2002 Volkswagen Golf

2002 Volkswagen Golf 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Campaign: 14E007000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Campaign: 07V063000

EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH

ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.

Campaign: 04V584000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Campaign: 07E023000

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).

Campaign: 02V031000

TIRES

The tire sidewall blew out. We were driving at 65 mph on an interstate highway in an urban area and had to change the tire in the triangular space between the highway lanes and an exit - very dangerous. These were sold as 60,000 mile tires, and this tire had 20,200 miles on it. It was maintained at proper pressure. Conditions were clear, dry, summer weather in Albuquerque, NM. The problem has not yet been confirmed by the service center, but we will be taking the damaged tire there because it is still under warranty. Tire size: 195 / 65 R 15

STRUCTURE

Certain conditions cause the electrics door locks to not function. When this happens, it is not possible to exit the car from the inside as the door handles are not operative creating a trapped situation potentially leading to injury or death if the case of a fire.

AIR BAGS

WHILE DRIVING AT ABOUT 45 MILES PER HOUR, THE SIDE CURTAIN AND SEAT BOLSTER AIRBAGS DEPLOYED ON THEIR OWN. THERE WAS NO IMPACT TO THE VEHICLE THAT PRECEDED THIS INCIDENT. THE AIRBAGS SIMPLY DEPLOYED BY THEMSELVES. THIS SEEMS TO BE A RECURRING PROBLEM WITH THIS GENERATION OF VOLKSWAGENS: HTTP://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/GOLF/2002/SEAT_BELTS_AIR_BAGS/AIR_BAGS-SIDE_WINDOW.SHTML

ENGINE

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN GOLF WITH A TDI ENGINE. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT HAD TO POP THE CLUTCH AND KILL THE IGNITION, BUT THE ENGINE CONTINUE TO OPERATE UNTIL THE VEHICLE RAN OUT OF FUEL. THE CONTACTS MECHANIC INSPECTED THE VEHICLE AND STATED THAT THE TURBO CHARGER SEALS WERE NOT LEAKING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 53,000. *TR

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS 2002 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START IN RAINY WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE IGNITION COIL WOULD NEED TO BE REPLACED. THE CONTACT LOCATED A VOLUNTARY MANUFACTURERS RECALL FOR THE FAILURE BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE VOLUNTARY RECALL. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 150,000.

AIR BAGS

ON SATURDAY AUG 7TH I WAS DRIVING MY 2002 VW GOLF ON THE HIGHWAY WHEN THE PASSENGER SIDE AIRBAG DEPLOYED. THE ROAD WAS SMOOTH WITH NO BUMPS OR POTHOLES, NOTHING HIT THE CAR, IT WAS TOTALLY SPONTANEOUS. LUCKILY THERE WERE NO PASSENGERS IN THE CAR. I HAVE CONTACTED MY LOCAL VW SERVICE SHOP AND WILL TAKE THE CAR IN SO THEY CAN IDENTIFY THE CAUSE OF THE DEPLOYMENT. *TR

AIR BAGS

PASSENGER SIDE CURTAIN AIRBAG DEPLOYED WHILE TRAVELING DOWN THE HIGHWAY. NO COLLISION, CONSEQUENCES RINGING IN EARS. VOLKSWAGEN MADE REPAIR AT NO COST TO ME $3212.00. *TR

SEAT BELTS

AIR BAG LIGHT CAME ON. WHEN TAKEN IN FOR FIX IT WAS FOUND TO BE A FAULTY SWITCH IN THE DRIVER SIDE SEAT BELT BUCKLE. IT WAS JUST RECENTLY REPLACED AND SO FAR NO FURTHER PROBLEMS. *TR

VISIBILITY,STRUCTURE

WHILE DRIVING MY WIFE WAS DRIVING OUR 2002 VW GOLF THE DRIVER SIDE WINDOW DROPPED. TURNS OUT ALL OVER THE INTERNET THERE ARE COMPLAINTS OF THE TABS HOLDING THE WINDOWS BREAKING. IN FACT WHEN I WAS AT THE DEALER I FELLOW OVERHEARD ME AND SAID HE HAD THE EXACT SAME PROBLEM ON HIS 2001 VW GTI. VW HAD A TSB AND EXTENDED THE WARRANTY BY A FEW YEARS ON THIS BUT IS SHOULD HAVE BEEN A RECALL. A WINDOW DROPPING IS A HUGE SAFETY FACTOR FOR A NUMBER OF REASONS. THE WINDOW IS A PROTECTION DEVICE TO SHIELD YOU IN AN ACCIDENT OR FROM DEBRIS AT 65MPH AND FOR YOUR OWN PERSONAL SAFETY IF ON THE WRONG SIDE OF TOWN. I CALLED THE VW DEALER TO SEE IF THEY WOULD FIX THIS PROBLEM THEY SAID YES THEY WOULD FIX IT FOR FREE YET UPON ARRIVING I WAS TOLD I WAS ONE MONTH OUT OF THE EXTENDED WARRANTY. THE DROPPING OF THIS WINDOW CAUSED MY WIFE TO HAVE TO PULL OVER ON A BUSY EXPRESSWAY BECAUSE SHE COULD NOT SEE IN THE RAIN WITH IT BLOWING IN HER WINDOW. ONCE A GAIN A FAULTY WINDOW HOLDING MECHANISM IS A SAFETY ISSUE AND SHOULD BE A RECALL ITEM. *TR

AIR BAGS

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN GOLF. WHILE DRIVING 70 MPH ON THE FREEWAY, THE PASSENGER SIDE AIR BAG SPONTANEOUSLY DEPLOYED. THERE WERE NO INJURIES, BUT THE CONTACT WAS CONCERNED ABOUT THE SUDDEN EXPLOSION. HE STATED THAT THE DEPLOYMENT OCCURRED WHILE HE WAS USING HIS CELLULAR PHONE. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 70,000.