2002 Toyota Tacoma

2002 Toyota Tacoma 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★☆☆☆

2002 Toyota Tacoma Extended Cab

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.

Campaign: 12V542000

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E065000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

Campaign: 05V225000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.

Campaign: 03V189000

STEERING,SUSPENSION,FORWARD COLLISION AVOIDANCE

Rackandpinon replacement was also the upper and lower ball joints my steering is still giving me problems and I feel like it’s asafty concern because if I’m going down the highway I could loose control I have some receipts for what my mechanic replaced I called Toyota and they told me that it was to late to fix anything and that I would have to deal with it I never received a notice in the mail or anywhere else I feel like Toyota owes me Also what has happened is my spare tire feel off from the hanger going up my driveway I got to looking and the cable rusted away along with my rear parking brake cable up under the truck thanks for your time

SUSPENSION,STRUCTURE

Found hole in frame (chassis)

SUSPENSION

I recently lost both front wheels in two different incidents within a month. Early August drivers side ball joint failed on me. And on September 25th the passenger side failed on me on the freeway almost causing a collision with a mercedes and a semi truck.

SUSPENSION

As I was pulling out from being parked the truck just dropped to the floor on the drivers side. When I got out to see what happened? My wheel broke off at the lower ball joint yesterday evening. I had to wait 2 hours for a tow. I had no warning or symptoms prior.

SUSPENSION

The contact owns a 2002 Toyota Tacoma. The contact stated that while driving approximately 50 MPH, the front passenger’s side wheel separated from the vehicle, causing the driver to lose control of the steering and drove into the opposite lane. The vehicle was later towed to the local dealer who diagnosed that the front suspension ball joint had failed and needed to be replaced. The contact was also informed that the front shocks, front tires, and front brakes were also damaged during the failure, and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was 443,000.

AIR BAGS,UNKNOWN OR OTHER

My air conditioning is not working right blowing hot air. Had it charged and no change, I believe that I have the same issue as others, My air bags light keeps going off and on when driving. I see where there was a recall on other Toyota vehicles that had the same problem as me.

UNKNOWN OR OTHER

We heard they issued a recall for faulty frames. When someone told us this we contacted Toyota. They said it had expired. I never received a recall of any kind.i take excellent care of my vehicles and this Tacoma only roughly 98,000 miles. The body is great shape, it runs great. My question is if the frame should break and we're going 65mph, who is responsible if someone is killed. We did not know about the recall and we certainly would have had them fix it. Is there any way you can help us resolve this issue with Toyota? Thank you in advance.

SUSPENSION

The contact owns a 2002 Toyota Tacoma. The contact stated while an independent mechanic was servicing the vehicle, the contact was informed that the rear sub frame was severely rusted at the spring shackle on the driver's side. The vehicle was then taken to an auto body shop, where it was determined that the sub frame needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 225,000.

STRUCTURE

The contact's daughter owns a 2002 Toyota Tacoma. The contact stated that several independent mechanics and an auto body repair shop had informed her that there was a hole in the subframe, and the subframe was significantly corroded. The vehicle was taken to the dealer who informed the contact that the vehicle was unsafe to drive. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 138,000.

SUSPENSION,STRUCTURE,UNKNOWN OR OTHER

I went to get my 02 tacoma tires balanced and was called and told that where the frame was cracked. Upon inspecting it myself the crack is where the manufacturer welded the frame together. I'm the 3rd owner of this vehicle and there original owner didn't get frame warranty recall done. Which led to it running out. Now Toyota corporate has a frame case number ([XXX]) and was told that there's nothing that could be done until enough complaints about this case number reaches a certain number then they'll look into it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)