2002 Toyota Prius

2002 Toyota Prius 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

STEERING:ELECTRIC POWER ASSIST SYSTEM

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2003 PRIUS PASSENGER CARS MANUFACTURED FROM JANUARY 28, 2000, THROUGH MAY 30, 2003. THE STEERING LINKAGE MAY LOOSEN, RESULTING IN REDUCED ELECTRIC STEERING ASSISTANCE WHEN MAKING A LEFT TURN.

Campaign: 11V304000

ENGINE AND ENGINE COOLING

ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER MOLDING OF THE RESIN BODY OF THE CRANKSHAFT POSITION SENOR INSTALLED ON THE ENGINE BLOCK, ENGINE OIL MAY PENETRATE THE SEAL AND ENTER THE SENSOR WIRING CONNECTOR. THE WIRE HARNESS CONNECTOR MAY NOT BE SUFFICIENTLY ATTACHED TO THE LOCKING TAB OF THE SENSOR WIRING CONNECTOR.

Campaign: 06V266000

STEERING

I was driving on the 91 freeway west exit ramp to merge into the 57 freeway in Orange County ca. when suddenly I lost all power steering on the car . We managed to get out the freeway on the first exit

SERVICE BRAKES

Anti-lock brake failure. Failing to pressurize.

VEHICLE SPEED CONTROL,SERVICE BRAKES

DRIVING SPEED LESS THAN 25MPH ON FAMILIAR SURFACE STREET WITH NEED TO STOP FOR A CAR ABOUT 75 FEET (ESTIMATE) IN FRONT; SHOULD HAVE BEEN AN EASY STOP; APPLIED BRAKES BUT CAR ACCELERATED (I THINK ONLY ELECTRIC MOTOR); FURTHER BRAKE PRESSURE DID NOT STOP THE CAR, CONTINUED TO ACCELERATE (ESTIMATE 30 MPH); FENDER BENDER CRASH OF DRIVER SIDE FRONT FENDER INTO PASSENGER REAR FENDER AND SIDE BUMPER. VERY FAMILIAR WITH CAR (19 YEARS DRIVING IT) AND VERY FAMILIAR STREET NEAR MY HOME; CONFUSION WAS NOT A FACTOR; NO AIRBAGS ON EITHER CAR ACTIVATED; I WAS ABLE TO STOP WHEN I WAS BEYOND THE STRUCK VEHICLE. I PLAN ON NOT DRIVING CAR FURTHER AND HAVE ASKED TOYOTA DEALER TO TAKE IT BACK FOR JUNK WITHOUT A DEFINITE REPLY SO FAR

STEERING

DRIVING UP AND DOWN A SLIGHT INCLINE, POWER STEERING SUDDENLY GOES OUT. ONLY HAPPENED TWICE SO FAR BUT I DON'T KNOW WHAT WOULD PREVENT IT FROM HAPPENING AGAIN. PROBABLY GOING ABOUT 15-20MPH UPHILL AND MAYBE 20-25MPH DOWNHILL. HAPPENED ON A CITY STREET.

STEERING

I WAS DRIVING ON THE HIGHWAY AND FELT A JERKING AT MY STEERING WHEEL A FEW MONTHS BACK, I THOUGHT OK MAYBE THE STEERING WHEEL LOOSE OR SOMETHING, I WAS GOING AROUND 65 MPH. FAST FORWARD TO TWO WEEKS AGO AND THE STEERING WHEEL COMPLETELY LOCKS UP ON ME DRIVING TO A DR APPOINTMENT I HAD TO GO TO. I WAS GOING AROUND 30 MPH IN TRAFFIC THE STEERING LOCKED UP AND THE TRIANGLE ILLUMINATED ON MY NAVIGATION SCREEN AND THE DREADED TROUBLE SIGN APPEARED. ONCE THIS APPEARED ON MY SCREEN THE STEERING WHEEL FELT LIKE IT HAD NO POWER STEERING. AT FIRST I THOUGHT, I NEED TO CHECK THE POWER STEERING FLUID, I RESEARCHED AND REALIZED THIS PRIUS IS COMPLETELY ELECTRIC POWER STEERING. SO I ARRIVED AT MY DOCTORS AND TURNED THE CAR OFF, WHEN I CAME BACK AND TURNED IT BACK ON TO MY AMAZEMENT THE LIGHT TURNED OFF AND THE POWER STEERING WAS BACK. THEN THE WEEK AFTER SAME PROBLEM HAPPENED, BUT I DIDN'T HAVE MY OBD 2 READER WITH ME, SO AGAIN I SHUT OFF THE CAR AND THE PROBLEM WENT AWAY. I STARTED TO DO RESEARCH AND REALIZED THIS IS A SERIOUS COMMON PROBLEM WITH THE ELECTRIC POWER STEERING, THE COMPUTER CHIP THAT CONTROLS THE STEERING MALFUNCTIONS AND NEEDS TO BE REPLACED, SO I CAME HERE TO CHECK IF ANY RECALLS ON MY VEHICLE AND THERE IS NOT. THE SAME PROBLEM HAPPENED AGAIN TODAY, THIS TIME MY GIRLFRIEND WAS DRIVING AND WAS GOING AROUND 45, SHE SAID SHE ALMOST CRASHED. THIS IS A SERIOUS SAFETY HAZARD AND TOYOTA APPEARS TO BE BEHIND THE EIGHT BALL IN THIS AS I HAVE READ NUMBEROUS FORUMS OF THIS MALFUNCTION, IT'S A WIDE SPREAD PROBLEM AND EXTREMELY COSTLY TO FIX. THIS PROBLEM SHOULDN'T FALL ONTO THE OWNERS AS IT IS THE MANUFACTURER'S FAULT FOR NOT DOING THEIR DUE DILIGENCE AND ADDRESSING THIS PROBLEM AT THE FACTORY BEFORE MASS PRODUCING AND SELLING TO CONSUMERS LIKE I.

EXTERIOR LIGHTING

THE HEADLIGHT LENSES COVERS REPEATEDLY CLOUDS OVER TO THE POINT I CAN HARDLY SEE THE ROADWAY AT NIGHT. DEALER HAVE CLEANSE THE LENSES HOW HAS LAST FOR ABOUT A MONTH. THE DEALER NOW SAYS THESE NEED TO BE REPLACE AT A COST TO ME FOR $750. I BELIEVE THIS IS MANUFACTURE'S DEFECT AND IT IS A SERIOUS SAFETY ISSUE FOR A RECALL. THE DEALER SHOULD DEVELOP A FIX AND REPLACE THESE LENSES WITHOUT CHARGING THE VEHICLE OWNER.

STEERING

MY STEERING WHEEL STARTS SHAKING VIOLENTLY WHEN DRIVING UNDER 32 DEGREES OUTSIDE AND LOCKS UP THE ABILITY TO STEER WHICH CAN BE DEADLY ON THE HIGHWAY WHICH I DON'T DRIVE MUCH LUCKILY AND TOYOTA HAS NO OPEN RECALLS EVEN THOUGH I'M NOT THE ONLY ONE WITH THIS. I'VE HAS TO HURT MY HANDS WRESTLING WITH IT TO PULL OVER WHICH IS DANGEROUS ON SOME ROADS!!!! VERY DANGEROUS FAULT IN A CAR THIS IS THE 1 PART I RELY ON TO SAVE ME! CAN'T BELIEVE TOYOTA WON'T FIX IT!!! ALSO THIS HAPPENS A FEW TIMES EVERY WEEK THOUGH OUT THE ENTIRE WINTER! IT HAPPENS WHEN DRIVING ON WINDING ROAD AT 10-35 MPH AND SOMETIMES HAPPENS WHEN TURNING RIGHT OR LEFT! I NEED ADVICE!

STEERING

TL* THE CONTACT OWNS A 2002 TOYOTA PRIUS. THE CONTACT STATED THAT THE ELECTRIC POWER STEERING FAILED WITHOUT WARNING. ALSO, THE STEERING WHEEL VEERED TO THE RIGHT, WHICH CAUSED THE CONTACT TO DRIVE OVER A CURB. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V304000 (STEERING); HOWEVER, THE VEHICLE EXHIBITED THE SAME FAILURE AS LISTED IN THE RECALL CAMPAIGN. THE DEALER (LARRY H. MILLER LIBERTY TOYOTA COLORADO SPRINGS, 5115 NEW CAR DR, COLORADO SPRINGS, CO 80923, (719) 419-5832) INDICATED THAT THE VEHICLE WAS EXCLUDED FROM A WARRANTY CAMPAIGN AND THE STEERING GEAR AND COMPUTER MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS NOT AVAILABLE. *AS

STEERING

WHILE DRIVING ON THE FREEWAY IN STOP AND GO TRAFFIC THE STEERING WHEEL STARTED TO OSCILLATE BACK AND FORTH IT SUBSIDED HOWEVER A FEW MIN LATER AS FREEWAY SPEEDS WERE APPROACHED THE WHEEL TRIED TURNING HARD LEFT THEN VIBRATED CENTER TO LEFT. IF I HAD BEEN UNAWARE THIS WOULD HAVE RESULTED IN HITTING THE CENTER DIVIDER AT FREEWAY SPEEDS. A BRIEF RESEARCH ONLINE SHOWS THIS IS NOT THE FIRST KNOWN ISSUE.. THIS WAS VERY SIMILAR TO: HTTPS://WWW.YOUTUBE.COM/WATCH?V=RV-UL1PXJ1U VERY DISTURBING SITUATION TO BE IN - AT FIRST THE PS WARNING INDICATOR CAME ON THEN SAID PROBLEM SOLVED ONLY TO HAPPEN AGAIN (LESS PULL THE 2ND TIME BUT STILL NOTICEABLE.)

STEERING

WHEN MAKING A TURN AT SLOW SPEEDS THERE IS VIOLENT BACK AND FORTH UNCONTROLLABLE MOVEMENT IN THE STEERING WHEEL. YOU HAVE TO BRING THE VEHICLE TO A STOP. THE PROBLEM IS YOUR IN THE MIDDLE OF A TURN OR INTERSECTION.VERY DANGEROUS,THERE ARE NO WARNINGS WHEN THIS OCCURS.