2005 Volkswagen Golf

2005 Volkswagen Golf 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Campaign: 14E007000

FUEL SYSTEM, DIESEL

ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.

Campaign: 04V586000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Campaign: 07E023000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Campaign: 07V063000

SERVICE BRAKES

Brake Booster Vacuum Line Fell off making me run a red light I could not stop the car in time. After getting the car stopped about 100 feet past the light I found that the Brake Booster Vacuum Line fell off its made of hard plastic that has become brittle it cracked at both ends. There was no warning lights even after it fell off. The part number of the hose is 130-612-041 I just wanted to let someone know before people start getting hurt...

SEAT BELTS

I GOT IN THE CAR THIS MORNING TO HEAD TO WORK, I REACHED BACK TO PULL THE SEAT BELT FORWARD AND AROUND MY LAP. NEXT THING I KNEW THE BELT WAS FULLY EXTENDED AND WOULD NOT RETRACT AT ALL. I HAD NO TENSION LEFT IN THE SEAT BELT AND IT HUNG OVER ME COMPLETELY EXTENDED. NOW I AM DRIVING WITH THIS COMPLETELY LOOSE SEAT BELT AROUND ME, AND NO PROTECTION IF I AM IN AN ACCIDENT.

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

WHEN DRIVING THE CAR IT WAS RUNNING FINE AND THEN ALL OF A SUDDEN DIED ON ME AND WOULD RESTART THEN DIED AGAIN BEFORE I COULD MOVE IT OUT OF THE WAY. NOW WHEN I START IT, IT DIES IMMEDIATELY.

AIR BAGS

I MOVE MY PASSENGER SEAT BACK AND FOR NO REASON THE AIRBAG CAME ON, IT WOULD NOT RESET.

AIR BAGS

TAKATA RECALL - I WAS IN ACCIDENT ON 5/24/16 AND THE FRONT OF MY CAR WAS ALL DAMAGED BUT THE AIRBAG DID NOT INFLATE CAUSING ME TO HIT THE STEERING WHEEL

FUEL SYSTEM, GASOLINE

WHEN EXITING THE FREEWAY, THE FUEL LIFT PUMP DIED AND THE CAR STALLED ON THE EXIT RAMP AT 55 MPH. I LOST CONTROL OF POWER BRAKES AND POWER STEERING BUT WAS ABLE TO COAST OFF THE RAMP TO THE STOP LIGHT AT THE END OF THE RAMP. *TR

AIR BAGS

MULTIPLE AIRBAG FAILURES 01218 - SIDE AIRBAG IGNITER; PASSENGER SIDE (N200) 001 - UPPER LIMIT EXCEEDED - INTERMITTENT - MIL ON 01217 - SIDE AIRBAG IGNITER; DRIVER SIDE (N199) 001 - UPPER LIMIT EXCEEDED - INTERMITTENT - MIL ON THE DTC'S SEEM TO BE GENERATED DURING COLD WEATHER PERIODS WHEN THE SEATS ARE MOVED. THIS HAPPENS AT LEAST 1 - 2 TIMES PER YEAR. VEHICLE HAS NEVER BEEN MOVING WHEN THESE CODES WERE GENERATED. DEALER HAS COMPLETED THE TSB FOR THE DRIVERS SIDE AIRBAG WIRING, BUT THE PROBLEM IS STILL OCCURRING. PASSENGER SEAT DOES NOT HAVE A TSB FOR THE AIRBAG WIRING. DEALER REQUIRES THAT THE CODE BE CLEARED AT THE DEALERSHIP FOR $100 PER INCIDENT. PROBLEMATIC AIRBAGS ARE DISABLED UNTIL THE FAULT CODE IS CLEARED FROM THE SYSTEM. BOTH CODES HAVE APPEARED MULTIPLE TIMES, AT LEAST 4, ON THIS SAME VEHICLE AND THIS PROBLEM IS ALSO FOUND ON MULTIPLE VW MODELS. *TR

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

THE TURN SIGNAL CLICKER CONTINUES CLICKING AFTER THE SIGNAL HAS BEEN DE-ACTIVATED. THIS DEFECT LEADS TO PEOPLE NOT USING THE SIGNAL AS THEY DO NOT WANT TO RISK LISTENING TO THE ANNOYING CLICKING THAT SOMETIMES GOES ON FOR HOURS. *TR

FUEL SYSTEM, DIESEL

THE VEHICLE IS MAINTAINED ACCORDING TO MANUFACTURER GUIDELINES AND BY CERTIFIED MECHANICS AT VOLKSWAGEN DEALER SERVICE CENTER. LESS THAN A WEEK AFTER THE LAST MAINTENANCE, FUEL TANK EXPLODED WHILE DRIVING. BOTTOM OF THE CAR IS DAMAGED RIGHT UNDER REAR PASSENGER SEATS. BASED ON INITIAL REPORT FROM DEALER SERVICE DEPARTMENT, DUE TO INTERNAL PRESSURE BUILD-UP THERE WAS NO FIRE (THE CAR IS DIESEL). UPDATED 06/23/10.*JB *TR

EXTERIOR LIGHTING,INTERIOR LIGHTING

VOLKSWAGEN 2005 GOLF: BOTH FRONT EXTERIOR LIGHTS, DAY TIME AND NIGHT TIME WENT OUT. THE FUSE WAS GOOD AND THE LIGHT BULBS WERE OUT. APPARENTLY, THE WIRING HAD A MALFUNCTION WHICH ALSO CAUSED THE INTERIOR LIGHT ON THE CLIMATE CONTROLS TO GO OFF. THE FUSE WAS GOOD AS WELL. ANOTHER MALFUNCTION FROM THEVW COMPANY. LASTLY, DRIVER SIDE FRONT WINDOW WENT DOWN WHILE DRIVING TO WORK 25 MPH. I DID NOT TOUCH THE WINDOW NOR TRIED TO OPEN OR CLOSE IT, IT WENT DONE COMPLETELY AND IT IS INSIDE THE DOOR...IT WON'T GO UP NOR DOWN. IT IS NOT BROKEN EITHER. IT IS VERY DANGEROUS TO DRIVE WITH NO WINDOW IN THE WINTER. SNOW, HAIL. RAIN CAN HAPPEN WHILE THE WINDOW WENT DOWN WHILE DRIVING. IT'S VERY UNPLEASANT TO HAVE WIND AND COLD OF 3 DEGREES BELOW ZERO HIT YOUR FACE AND GO IN THE CAR TO THE OTHER PASSENGERS. THE HAIL, RAIN OR SNOW CAN THAT CAN GET IN THE CAR CAN CAUSE FURTHER DAMAGE INSIDE THE CAR. *TR