2002 Volkswagen Jetta

2002 Volkswagen Jetta 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2002 Volkswagen Jetta 4-DR. Wagon w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Campaign: 14E007000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Campaign: 07V063000

EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH

ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.

Campaign: 04V584000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Campaign: 07E023000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.

Campaign: 06V183000

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).

Campaign: 02V031000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.

Campaign: 04V096000

AIR BAGS

I was driving on the freeway and the airbags deployed. No one hit me and I don't hit anyone.

POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

WHILE GOING 55 CAR DROPPED TORQUE AND GEARED DOWN FORCING CAR REV VERY HIGH RPMS, NOSE DIP. JERK ME INTO ON COMING LANE. LUCKILY NOTHING WAS COMING.

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

ONE DAY WAS RUNNING 75 TODAY WON'T SHIFT OUT OF 2ND GEAR TRANSMISSION HOLDBACK FEELS LIKE

POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

WHILE THE VEHICLE IS IN MOTION, IT "JERKS" OR MAKES A SHAKING MOVEMENT. WHILE THE VEHICLE IS IN MOTION, THE "DOOR AJAR" LIGHT STAYS ON ALTHOUGH ALL DOORS HAVE BEEN OPENED AND CLOSED. WHILE STATIONARY, THE VEHICLE BRAKE LIGHT IS NOT WORKING. WHILE STATIONARY AND IN MOTION, THE VEHICLE'S CHECK ENGINE LIGHT STAYS ON. THE REAR MIDDLE PASSENGER SEATBELT IS NOT USEABLE. THE DRIVER'S DOOR REMAINS UNLOCKED AFTER PRESSING THE "LOCK DOORS" BUTTON.

FUEL/PROPULSION SYSTEM

WHILE MAINTAINING SPEED AT OR ABOVE 40 MPH AND WITH 1/4 TANK OR LESS OF FUEL REMAINING, MY JETTA WILL CONSISTENTLY STALL OUT AND TURN OFF FROM FUEL STARVATION. THIS HAS HAPPENED TO ME BETWEEN 40 AND 80 MPH SEVERAL TIMES, BOTH IN THE CITY AND ON THE HIGHWAY. I HAVE REPLACED THE CRANKSHAFT POSITION SENSOR, THE FUEL SENDER, AND THE FUEL PUMP WITH NO SUCCESS. ADDITIONALLY, THE JETTA WILL DIE THE FIRST TIME I TRY TO START IT AS MY FUEL LEVEL APPROACHES 1/4, ESPECIALLY IF I AM PARKED ON AN INCLINE. HOWEVER, IT NEVER FAILS TO START ON THE SECOND TRY ONCE SOME FUEL HAS BEGUN MOVING THROUGH THE SYSTEM. FULLY REFUELING ALLEVIATES ALL PROBLEMS.

ELECTRICAL SYSTEM

KNOWN MELTING FUSE BOX ON TOP OF BATTERY. FROM SCHEMATICS, APPEARS S180 FUSE (COOLANT FAN) AS PREDOMINANT POINT OF FAILURE. ISSUE HAS BEEN REPORTED (VIA WEB) ACROSS NUMEROUS MODELS AND YEARS. CALLED VW FOR FIX; AS TECHS APPEAR VOID OF A GENERAL CONSENSUS TO PROBLEM/FIX. UNFORTUNATELY, VW REFUSES TO ACKNOWLEDGE AND/OR PROVIDE SOLUTION TO CUSTOMER(S). REFERS ME TO DEALER, WHICH IS OVER AN HOUR AWAY. JUST NEED INFO TO ORDER REPAIR KIT AND RESTORE VEHICLE INTEGRITY/SAFETY. CONCERNED AS THIS MAY BE A POTENTIAL FIRE HAZARD; DUE TO THE VOLUME OF HEAT GENERATED BY WIRING WITHIN INTERNAL COMPARTMENT. IN TURN, I UNDERSTAND THE AGE OF THE VEHICLE IS OUTSIDE THE NORMAL WARRANTY PERIOD. AS STATED, JUST WANT AN ANSWER TO REPAIR; HOWEVER, VW CUSTOMER CARE REP COMMENTED I SHOULD REPORTING THIS ISSUE IN HOPES TO DRAW ADDITIONAL ATTENTION OF OTHER OWNERS AND, EVENTUALLY, THE NHTSA TO GET VW TO RESPOND TO CUSTOMERS QUESTIONS.

AIR BAGS

SIMPLY WANTED TO LET YOU KNOW THAT MY DAUGHTER REAR ENDED ANOTHER CAR AT 40MPH AND COMPLETELY CRUNCHED IN HER FRONT END (CAR IS TOTALED), BUT THE AIRBAGS DID NOT DEPLOY. WE DIDN'T THINK ANYTHING OF IT UNTIL THE STATE FARM AGENT MENTIONED THAT SHE HAD AIRBAGS ON THE CAR.

POWER TRAIN

THE SHIFTER FIRST LOCKED UP IN HEAVY TRAFFIC, THEN LATER CAME COMPLETELY LOOSE IN TRAFFIC. THE VW PARTS DEPARTMENTS SAID THIS PROBLEM HAS HAPPENED SO MUCH THAT NO ONE WITHIN 200 MILES HAD THE PARTS IN STOCK AS THEY WERE SOLD OUT. VW REFUSED TO COOPERATE WITH THE BETTER BUSINESS BUREAU IN RESOLUTION. THE BBB TOLD ME TO REPORT TO THE NHTSA>

ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT WAS GETTING AN ALLERGIC REACTION FROM THE INTERIOR OF THE VEHICLE. THE CONTACT STATED THERE WAS AN ODOR EMITTING FROM THE VEHICLE, WHICH CAUSED THE REACTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

SEATS

TL* THE CONTACT OWNS A 2002 VOLKWAGEN JETTA. WHILE OPERATING THE VEHICLE WITH THE FRONT SEAT WARMERS ACTIVATED, THE FRONT PASSENGER WAS BURNED WHEN THE SEAT WARMER MALFUNCTIONED. MEDICAL ATTENTION WAS NOT NEEDED. THE FAILURE BURNED A HOLE THROUGH THE FRONT PASSENGER SEAT. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.