1993 Volkswagen Passat

1993 Volkswagen Passat 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.

Campaign: 92V058000

SUSPENSION:FRONT

LOCK NUTS USED TO HOLD THE LEFT AND RIGHT FRONT AXLES TO THE SUSPENSION STRUTS MAY NOT HAVE BEEN PROPERLY MANUFACTURED. THE LOCK NUTS MAY BREAK AND CAUSE SEPARATION OF THE AXLE FROM THE SUSPENSION STRUTS.

Campaign: 93V118000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.

Campaign: 95V178000

ENGINE AND ENGINE COOLING

HEATER CORE BAD IN 1993 VW GLX, VERY COMMON IN MY EXPERIENCE. *TR

FUEL SYSTEM, GASOLINE

TL*THE CONTACT OWNS A 1993 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE FUEL LEAKS AT THE END OF THE HOSE AND HE SMELLED GAS. THE VEHICLE DID NOT RUN AS EFFECTIVELY WHEN THE FUEL BEGAN LEAKING. THE FAILURE OCCURRED WHILE DRIVING 35 MPH. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 115,000.

SEAT BELTS

FRONT SEAT BELTS FAIL TO POWER, MUST USE EMERGENCY BELTS. *JB

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

FUEL LEAKAGE IN THE ENGINE COMPARTMENT AND NOISY FAN MOTOR SHAFT. FOUND TWO RECALLS REFERRING TO THESE TWO PROBLEMS. NEVER RECEIVED RECALL LETTERS FROM MANUFACTURER. *JB

ENGINE AND ENGINE COOLING

FAULTY HEATER CORES/HEATER EXCHANGERS LOCATED BEHIND THE DASHBOARD IS A PERVASIVE PROBLEM. HEATER CORE LEAKED. *BF ANTI FREEZE LEAKED INTO THE PASSENGER COMPARTMENT AROUND THE FEET OF THE PASSENGER. THE CONSUMER FOUND THAT THIS WAS A COMMON PROBLEM. RECALL# 98V295000. *SC

ENGINE AND ENGINE COOLING

TURN ON AIR CONDITIONER, OR HEATER, AND A STEAM OF ANTIFREEZE COATS WINDSHIELD, AND IT GETS COMPLETELY FOGGED OVER TO THE POINT WHERE I CANNOT SEE. HAS OCCURRED NUMEROUS TIMES. 1993, PASSAT GLX. VR6. *AK

VISIBILITY

VEHICLE WAS AT A COMPLETE STOP WHEN STEAM STARTED COMING THROUGH THE AIR VENTS AND THE WINDOWS FOGGED UP. HOT ANTI FREEZE LEAKED IN AND SCORCHED THE DRIVER'S FEET. THIS OCCURRED BECAUSE THE HEATER CORE CAME APART AT THE SEAM. *AK *JB

POWER TRAIN

WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE PROBLEM STILL OCCURS. *MR

VISIBILITY

LETTER CONCERNING THE MANNER IN WHICH VOLKSWAGEN CHOOSE TO HANDLE A RECENT FAILURE ON THE CONSUMERS VEHICLE. (NAR) *PH WHILE DRIVING THE CONSUMER VEHICLE HEATER CORE EXPLODED. *CB

VISIBILITY

WHILE DRIVING AT ROUGHLY 25 MPH, HEATER CORE FAILED. INTERIOR OF VEHICLE IMMEDIATELY BEGAN FILLING WITH FOUL SMELLING DENSE SMOKE, AND WINDOWS BECAME COATED WITH A FILM. DRIVER QUICKLY PULLED OFF THE ROAD, WHICH FORTUNATELY WAS EASY AS WE WERE IN A RESIDENTIAL NEIGHBORHOOD. DRIVER AND PASSENGERS BELIEVED THE ENGINE WAS ON FIRE, AS THE TRUE CAUSE OF THE FAILURE WAS NOT IMMEDIATELY KNOWN. WE QUICKLY EVACUATED ALL 4 PASSENGERS, INCLUDING A 5 YEAR OLD CHILD WHO WAS STRAPPED IN A CAR SEAT. THIS WAS A TERRIFYING EXPERIENCE. WE HAD EXITED A BUSY FREEWAY LESS THAN 1 MINUTE BEFORE. IF THIS FAILURE HAD OCCURRED WHILE WE WERE STILL ON THE FREEWAY, WE MAY NOT HAVE BEEN ABLE TO PULL OFF THE ROAD SAFELY PRIOR TO THE DRIVER'S VISION BEING COMPLETELY IMPAIRED. THIS COULD HAVE PROVED DISASTROUS. AFTER THE ISSUE WAS IDENTIFIED, AND WE BEGAN TO DO SOME RESEARCH, WE WERE VERY UPSET TO FIND THAT THIS APPEARS TO BE A RECURRING PROBLEM WITH OUR VEHICLE. WE WERE ALSO STUNNED TO READ THE COMPLAINT SUMMARIES ON THE NHTSA SITE WHICH NOTED THAT SOME DRIVERS/PASSENGERS WERE INJURED BY HOT STEAM/COOLANT LEAKING INTO THE PASSENGER COMPARTMENT. IT IS AMAZING THAT A TECHNICAL SERVICE BULLETIN OR RECALL HAS NOT YET BEEN ISSUED FOR THIS PROBLEM. AS OF THE TIME THIS COMPLAINT IS BEING FILED, WE ARE ALSO DRAFTING A LETTER TO VOLKSWAGEN TO URGE THEM TO ADDRESS THIS FAILURE. A FAILURE THAT CAN CAUSE TOTAL LOSS OF VISIBILITY IN A BRIEF PERIOD OF TIME, AND THEREFORE LOSS OF CONTROL OF A VEHICLE, SHOULD BE CONSIDERED EXTREMELY SERIOUS. WE STRONGLY URGE THE NHTSA TO TAKE APPROPRIATE MEASURES TO ENSURE THAT THIS FAILURE IS ADDRESSED.*AK