2007 Toyota Sequoia

2007 Toyota Sequoia 4-DR w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 19V741000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.

Campaign: 22E002000

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Campaign: 14V743000

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Campaign: 16V396000

AIR BAGS

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Campaign: 15V286000

AIR BAGS

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Campaign: 15V285000

EQUIPMENT:OTHER:LABELS

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Campaign: 10V036000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.

Campaign: 07V013000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Campaign: 07E023000

STRUCTURE

Tail gate handle broke (second time). dealer fixed the first time. If I have a flat tire, I can't get to the spare tire.

STEERING,SUSPENSION

Turned into a laundromat parking lot and my balljoint snapped and my truck was sitting on the ground on the driver side front. Bent my fender and door also.

UNKNOWN OR OTHER

The frame of the vehicle is rusting away despite being sprayed with rust inhibitor during the frame recall. The vehicle was considered unsafe to drive due to large holes in the frame just 3 years after being sprayed by Toyota.

LATCHES/LOCKS/LINKAGES

The rear gate door or Deck lid will not open. with either key, or any other method. Every time this occurs, I have to take to the body shop to open and pay $200 for them to open it. They have to climb to the back, dismantle the rear door panels from the inside and undo some mechanisms to open it finally. The shop stated that they have had this problem with these Sequoias many times.

UNKNOWN OR OTHER

Rear hatch/latch. I purchased my 2007 Sequoia lightly used in 2013. Luckily I purchased a 3 year extended warranty also. Within a year my rear hatch broke for the 1st time, I was unable to open the rear gate, my warranty covered the parts & Labor, within a year it broke again, this time the door would not latch closed, it freely opened & would or could not be secured. This happened while out of town (Fairbanks, AK. In Feb. -40 degrees) luckily the dealership had the parts & was able to fix it quickly. Still covered by my extended warranty. That dealership told me about the consistent problem & I was told about the cheap parts, but also a poor design as far as weather & grime able to reach the components & cause corrosion quickly. It broke one more time before my warranty expired (#3) again unable to open the rear gate. That repair didn’t even last 3 months, But the warranty was expired & I had a very reliable mechanic replace it this time (#4). Much cheaper than what Toyota wanted to charge me. He did a little weather preventative repair and I actually got nearly 2 years on that repair. He also said it was a terrible design flaw on the rear hatch, & there was significant corrosion on many other parts in the rear gate. He cleaned it up as well as possible. When it broke the 5th time, I was furious, & couldn’t see the point of the $750.00+ repair (Alaska is more $$), again was broken in the unable to open position. So I used the window & crawling over the seats method for over a year, until my window started making horrible noise when opening. I made an appointment with Toyota in Anchorage, AK to repair it this time as I had a recall taken care of at the same time. The only visible corrosion on the vehicle was around the latch, the window does not work properly, & you hear parts rattling when you open & close the gate now. I realize the open gate break is not common, But that was a horribly dangerous situation, recall is needed immediately for safety & reputation

STRUCTURE

The contact owns a 2007 Toyota Sequoia. The contact stated while the vehicle was parked, the contact noticed that the rear subframe was fractured. The vehicle was taken to an independent mechanic where it was determined that the rear subframe needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 138,000.

SUSPENSION

2007 Toyota Sequoia frame completely deteriorated and rusted through. I discovered this when brining my vehicle in for the Toyota Airbag Recall when the technician brought this safety issue to my attention. Previous driving had been extremely unstable and buckled when I was on the highway. Since discovering the frame issue, I stopped driving the vehicle. I believe this is a safety issue caused by a defective frame that Toyota is aware of and had issue a past recall for. The Toyota dealer has made a video of the deteriorated frame and has commented that the vehicle is a safety issue.

ELECTRICAL SYSTEM

Doors not locking with key fob. Have to manually lock all doors by hand. Sometimes the key fob arms the security and sometimes it doesn’t. I’ve replaced the key fob and tried to program new fob but cannot program, hooked up a scanner to run for codes and 1 showed a (B1242 - wireless door lock tuner circuit)

STRUCTURE

Purchased this vehicle with a clear title and then noticed it has frame rot.

UNKNOWN OR OTHER,SERVICE BRAKES

Plan road trip Had Vehicle thoroughly. Inspected only to find that the frame was cracked on goth side and all brake lines are corroded. Called several places to get help with this matter, only to have no help at all. Spoke to many people final communication was with [XXX] in Tennessee who admitted the prior owner was notified as to the issue I have owned this vehicle for 6 yrs and could not understand why the Prior owner was notified and not I. I find that due to not notifying the correct owner they should allow me to have this issue taken care of, but they are not cooperating with me I would like to take this matter further and have them accountable for this safety issue and neglect as to contacting the existing owner. reaching out for help Sincerely [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)