2001 Volkswagen Passat

2001 Volkswagen Passat 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Campaign: 14E007000

FUEL SYSTEM, GASOLINE:DELIVERY

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Campaign: 08V156000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.

Campaign: 01V157000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Campaign: 02V026000

SERVICE BRAKES

My fuses keep blowing, this is leading to replacing the Brake switch which I believe was recalled. If it was replaced,it's not working.

AIR BAGS

The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking locks unlocked twice while I was driving the car. After the second time, I tried to lock the car doors by pressing the lock button on the driver's door console but the doors would not locked. At that time I noticed that the two interior lights in the back seat area were turned on. All the doors of the car were properly shut. When the airbags deployed I was driving on the smooth 1 year old concrete section of Hwy 494. I did not hit anything on the highway. After the deployment, I parked on the shoulder, shut off the engine and opened the passenger door to air out the car. After about 5 minutes, I got back in the car and drove home. The automatic locks worked again. The interior lights automatically turned off. The drive home was uneventful.

ENGINE,FUEL/PROPULSION SYSTEM

TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE UPGRADE. I NEVER RECEIVED ANY RECALL NOTICES IN THE MAIL. NOW VW WANTS TO BUY THE CAR BACK BECAUSE THEY CAN'T FIX IT. IT'S A 2001 VW PASSAT WITH 25K MILES IN SHOWROOM SHAPE. WAS NEVER DRIVEN IN SNOW AND GARAGED IT'S ENTIRE LIFE. THEY OFFERED ME $1500 OUT OF WHICH I OWE $1300 FOR THE TIMING BELT. THEY SAID IT MAY NEED A ECU BUT THEY ARE NO LONGER AVAILABLE FROM VW BUT REFUSE TO INSTALL A USED ONE. THE CAR HAS BEEN AT THE VW DEALER SINCE 12/28/2020. I WAS UNDER THE IMPRESSION THAT RECALLS NEVER EXPIRE.

VEHICLE SPEED CONTROL,SERVICE BRAKES

ABS LIGHT ON AND BREAK LIGHT FLASHING

FUEL/PROPULSION SYSTEM

STARTED SMELLING GAS AND MILEAGE STARTED DROPPI G BAD AROUND THE END OF NOVEMBER. WE SEE THAT THERE HAS BEEN RECALLS ON THE GAS TANK AND FUEL LINES FOR 01 VOLKSWAGEN PASSATS BUT UNFORTUNATELY NOT FOR THIS VIN # WHICH HAPPENS TO BE MY SONS CAR. NOW ITS AT THE SHOP BECAUSE ITS GAS MILEAGE WENT WAY DOWN AND AND SMELLS LIKE GAS AND HE WAS TOLD THAT HE WAS DRIVING A BOMB BASICALLY. IT COULD BE AROUND $1000 TO FIX IT. NONE OF US HAVE THAT KIND OF $ AND HES STILL HAS $800 LEFT OWEING ON IT. HELP

ENGINE

FAULTY CAM CHAIN TENSIONER FAILED AND CAUSED SEVERE ENGINE DAMAGE TO VALVES, PISTONS, CAMSHAFT, CAM TIMING CHAIN. I WAS STATIONARY WAITING AT A RED LIGHT WHEN I HEARD A SUDDEN LOUD GRINDING NOISE FROM INSIDE THE ENGINE COMPARTMENT, THE ENGINE BEGAN TO SHAKE AND SPUTTER. THE CAR LOST MOST OF ITS POWER AND I WAS BARELY ABLE TO MAKE IT THROUGH THE INTERSECTION WHEN THE LIGHT TURNED GREEN. UPON INSPECTION IT WAS CLEAR TO SEE THAT THE CAM CHAIN TENSIONER HAD SELF DESTRUCTED AND CAUSED THE ENGINE TO FAIL.

FUEL/PROPULSION SYSTEM

MY 2001 VOLKSWAGEN PASSAT HAS HAD AN R5 RECALL FOR FUEL LINES, FUEL TANK, AND A HEAT SHIELD. THE HARD (LOW PRESSURE FUEL RETURN?) LINE, THE MIDDLE ONE OF THE MOUNTING BRACKET ATOP THE FIREWALL, HAS FAILED CATASTROPHICALLY. IT NOW SPRAYS GASOLINE DIRECTLY DOWN ONTO THE CATALYTIC CONVERTER HEAT SHIELD. THIS IS THE SAME FAILURE IN THE SAME EXACT POINT THAT MANY OTHER OWNERS HAVE HAD. THIS PART IS DANGEROUS AND COULD HAVE KILLED ME AND DESTROYED MY CAR. VOLKSWAGEN REFUSED TO FIX IT. I'VE BEEN IN CONTACT WITH VW CUSTOMER CARE AND MY LOCAL DEALER, BOTH TOLD ME THAT ONCE THE RECALL IS CLOSED ON MY VEHICLE THAT THERE IS NOTHING THEY'LL DO. THEY WANTED ME TO TOW MY CAR TO THE DEALERSHIP AND PAY $135 FOR A DIAGNOSTIC UNTIL I SHOWED THEM A VIDEO OF THE FUEL LINE UNDER PRESSURE SPRAYING EVERYWHERE.

AIR BAGS

MY CAR IS A 2001 MODEL, AND I'D LIKE TO KNOW IF IT HAS TAKATA AIRBAGS IN IT, EVEN IF IT ISN'T COVERED BY THE RECALL. DEALER DOESN'T KNOW IF THE AIRBAGS ARE TAKATA OR NOT. CAN YOU GIVE ME THIS INFORMATION?? I HOPE SO, OTHERWISE I DON'T KNOW HOW TO FIND OUT. THANKS [XXX] *DL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*JB

SERVICE BRAKES

ABS CONTROL MODULE FAULT

POWER TRAIN

AS MY SON GOT ON THE HIGHWAY THE TRANSMISSION FELT LIKE IT WAS SLIPPING AND JERKING TO THEN CATCH BACK UP TO THE ORIGINAL SPEED I WAS GOING. WHEN HE PUT HIS FOOT ON THE GAS PEDAL THE CAR WOULD STRUGGLE TO GO, 5 SECONDS LATER IT WOULD GET UP TO SPEED BUT THEN SLOW BACK DOWN. AT A STOPLIGHT THE CAR WOULD SHAKE ROUGHLY AND IDLE REALLY HIGH, THEN HE SAW THE FRONT OF THE HOOD START TO SMOKE AND I REALIZED THERE WAS A PROBLEM.