2006 Toyota Sienna

2006 Toyota Sienna w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

POWER TRAIN:AUTOMATIC TRANSMISSION

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.

Campaign: 17V657000

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Campaign: 14V743000

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.

Campaign: 14V273000

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Campaign: 16V396000

EQUIPMENT:OTHER:LABELS

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Campaign: 09V223000

EQUIPMENT:OTHER:LABELS

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Campaign: 10V036000

STRUCTURE:BODY:HATCHBACK/LIFTGATE

TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.

Campaign: 08V244000

EQUIPMENT:OTHER:LABELS

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.

Campaign: 09V234000

SEATS

ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

Campaign: 10V270000

EQUIPMENT:OTHER:LABELS

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Campaign: 10V035000

STRUCTURE

TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.

Campaign: 10V160000

STRUCTURE

The contact owns a 2006 Toyota Sienna. The contact stated that while the vehicle was at the dealer for a recall repair, the mechanic discovered large holes in the center of the subframe caused by rust. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 218,000.

WHEELS

The TPMS system failed in the ECM or engine computer. It uses the wheel speed sensors on each hub to measure differences in wheel speed and uses this to infer if any one wheel has low tire pressure. (This vehicle does not have TPMS sensors in the wheels.) However, with this failure, it reports a tire pressure problem even though all 4 tires are inflated properly. This problem persists even after cleaning then replacing wheel speed sensors. The problem appears to be in the ECM or engine computer, which is very difficult and expensive to replace. With this problem, the driver is never able to tell if any tire actually has low pressure because the system always reports that a tire has low pressure. Toyota should be required to fix this issue in all affected vehicles.

UNKNOWN OR OTHER

While driving, there was a recurrent sound like doors locking and unlocking, several dozen times over a half hour drive at 50 miles per hour. When stopped, the passenger side sliding door opened by itself. Luckily, my dogs were in a kennel or they might have jumped out of the car. I closed it and it opened by itself again. At home, the passenger side sliding door opens when my neighbor presses the button on his key fob to open his non-Toyota pickup truck. It will not open or close when I press the button on my Sienna key fob.

TIRES

The contact owns a 2006 Toyota Sienna equipped Hercules Tires, Tire Line: Roadtour 855 SPE, Tire Size: 215/65/R16, DOT Number: U96VH260H21. The contact stated while driving 35 MPH during a trip, the steering wheel started shuddering. The vehicle was taken to a tire shop, and the contact was informed that the two front tires had sustained tread belt separation and bulges. The two front tires were replaced. Additionally, the contact stated while driving 65-70 MPH, the TPMS warning light illuminated. The vehicle was taken to the tire shop, and the contact was informed that the rear passenger's side tire had sustained tread belt separation, and the metallic belt was poking through the rubber. The contact requested that the rear tires be replaced as a precautionary measure. The rear tires were replaced. All four tires were replacement tires. The dealer and the manufacturer were not notified of the failure. The vehicle failure mileage was 173,414. The tire failure mileage was approximately 16,022. The VIN was not available.

UNKNOWN OR OTHER

I am contacting you regarding Toyota Warranty Enhancement Program – ZE6. This concerns sticky and cracking dashboard and glare from this. I had no idea this existed. I own a 2006 and a 2010 sienna. I have not received any mailers from Toyota regarding either Sienna's . My van's dashboards are included in this program. Problem is, I never received notice from Toyota about either dashboard. Is there anything that can be done about this?

STRUCTURE

The contact owns a 2006 Toyota Sienna. The contact stated that while the vehicle was parked, the liftgate was opened and raised; however, the liftgate failed to remain open and raised as intended. The contact stated that when the liftgate was raised, the liftgate independently fell due to faulty liftgate struts. The vehicle was not diagnosed or repaired by an independent mechanic. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to report the failure to the NHTSA Hotline. The failure mileage was unknown. The VIN was unavailable.

STEERING,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

My vehicle steering/control has frozen a few times in the past 18-24 mos. This happens for me in wet conditions at slow speeds while trying to turn, usually to the right. The car also seems to slow on its own and pull to the side at these times. This has also happened while reversing out of a parking spot. I do not recall seeing any lights engage but I am more focused on steering the car safely and exterior factors at these times so I haven't noticed the dashboard. It feels like the power steering fails, and I have no control. Thankfully, I have not been moving at high rates of speed, nor been in a position to go into the lane of on-coming traffic or had someone in a lane near me, and have been able to hold in position or manually turn as much as needed. Steering seems to return once the turn is complete. I have been fearful of hitting someone or being hit from behind each time. My mechanic has been unable to recreate the experience and was unable to suggest a direct answer. I see others have had similar experiences and the same lack of answers from even Toyota. Having come across this website and seeing responses here to this exact problem I have had, I am hoping for more information or a recall soon!

STEERING,POWER TRAIN,SERVICE BRAKES

Bought the van used last year. Previous owner said mechanic could not diagnose the issue. On slight curves similar to on-ramps while accelerating the Vehicle stability control (VSC) will engage unexpectedly, sound an alarm and jerk the steering wheel. Some times to the point of pulling the vehicle out of its lane. Road speed is decreased dramatically as it feels as though the ABS is engaging. This has happened to me at least half a dozen times since June 2023. The condition will continue for maybe five or ten seconds until the wheel is straightened and speed reduced. Searching the Internet seems it's a fairly common problem. The fix might be to replace the steering rack or disable the VSC system. It's reported by those experiencing the issue get little to no help from the dealerships which strikes me as quite strange... From what I've read it seems to affect 2004-2009 Siennas

POWER TRAIN

The bushing for the gear shift is broken causing the lever to disconnect from the cord preventing the vehicle from shifting gears. This caused the vehicle to become stuck in reverse. The car was stuck in reverse when attempting to shift to drive, nearly causing my wife to crash into another vehicle. There are multiple videos on YouTube demonstrating this problem, it is a known issue. The vehicle/component has not been manufactured. No warning lamps, messages or other symptoms.

UNKNOWN OR OTHER,SERVICE BRAKES

Vehicle traction control system will activate around a curve and break the vehicle while the traction control warning system activates. Breaking around a curve in a wet road situation can be very risky. Numerous other Toyota owners have filed similar complaints.