2016 Toyota Prius

2016 Toyota Prius 5 HB FWD

Overall

★★★★★

Front Crash

★★★★☆

Side Crash

★★★★★

Rollover

★★★★☆

HYBRID PROPULSION SYSTEM: INVERTER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Prius vehicles. A capacitor within the hybrid system may not have been properly bolted to the inverter housing.

Campaign: 17V658000

ELECTRICAL SYSTEM:WIRING

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.

Campaign: 18V579000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Toyota Motor Engineering and Manufacturing (Toyota) is recalling certain model year 2016 Toyota Prius vehicles manufactured November 30, 2015, to June 14, 2016. An air bag inflator manufacturing error may result in the inadvertent partial inflation of the front passenger air bag.

Campaign: 16V672000

AIR BAGS:SIDE/WINDOW

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Toyota Prius and Lexus RX 350, RX 350 F Sport, RX 450h F Sport and RX 450h vehicles and 2015-2016 Lexus NX 200T, NX Turbo and NX 300h vehicles. The air bag pressure sensors and/or the acceleration sensors may fail causing the side/curtain shield air bags and/or the front air bags to not deploy in the event of a crash.

Campaign: 18V085000

PARKING BRAKE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016-2017 Prius vehicles manufactured August 6, 2015, to October 3, 2016. The affected vehicles are equipped with a foot-operated parking brake system that has a parking brake cable that may disengage.

Campaign: 16V741000

SERVICE BRAKES, HYDRAULIC,TRACTION CONTROL SYSTEM

The contact owns a 2016 Toyota Prius. The contact stated that while the vehicle was on and running, the ABS and traction control warning lights illuminated, and the messages "Braking Power Low - Stop in a Safe Place”, “See Owner's Manual", "Braking Power Low - Visit the Dealer", and "ABS Malfunction - See Dealer" were displayed. The contact stated that while driving approximately 35 MPH and depressing the brake pedal, the brake pedal was firm. The vehicle was taken to a dealer, and DTC: C14B6 was retrieved, indicating that the brake booster needed to be replaced. The vehicle was not repaired; however, the code was cleared. The vehicle was then taken to an independent mechanic, where the information from the dealer was relayed that the brake booster needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,028.

SERVICE BRAKES

Second time !!!! during ownership of car that brakes fail. Same problem as before Brake Actuator/Booster Failures: Multiple reports indicate issues with the ABS actuator or brake booster pump, leading to warning lights ("Braking power low", "ABS system malfunction").

FUEL/PROPULSION SYSTEM

The car has a very strong gas smell, especially when full.

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

Found coolant leak from heat exchanger into exhaust pipe. Looks like, T-SB-0135-19.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES

Car was driving fine one day and then while driving down the interstate I had the Pre collision system malfunction error, Brake light came on, Cruise will not operate, ABS light is on. After much research it seems Prius V has a common issue with brake booster faulting.

EXTERIOR LIGHTING

The headlights are either too bright or aimed poorly that it blinds oncoming traffic, who frequently flash their high beams at me. This occurs without any load in back and without me using the high beams. Can Toyota either adjust the bulbs or place a film on the headlights to prevent blinding oncoming traffic? Thank you!

ENGINE

Water pump failed without warning and caused irreparable damage to the engine ("blown" engine requiring replacement). Vehicle began to stall and not respond to attempted acceleration while traveling on 4 lane divided highway, 55 mph speed limit. One "Maintenance Required" message was received the previous week, but disappeared. This is the same message that appears for routine oil changes. No other warning messages were noted at the time of the incident, no unusual noises, and no smoke or other sign of overheating. Driver was able to steer vehicle to safety, but this failure could result in stranding on a busy, dangerous interstate highway. For such a critical piece of the vehicle (i.e., the water pump), there should be obvious warning message(s) and dedicated monitoring of the equipment.

ENGINE

Refer to TSB 0135-19 dealer denied repairing under the California emissions defect and performance warranty.

STEERING,POWER TRAIN,ENGINE

My car suddenly stopped in the middle of the road with message "Hybrid system stopped steering power low". Safety concern to this happen on the middle of road during rain or cold.

FUEL/PROPULSION SYSTEM

Driving on the freeway the car stalled and was unable to accelerate. The issue seems identical to the 2020 recall. 2020-06-23 Recall no. 20V369000 Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven. I was told by the service center that my car is not on the recall list so they are unable to work it as a recall.