2019 Toyota Sienna

2019 Toyota Sienna VAN AWD

Overall

★★★★★

Front Crash

★★★★☆

Side Crash

★★★★★

Rollover

★★★★☆

2019 Toyota Sienna VAN FWD

Overall

★★★★★

Front Crash

★★★★☆

Side Crash

★★★★★

Rollover

★★★★☆

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Campaign: 20V682000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Campaign: 20V012000

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Sienna vehicles. The passenger front door may have incorrect welds inside, possibly affecting the air bag sensor readings for the passenger side front seat and curtain shield air bags.

Campaign: 19V318000

STEERING

Braun Corporation (Braun) is recalling certain modified 2017-2020 Toyota Sienna vehicles. The steering shaft extensions may have been improperly manufactured, possibly causing the extensions to fracture.

Campaign: 19V532000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.

Campaign: 19V410000

EQUIPMENT:OTHER:LABELS

Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Campaign: 19V503000

EQUIPMENT:OTHER:LABELS

Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Campaign: 19V244000

POWER TRAIN

2019 Sienna XLE with 77,000 miles has a UA80 Transmission is whining at the final gear per Imperial Toyota Milford MA service center. They want to replace the transmission for 9,000 USD and Toyota Corporate refuses assistance. It appear to be a common defect which could lead to transmission lockup if the gear fails.

LATCHES/LOCKS/LINKAGES

The contact owns a 2019 Toyota Sienna. The contact stated that while attempting to open the driver's side sliding door, the door failed to completely open but remained ajar. The contact became aware that an electrical cable was hanging from the door. The vehicle was taken to the dealer, where it was diagnosed, and determined that the cable needed to be replaced. The dealer informed the contact that the door needed to be taken off and reinstalled to repair the vehicle. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 72,000.

UNKNOWN OR OTHER

Started hearing a whining noise upon acceleration. Took car to Toyota for a diagnostic check. Discovered transmission is failing. Recommended repair is a full transmission replacement, quoted 10,000. After bringing to a local mechanic for a second opinion, he claims this is a widespread issue with Toyota Siennas in similar years. After some research, Toyota quietly claims there was an issue in the manufacturing of these transmissions however won’t take accountability

STRUCTURE

About 2 years after the 9/30/2019 purchase (new), the paint on the front engine hood began peeling & cracking. Calls to Parks Toyota were ineffective. Now the entire hood has pervasive cracks. The hood needs to be removed, sanded & painted with a more substantial, long-lasting paint. The paint used is supposed to contain an additional clear coat for protection.

POWER TRAIN

Transmission has failed and been replaced. This is part of issues from 2017 to 2020 tranny failures, loud whining and needing to be replaced. Tranny failure is very dangerous to the occupants. Toyota has failed to warranty these.

UNKNOWN OR OTHER

Lyft deactivated 60yo driver (7yr Lyft, 30yr driving) over vague "unsafe driving". Submitted **20 raw dashcam videos** (Oct 29, 2025) proving: - Full stop at flashing red light - Safe rolling stops (<4 mph) in Toyota Sienna + 3 passengers - Max 28 mph Videos requested by Lyft but ignored. **Tickets:** XXX/ XXX/ XXX **Evidence:** https://drive.google.com/drive/folders/1OIgAwnaAV8Jr8GS4uiUcmqwYodmgCAWy?usp=sharing Lyft violates safety policy (§7.3). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

sever transmission whine started at 138k miles over a year ago.Toyota will not fix issues under recalled ua80 transmission. Said my vin doesn’t fall within recall.

Chest Clip, Buckle, Harness

The Harness Adjuster Strap (item 5 in attached snip from user manual) loosens while in use. This item was manufactured post-recall 24C002000, using Nuna's new design described here: [XXX] This design change did not prevent the functionality of the strap to fail. There was zero to minimal debris (no food, drink, or water) in the mechanism causing it to fail. The Harness Release button (item 4 in snip from user manual) actuates freely. The adjuster strap, and subsequently the entire harness strap, moves freely, while the carseat is loaded or unloaded. I have a video available showing that the strop in the seat freely moving. We discovered the product failure while loading the child in the carseat and testing it's security by pulling on chest straps. Nuna's response was lackluster and unprofessional. Here is the sequence of events: We immediately reported the issue the first business day available, May 27th, and Nuna responded 24hrs later, informing us they would again respond in 1-2 business days to send us a form and shipping label to send back the defective product. We responded the same day asking them to expedite the process and send us a new product immediately as we had no backup for a carseat and my wife could not leave the home. A little over 48 hrs later they denied our request, and sent us the shipping and RMA form. We are now a full business week past the initial request and now are returning the carseat, with no assurance of when the replacement will be delivered. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Transmission UA80e is a poorly designed transmission. It almost caused an accident due to the transmission lunching forward on its own. Also has a whine coming from the transaxle. There is a customer service program for the 2017-2018 models about this issue. But I have a 2019 and not eligible for the program. Would like for Toyota to make this right. Less than 5 year old van.

AIR BAGS

My van was struck directly in the driver side rear sliding door while sitting still at a stop sign. The other driver collided straight into the passenger compartment door at an approximate speed of 30 mph crushing the door, exploding the window and neither the driver side airbags nor the side curtain airbags deployed. Resulting in my wife severely jarring around in the driver's seat, as well as my son who was securely fastened in a child booster seat in the driver side rear seat. The glass from the rear door window shattered and covered my son and the interior of the vehicle. There are no active recalls, but I read about a recall concerning the passenger side door welds that could affect operation of the side airbag and side curtain airbag sensors, but this only applied to a small number of 2019 Sienna's. Could this have been a manufacturing defect that bled over to the other door structures affecting the sensors in the same way.