2016 Toyota Prius C

2016 Toyota Prius C 5 HB FWD

Overall

★★★★☆

Front Crash

★★★★☆

Side Crash

★★★★☆

Rollover

★★★★☆

HYBRID PROPULSION SYSTEM: INVERTER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Prius vehicles. A capacitor within the hybrid system may not have been properly bolted to the inverter housing.

Campaign: 17V658000

ELECTRICAL SYSTEM:WIRING

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.

Campaign: 18V579000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Toyota Motor Engineering and Manufacturing (Toyota) is recalling certain model year 2016 Toyota Prius vehicles manufactured November 30, 2015, to June 14, 2016. An air bag inflator manufacturing error may result in the inadvertent partial inflation of the front passenger air bag.

Campaign: 16V672000

AIR BAGS:SIDE/WINDOW

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Toyota Prius and Lexus RX 350, RX 350 F Sport, RX 450h F Sport and RX 450h vehicles and 2015-2016 Lexus NX 200T, NX Turbo and NX 300h vehicles. The air bag pressure sensors and/or the acceleration sensors may fail causing the side/curtain shield air bags and/or the front air bags to not deploy in the event of a crash.

Campaign: 18V085000

PARKING BRAKE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016-2017 Prius vehicles manufactured August 6, 2015, to October 3, 2016. The affected vehicles are equipped with a foot-operated parking brake system that has a parking brake cable that may disengage.

Campaign: 16V741000

SERVICE BRAKES

My name is [XXX] currently active duty military stationed in San Diego. Can you please check if my car VIN number [XXX] 2016 Toyota Prius C 103k miles still covered for brake booster malfunction code 1391. I have told they are extended warranty up to 10 yrs less 150k. Toyota dealer here seems not seeing any warranty coverage issues. Please help me look into this issues thank you. My contact number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TIRES

P 175/65r15 I was driving on a slight curve on the I-10 in El Paso, TX when the rear bumper exploded. The car started swaying and swerving then I pulled over. I then realized that the tread on the tire was gone floating across the highway. The trie was bare with no tread with the bumper around the tire was gone. The explosion also caused the tail light to break.

EXTERIOR LIGHTING

The headlights are either too bright or aimed poorly that it blinds oncoming traffic, who frequently flash their high beams at me. This occurs without any load in back and without me using the high beams. Can Toyota either adjust the bulbs or place a film on the headlights to prevent blinding oncoming traffic? Thank you!

ENGINE

Water pump failed without warning and caused irreparable damage to the engine ("blown" engine requiring replacement). Vehicle began to stall and not respond to attempted acceleration while traveling on 4 lane divided highway, 55 mph speed limit. One "Maintenance Required" message was received the previous week, but disappeared. This is the same message that appears for routine oil changes. No other warning messages were noted at the time of the incident, no unusual noises, and no smoke or other sign of overheating. Driver was able to steer vehicle to safety, but this failure could result in stranding on a busy, dangerous interstate highway. For such a critical piece of the vehicle (i.e., the water pump), there should be obvious warning message(s) and dedicated monitoring of the equipment.

ENGINE

Refer to TSB 0135-19 dealer denied repairing under the California emissions defect and performance warranty.

STEERING,POWER TRAIN,ENGINE

My car suddenly stopped in the middle of the road with message "Hybrid system stopped steering power low". Safety concern to this happen on the middle of road during rain or cold.

TIRES

See attached document for complaint

TIRES

Prinx HiCITY HH2 175/65R15 84H Bought this tire in November 2022. About 15000 miles into it, on Aug 6, 2024, the passenger front tire just busted. After swapping with the spare tire, and upon inspection, there was no nail nor it hit the curb, but the side wall is busted. This is a manufacturing quality issue.

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

During summer months when temperatures are above 100 degrees when accelerating from a complete stop I can hear the engine rev and the RPMs increase but the vehicle will move at 1-2 mph. Even if the accelerator is to the floor. After 3-4 seconds the tires will squeal and the vehicle will be jolted forward then it will slowly accelerate. This happens occasionally and I have taken it to a Toyota dealership and a chain mechanic shop, neither have been able to recreate the problem. There are no warnings and no error codes. I have been stuck in the middle of intersections trying to turn left, I have not been hit, but I fear it will happen. There is a recall out for this issue on other Priuses and I believe the issue needs to be investigated further as there is another complaint on this site for the same issue and I have found it on other sites. I bought the car in fall of 2019 and this problem has been occurring since summer of 2020.

STRUCTURE

Paint is starting to peel around trunk, clear coat has peeled off of black triangle areas by rear passenger windows on both sides of vehicle. Other 2016 Prius have had a paint recall. My vehicle needs to be included in the recall.