independent mechanic, it was discovered that the rear subframe was rusted. The contact was informed that the subframe needed to be replaced. No warning lights were illuminated. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

SEATS

Passager seat burnt up from the heated seats

PARKING BRAKE

The contact owned a 2005 Toyota Highlander. The contact stated that while driving 15 MPH, the brake pedal was depressed and the vehicle accelerated and crashed into a fence. The air bags did not deploy. At the time of the crash, the vehicle was 20 MPH. The vehicle was towed to a junkyard. No warning lights were illuminated. The contact sustained a face injury where he lost several teeth and also had back pain. Medical treatment was needed for the injury, went to the hospital and got an x-ray and some dental work done A police report was filed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,435.

Other/I am not sure

I was driving home and a deer ran infront of me. I tried to put my seat belt on before but it locked, so I tried to get home to my 3yr old safely without it.

SEAT BELTS

Driver's seat belt locked up so I was unable to wear it, I hit a deer tried to swerve to miss it, and my car was shaking uncontrollably.

CHILD SEAT

The contact owns a Mifold Original Grab-and-Go Booster Seat, Model Number: MF01/US, Manufactured Date: May 3, 2019. The contact stated that her daughter had unbuckled the seat belt but was unable to unlatch the seat belt from the buckle. The seat belt was extremely tight and would not loosen from the child restraint. Since her daughter remained stuck in the child restraint, the contact had to cut the seat belt to remove her child from the vehicle. The manufacturer was not notified of the failure. The seat belt was not replaced. The failure mileage was unknown.

SERVICE BRAKES

MY 2005 TOYOTA HIGHLANDER MASTER BRAKE CYLINDER LOOKS TO BE LEAKING NEAR THE BRAKE BOOSTER. I KNOW THAT IT WAS REPLACED BY TOYOTA DEALER UNDER NHTSA CAMPAIGN NUMBER: 10V499000. HOWEVER I DO NOT REMEMBER THE YEAR. I WAS DRIVING ON LOCAL STREETS, WHEN I STEPPED ON THE BRAKE PEDAL AND IT WENT ALL THE WAY TO THE FLOOR. THE NEXT TIME I TRIED TO STEP ON THE PEDAL IT WAS WORKING OK. BUT THEN THE 3RD TIME I STEPPED ON THE BRAKE PEDAL IT WAS GOING ALL THE WAY TO THE FLOOR AGAIN. THIS WAS A SHOCKED SINCE IT GOT ME TO WORK 9 HOURS EARLIER WITH NO ISSUE. I GOT HOME AND CHECKED THE BRAKE FLUID LEVEL AND LOOKED TO BE AT THE CORRECT LEVEL. I DID NOT DRIVE UNTIL NEXT DAY TO TAKE IT TO MY LOCAL MECHANIC, WHO TOLD ME IT WAS THE MASTER BRAKE CYLINDER. HE STATED THAT THERE WAS A SMALL LEAK INSIDE THE BRAKE BOOSTER AND NEEDED TO REPLACE THE WHOLE MASTER BRAKE CYLINDER. IT STILL IS IN THE SHOP, HOWEVER I REMEMBERED THAT IT WAS "SWAPPED OUT" WITH A NEW ONE UNDER NHTSA CAMPAIGN NUMBER: 10V499000. COULD IT BE POSSIBLE THAT THE RECALLED FOR THE NEW PART IS STILL DOING THE SAME THING? I WOULD LIKE TO KNOW IF I CAN GET REPLACED AGAIN UNDER THE RECALL, OR HAVE TO PAY THE $550 FOR NEW PART AND LABOR. THANK YOU